MTL Power Clean 2000
Page 1 of 3
MATERIAL SAFETY DATA SHEET
SECTION I: IDENTIFICATION OF PRODUCT
PRODUCT NAME: MTL POWER CLEAN 2000
PRODUCT USE: Heavy Duty Degreaser
CHEMICAL FAMILY: Blended Mixture
WORK PLACE HAZARDOUS MATERIALS INFORMATION SYSTEM (WHMIS)
WHMIS CLASSIFICATION: D-2 (B)
WORK PLACE HAZARD: Skin and Eye Irritant
TRANSPORTATION OF DANGEROUS GOODS (TDG)
SHIPPING NAME: Corrosive liquid NOS (MTL Power Clean 2000)
TDG CLASSIFICATION: Class 8
UN NUMBER (PIN): 1760
PACKING GROUP: II
SECTION II: HAZARDOUS INGREDIENTS
INGREDIENT PERCENT CAS NUMBER LD(50) Oral-Rat OSHA PEL ACGIH TLV
D鈥? limonene 5-15% 5989-27-5 N/A N/A N/A
Potassium Hydroxide 1-5% 1310-58-3 365 mg/kg N/A N/A
Polyxyalkylated AlkylarylPhosphate Ester 5-10% 51811-79-1 1530 mg/kg N/A N/A
Nonylphenoxy Poly Ethanol, Branched 5-10% 68412-54-4 1746 mg/kg N/A N/A
SECTION III: TOXICOLOGICAL PROPERTIES
ROUTE OF ENTRY: [XX] SKIN [XX] EYE CONTACT [ ] INHALATION [ ] INGESTION
EYE CONTACT: May cause irritation to the eyes
SKIN CONTACT: May cause irritation and defatting of skin
INGESTION: May cause irritation to throat, nausea, vomiting, diarrhea, and gastrointestinal distress
INHALATION: May cause irritation to respiratory system
MTL Power Clean 2000
Page 2 of 3
MATERIAL SAFETY DATA SHEET
SECTION IV: FIRST AID MEASURES
SKIN CONTACT: Wash skin thoroughly with soap and water. If irritation or rash develops, obtain Medical
assistance
EYE CONTACT: If splashed into the eyes, flush with clear water for 15 minutes or until irritation subsides. If
irritation persists, call a physician.
INGESTION: DO NOT induce vomiting. If vomiting occurs keep airways clear, seek medical attention.
INHALATION: Remove patient to fresh air. Apply artificial respiration as required, consult physician.
SECTION V: PHYSICAL DATA
APPEARANCE AND ODOUR Clear, pale straw liquid; citrus odour
SPECIFIC GRAVITY 1.06
BOILING POINT ( C) >100 C
MELTING POINT ( C) N/A
pH: 13.0
SOLUBILITY IN WATER Soluble
PERCENT VOLATILE BY VOLUME N/A
EVAPORATION RATE N/A
VAPOUR PRESSURE (mm Hg) N/A
BULK DENSITY (lb/ft3) 1.06 (g/ml)
SECTION VI: FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: None
FLAMMABLE LIMITS: None
EXTINGUISHING MEDIA: Carbon dioxide, dry powder, foam, and water.
SPECIAL FIRE FIGHTING PROCEDURES: Self-contained respirators required for fire fighting personnel.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None Know
SECTION VII: REACTIVITY DATA
STABILITY: Stable [XX] Unstable [ ]
MTL Power Clean 2000
Page 3 of 3
MATERIAL SAFETY DATA SHEET
INCOMPATIBILITY (CONDITIONS TO AVOID): Strong acids, or oxidizing agents
CONDITIONS OF REACTIVITY: None
HAZARDOUS DECOMPOSITION PRODUCTS: Burning can produce Carbon Monoxide, dioxide, and
nitrogen oxides.
HAZARDOUS POLYMERIZATION: Will Not Occur [XX] May Occur [ ]
VIII: PREVENTIVE MEASURES
SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: Not required.
VENTILATION: Suggested local mechanical exhaust.
PROTECTIVE GLOVES: Chemical impermeable
EYE PROTECTION: Suggest goggles
OTHER PROTECTIVE EQUIPMENT (Specify): Ensure eyewash station and emergency shower is available.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
Avoid ingestion. Practice reasonable caution and personal cleanliness. Avoid skin and eye contact. Avoid product
from freezing. Store away from heat, flame and spark source.
STEPS TO BE TAKEN IN CASE THE MATERIAL IS SPILLED OR RELEASED
Use appropriate safety equipment. Soak up with absorbent material and place in proper disposal container.
WASTE DISPOSAL METHOD
Dispose of in accordance with federal, provincial and local regulations. It is the responsibility of the user to
determine if contaminated material meets hazardous waste requirements.
SECTION IX: PREPARATION
THE INFORMATION CONTAINED HEREIN IS GIVEN IN GOOD FAITH, BUT NO WARRANTY, EXPRESSED OR
IMPLIED, IS MADE.
DATE PRINTED: April 6, 2006 BY: MILLENNIUM TECHNOLOGIES LTD.
DATE MODIFIED: May 17, 2004 APPROVED BY:
SUPERSEDES: October 1, 2003
|