ACCUMETRIC LLC
350 RING ROAD
ELIZABETHTOWN, KY 42701
MATERIAL SAFETY DATA SHEET
__________BOSS 344 SUPERSTIK FAST CURE____________
SECTION 1. CHEMICAL PRODUCT AND COMPANY INFORMATION
MATERIAL IDENTITY:
PRODUCT NAME: BOSS庐 344 SUPERSTIK FAST CURE
HIGH STRENGTH ELASTOMERIC
ADHESIVE/SEALANT
COMPANY:
ACCUMETRIC LLC
350 RING ROAD
ELIZABETHTOWN, KY 42701
270-769-3385
EMERGENCY TELEPHONE NUMBERS:
1-800-928-2677
_____________________________________________________________
SECTION 2. COMPOSITION/INFORMATION ON INGREDIENTS
CHEMICAL CHARACTERIZATION:
DESCRIPTION: SEALANT THAT IS SOLVENT-FREE, ISOCYANATE-FREE
MOISTURE-CURING ODOURLESS ONE-PART MS POLYMER.
DANGEROUS COMPONENTS:
VOID
_____________________________________________________________
SECTION 3. HAZARDS IDENTIFICATION
HAZARD DESCRIPTION:
NOT APPLICABLE
INFORMATION PERTAINING TO PARTICULAR DANGERS FOR MAN AND
ENVIRONMENT:
NOT APPLICABLE
CLASSIFICATION SYSTEM:
THE CLASSIFICATION WAS MADE ACCORDING TO THE LATEST
EDITIONSOF THE EU-LISTS, AND EXPANDED UPON FROM COMPANY AND
LITERATURE DATA.
_____________________________________________________________
SECTION 3. FIRST AID MEASURES
EYES:
FLUSH EYES GENTLY WITH WATER WHILE HOLDING EYELIDS APART. IF
SYMPTOMS PERSIST, OR THERE IS ANY VISUAL DIFFICULTY, SEEK
MEDICAL ATTENTION.
SKIN:
REMOVE CONTAMINATED CLOTHING. WASH EXPOSED AREA WITH SOAP
AND WATER. IF SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION.
LAUNDER CLOTHING BEFORE USE.
SWALLOWING:
SEEK MEDICAL ATTENTION. IF INDIVIDUAL IS DROWSY OR UNCONCIOUS,
DO NOT GIVE ANYTHING BY MOUTH; PLACE INDIVIDUAL ON THE LIFT
SIDEWITH THE HEAD DOWN. CONTACT A PHYSICAN, MEDICAL FACILITY,
OR POISON CONTROL CENTER FOR ADVICE ABOUT WHETHER TO INDUCE
VOMITING. IF POSSIBLE, DO NOT LEAVE INDIVIDUAL UNATTTENDED.
INHALATION:
IF SYMPTOMS DEVELOP, MOVE INDIVIDUAL AWAY FROM EXPOSURE AND
INTO FRESH AIR. IF SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION. IF
BREATHING IS DIFFICULT, ADMINISTER OXYGEN. KEEP PERSON WARM
AND QUIET; SEEK IMEDICATE MEDICAL ATTENTION.
NOTE TO PHYSICANS:
PREEXISTING DISORDERS OF THE FOLLOWING ORGANS (OR ORGAN
SYSTEMS) MAY BE AGGRAVATED BY EXPOSURE TO THIS MATERIAL:
RESPIRATORY TRACT, SKIN, LUNG (FOR EXAMPLE, ASTHMA-LIKE
CONDITIONS).
_____________________________________________________________
SECTION 5. FIRE FIGHTING MEASURES
SUITABLE EXTINGUISHING AGENTS (CO虏, EXTINGUISHING POWDER OR
WATER SPRAY).
FOR SAFETY REASONS UNSUITABLE EXTINGUISHINGAGENTS (WATER WITH
FULL JET).
SPECIAL HAZARDS CAUSED BY THE MATERIAL, ITS PRODUCTS OF
COMBUSTION OR RESULTING GASES:
IN CASE OF FIRE, THE FOLLOWING CAN BE RELEASED:
CALCIUM OXIDE
CARBON MONOXIDE (CO)
PROTECTIVE EQUIPMENT
WEAR SELF-CONTAINED RESPIRATORY PROTECTIVE DEVICE.
FIRE AND EXPLOSION HAZARDS:
NEVER USE WELDING OR CUTTING TORCH ON OR NEAR DRUM (EVEN
EMPTY) BECAUSE PRODUCT (EVEN JUST RESIDUE) CAN IGNITE
EXPOSIVELY.
EXTINGUISHING MEDIA:
REGULAR FOAM, ALCOHOL FOAM, WATER FOG, CARBON DIOXIDE, DRY
CHEMICAL.
FIRE FIGHTING INSTRUCTIONS:
WATER OR FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT AND
POSSIBLY ENDANGER THE LIFE OF THE FIREFIGHTER. WEAR A SELF-
CONTAINED BREATHING APPARATUS WITH A FULL FACEPIECE OPERATED
IN THE POSITIVE PRESSURE DEMAND MODE WITH APPROPRIATE TURN-
OUT GEAR AND CHEMICAL RESISTANT PERSONAL PROTECTIVE
EQUIPMENT. REFER TO THE PERSONAL PROTECTIVE EQUIPMENT SECTION
OF THIS MSDS.
_____________________________________________________________
SECTION 6. ACCIDENTAL RELEASE MEASURES
PERSON-RELATED SAFETY PRECAUTIONS:
PARTICULAR DANGER OF SLIPPING ON LEAKED/SPILLED PRODUCT.
ENSURE ADEQUATE VENTILATION.
USE RESPIRATORY PROTECTIVE DEVICE AGAINST THE EFFECTS OF
FUMES/DUST/AEROSOL.
MEASURES OF ENVIRONMENTAL PROTECTION:
DO NOT ALLOW PRODUCT TO REACH SEWAGE SYSTEM OR ANY WATER
COURSE.
MEASURES FOR CLEANING/COLLECTING:
ABSORB WITH LIQUID-BINDING MATERIAL (SAND, DIATOMITE, ACID
BINDERS, UNIVERSAL BINDERS, SAWDUST).
_____________________________________________________________
SECTION 7. HANDLING AND STORAGE
HANDLING:
ENSURE GOOD VENTILATION/EXHAUSTION AT THE WORKPLACE. OPEN
AND HANDLE RECEPTACLE WITH CARE. KEEP IGNITION SOUCES AWAY-DO
NOT SMOKE.
STORAGE:
REQUIREMENTS TO BE MET BY STOREROOMS AND RECEPTACLES:
STORE ONLY IN THE ORIGINAL RECEPTACLE.
FURTHER INFORMATION ABOUT STORAGE CONDITIONS:
KEEP RECEPTACLE TIGHTLY SEALED
STORE IN DRY CONDITIONS
STORE IN COOL PLACE
CONTAINER OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED.
SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR,
LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THE DATA
SHEET MUST BE OBSERVED.
_____________________________________________________________
SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION
EYE PROTECTION:
CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH ISHA REGULATIONS
ARE ADVISED; HOWEVER OSHA REGULATIONS ALSO PERMIT OTHER TYPE
SAFETY GLASSES.
SKIN PROTECTION:
WEAR RESISTANT GLOVES SUCH AS: NITRILE RUBBER, BUTYL RUBBER, TO
PREVENT REPEATED OR PROLONGED SKIN CONTAC, WEAR INPERVIOUS
CLOTHING AND BOOTS.
RESPIRATORY PROTECTIONS:
IF WORKPLACE EXPOSURE LIMITS OF PRODUCT OR ANY COMPONENT IS
EXCEEDED (SEE EXPOSURE GUIDELINES), A NIOSH/MSHA APPROVED AIR
SUPPLIED RESPIRATOR IS ADVISED, IN ABSENCE OF PROPER
ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO PERMIT OTHER
NIOSH/MSHA RESPIRATORS (NEGATIVE PRESSURE TYPE) UNDER SPECIFIED
CONDITIONS (SEE YOUR INDUSTRIAL HYGIENIST). ENGINEERING OR
ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
_____________________________________________________________
SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES
BOILING POINT: UNDETERMINED
FLASH POINT: NOT APPLICABLE
SPECIFIC VAPOR DENSITY: 20掳C 1.53
SELF IGNITING: PRODUCT IS NOT SELF IGNITING
DANGER OF EXPLOSION: PRODUCT IS NOT EXPLOSIVE. HOWEVER,
FORMATION OF EXPLOSIVE AIR/VAPOUR
MIXTURES ARE POSSIBLE.
FORM: PASTY
COLOR: GREY, WHITE, BLACK
ODOR: LIGHT
_____________________________________________________________
SECTION 10. STABILITY AND REACTIVITY
THERMAL DECOMPOSITION / CONDITIONS TO BE AVOIDED:
NO DECOMPOSITIONS IF USED ACCORDING TO SPECIFICATIONS.
DANGEROUS PRODUCTS OF DECOMPOSITION:
NONE TO OUR KNOWLEDGE AT ROOM TEMPERATURE.
_____________________________________________________________
SECTION 11. TOXICOLOGICAL INFORMATION
ACUTE TOXICITY:
PRIMARY IRRITANT EFFECT:
SKIN: IRRITANT TO SKIN AND MUCOUS MEMBRANES
EYE:
IRRITATING EFFECT
SENSITIZATION:
SENSITIZATION EFFECT THROUGH INHALATION IS POSSIBLE WITH
PROLONGED EXPOSURE.
_____________________________________________________________
SECTION 12. ECOLOGICAL INFORMATION
DO NOT ALLOW PRODUCT TO REACH GROUND WATER, WATER COURSE OR
SEWAGE SYSTEM.
_____________________________________________________________
SECTION 13. DISPOSAL CONSIDERATION
WASTE MANAGEMENT INFORMATION:
DESTROY BY LIQUID INCINERATION IN ACCORDANCE WITH APPLICABLE
REGULATIONS.
THE PACKAGING MAY BE DECONTAMINATED FOR EXAMPLE WITH A
MIXTURE OF SODIUM CARBONATE AND 95% OF WATER.
_____________________________________________________________
SECTION 14. TRANSPORTATION INFORMATION
LAND TRANSPORT ADR/RID (cross-border)
REMARKS: Not Hazardous
MARITIME TRANSPORT IMDG:
MARINE POLLUTANT: Yes
REMARKS: Not Hazardous
AIR TRANSPORT ICAO-TI AND IATA-DGR:
PROPER SHIPPING NAME: Not Regulated
_____________________________________________________________
THE INFORMATION CONTAINED HEREIN IS BASED ON THE DATA
AVAILABLE AS OF THE DATA OF PREPARATION OF THIS MSDS AND WHICH
WE BELIEVE TO BE RELIABLE. HOWEVER, NO WARRANTY IS EXPRESSED
OR IMPLIED REGARDING THE ACCURACY OF THE DATA. WE SHALL NOT BE
RESPONSIBLE FOR THE USE OF THIS INFORMATION, OR OF ANY PRODUCT,
METHOD, OR APPARATUS MENTIONED. AND THE USER MUST MAKE HIS
OWN INVESTIGATION TO DETERMINE THE SUITABILITY OF THE
INFORMATION OR PRODUCTS FOR HIS PARTICULAR PURPOSE, FOR THE
PROTECTION OF THE ENVIRONMENT, AND THE HEALTH AND SAFETY OF
THE USERS OF THIS MATERIAL.
DATE PREPARED: NOVEMBER 20TH 2003
|