Defoamer A
Page 1 of 3
MATERIAL SAFETY DATA SHEET
SECTION I: IDENTIFICATION OF PRODUCT
PRODUCT NAME: Defoamer 鈥淎鈥? (Alcohol)
PRODUCT USE: Oil Well Fluid Additive
CHEMICAL FAMILY: Aliphatic Alcohol
WORK PLACE HAZARDOUS MATERIALS INFORMATION SYSTEM (WHMIS)
WHMIS CLASSIFICATION: Controlled Product Under WHMIS
WORK PLACE HAZARD: Mildly Toxic with Skin / Eye Contact and Ingestion
TRANSPORTATION OF DANGEROUS GOODS (TDG)
SHIPPING NAME: Isopropyl alcohol
TDG CLASSIFICATION: 3
UN NUMBER (PIN): 1219
PACKING GROUP: II
SECTION II: HAZARDOUS INGREDIENTS
INGREDIENT PERCENT CAS NUMBER LD(50) Oral-Rat OSHA PEL ACGIH TLV
Isopropyl alcohol 98 67-63-0
Sodium silicate 2 6834-92-0
SECTION III: TOXICOLOGICAL PROPERTIES
ROUTE OF ENTRY: [ ] SKIN [ ] EYE CONTACT [ ] INHALATION [ ] INGESTION
EYE CONTACT : May cause injury to eye tissue if not removed promptly
SKIN CONTACT: Frequent or prolonged exposure may irritate skin and cause dermatitis. Low order toxicity.
INGESTION: Minimal toxicity. Small amounts of liquid aspirated into the respiratory system during
ingestion or from vomiting may cause bronchopneumonia or pulmonary enema
INHALATION: May cause irritation to respiratory system
Defoamer A
Page 2 of 3
MATERIAL SAFETY DATA SHEET
SECTION IV: FIRST AID MEASURES
SKIN CONTACT: Wash skin with soap and water.
EYE CONTACT: If splashed into the eyes, flush with clear water for 30 minutes or until irritation subsides.
Consult an eye physician
INGESTION: If ingested, DO NOT induce vomiting. Keep at rest. Contact Physician immediately.
INHALATION: Remove patient to fresh air. Apply artificial respiration as required
SECTION V: PHYSICAL DATA
APPEARANCE AND ODOUR: Slight red tint liquid, smells like alcohol
SPECIFIC GRAVITY: .79
BOILING POINT (掳F): 180 - 181 掳F
MELTING POINT (掳F): -128 掳F
SOLUBILITY IN WATER: 100.00 @ 68掳F
PERCENT VOLATILE BY VOLUME: N/A
EVAPORATION RATE: 2.3
VAPOUR PRESSURE (mm Hg): N/A
BULK DENSITY (lb/ft3): N/A
SECTION VI: FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: 54 掳F
FLAMMABLE LIMITS: Upper 12.7 77 掳F Lower 2.0
EXTINGUISHING MEDIA: Water spray, alcohol type foam, dry chemical
SPECIAL FIRE FIGHTING PROCEDURES: Self-contained respirators required for fire fighting personnel.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None
SECTION VII: REACTIVITY DATA
STABILITY: Stable [XX] Unstable [ ]
INCOMPATIBILITY (CONDITIONS TO AVOID): Avoid causyics. amines, alkanolamines, aldehydes, strong
oxidizing agents, and chlorinated compounds.
Defoamer A
Page 3 of 3
MATERIAL SAFETY DATA SHEET
CONDITIONS OF REACTIVITY: N/A
HAZARDOUS DECOMPOSITION PRODUCTS: None
HAZARDOUS POLYMERIZATION: Will Not Occur [XX] May Occur [ ]
VIII: PREVENTIVE MEASURES
SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION Suggest NIOSH/MESA Approved respirator.
VENTILATION As needed to control vapours.
PROTECTIVE GLOVES Suggest rubber
EYE PROTECTION Suggest goggles; Safety glasses
OTHER PROTECTIVE EQUIPMENT (Specify) Ensure eye-wash station and emergency shower is available.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Do not store near food or drink. Approved respirator and safety goggles should be worn while handling this material.
Wash thoroughly after handling this material.
STEPS TO BE TAKEN IN CASE THE MATERIAL IS SPILLED OR RELEASED
Eliminate sources of ignition. Prevent additional discharge of material; prevent material from entering sewers,
watercourses, or low areas. Contain spill with sand or earth, do not use sawdust or combustible material to absorb
material.
WASTE DISPOSAL METHOD
Dispose of in accordance with federal, provincial and local regulations. It is the responsibility of the user to determine if
contaminated material meets hazardous waste requirements.
SECTION IX: PREPARATION
THE INFORMATION CONTAINED HEREIN IS GIVEN IN GOOD FAITH, BUT NO WARRANTY, EXPRESSED OR
IMPLIED, IS MADE.
DATE PRINTED: April 6, 2006 BY: MILLENNIUM TECHNOLOGIES LTD.
DATE MODIFIED: May 5, 2004 APPROVED BY:
SUPERSEDES: October 1, 2003
|