Material Safety Data Sheet
72 Red 鈥? Anaerobic Adhesive
庐
TELEPHONE 715-832-4557
1. Product Identification
Product Name ADHESIVE R&D 72 Red
Product Anaerobic Adhesive
2. Composition
Ingredients CAS# WT%
Aromatic dimethacrylate ester 24448-20-2 40-50
Polglycol dimethacrylate 25852-47-5 20-30
Bisphenol A fumarate resin 39382-25-7 10-20
Hydroxyalkyl methacylate 27813-02-1 5-10
Cumene Hydroperoxide* 80-15-9 1-3
Maleic Acid 110-16-7 .1-1
Saccharin 81-07-2 .1-1
This component is listed as a SARA Section 313 toxic chemical.
Ingredients that Have Exposure Limits
Exposure Limits (TWA) ACGIH OSHA Other
Ingredients (TLV) (PEL)
Cumene Hydroperoxide None None 1ppm(6mg/m3)
Skin (Weel)
3. Hazards Identification
Toxicity Severe eye irritant. Moderate skin irritant. Possible inhalation irritant.
May be harmful if swallowed.
Primary Routes of Entry Skin, eyes, inhalation, ingestion
Symptoms of Exposure May cause severe dermatitis on prolonged contact in sensitive individuals.
Existing Conditions Aggravated by Exposure None Known
4. First Aid Measures and Personal Protection
Note: See supplemental page or emergency procedures and additional First Aid information.
Ingestion Do not induce vomiting. Keep individual calm. Obtain medical attention.
Inhalation Does not apply
Skin contact Wash with soap and water.
Eye contact Flush at least 15 minutes with water. Obtain medical attention.
5. Fire Fighting Measures
Flash Point More than 200藲F Method: Tag Closed Cup
Extinguishing Agents Carbon dioxide, foam, dry chemical.
Special Fire Fighting
Procedures Not available.
Hazardous Products Formed by
Fire or Thermal Decomp Irritating organic vapors.
Unusual Fire or Explosion Hazards None
Explosive Limits
(% by volume in air) Lower Not available
(% by volume in air) Upper Not available
6. Accidental Release Measures
If a spill or leak occurs, maintain adequate ventilation. Soak up in an inert absorbent. Store in partly filled closed container until disposal.
7. Handling and Storage
Storage Store below 100掳F
Handling Avoid prolonged contact with skin. Keep away from eyes. Avoid breathing vapors.
8. Exposure Controls, Personal Protection
Eyes Chemical safety glasses or goggles.
Skin Rubber or plastic gloves.
Ventilation Sufficient to maintain vapor concentration below TLV.
Respiratory OSHA approved respirator if ventilation is inadequate.
9. Physical and Chemical Properties
Appearance Green Liquid
Odor Mild
Boiling Point More than 300掳F
Ph Does not apply
Solubility in Water Slight
Specific Gravity 1.11 at 80藲F
VOC 38.4%; 426 grams per liter (EPA Method 24)
Vapor Pressure Less than 5mm at 80藲F
Vapor Density Not available
Evaporation Rate Not available
10. Stability and Reactivity
Stability Stable
Hazardous Polymerization Will not occur
Incompatibility None
Conditions to Avoid Not available
Hazardous Decomposition Products (Non Thermal) None
11. Toxicological Information
Oral LD50 more than 1000 mg/kg
Estimated dermal LD50 more than 200 mg/kg
12. Ecological Information
No data available.
13. Disposal Considerations
Recommended Methods of Disposal Incinerate following EPA and local regulations
EPA Hazardous Waste Number NH - Not a RCRA Hazardous Waste Material.
14. Transportation Information
DOT (49CFR 172) Domestic Ground Transport
Proper Shipping Name Unrestricted
Hazard Class or Division Unrestricted
Identification Number None
Marine Pollutant None
IATA
Proper Shipping Name Unrestricted
Class or Division Unrestricted
UN or ID Number None
15. Regulatory Information
CA Proposition 65: Warning this product contains chemicals known to the State of California to cause cancer and birth defects or other
reproductive harm. Propylene oxide (ppb levels of arsenic, Cd, Pb, Ni), This product contains Saccharin. No Prop 65
hazard warning is necessary if this product is used as reasonably anticipated.
16. Other Information
Estimated NFPA 庐 Code
Health Hazard 1
Fire Hazard 1
Reactivity Hazard 1
Specific Hazard Does not apply
Estimated HMIS 庐 Code
Health Hazard 1*
Flammability Hazard 1
Reactivity Hazards 1
Personal Protection See Section 8.
NFPA庐 is a registered trademark of the National Fire Protection Association.
HMIS庐 is a registered trademark of the National Fire Protection Association.
We believe the information contained herein is current and accurate as of this date of this Material Safety Data Sheet. Since the use of this information and these opinions and the
conditions of use of this product are not under the control of ADHESIVE R&D庐, Inc. or it鈥檚 agents or distributors, it is the user鈥檚 obligation to determine the conditions of safe use of
this product. The buyer should conduct its own tests of this product before use to determine proper preparation technique and suitability for proposed application. ADHESIVE R&D庐,
Inc. warrants that the product conforms with ADHESIVE R&D庐鈥檚 written specifications, and is free from defects and disclaims all other warranties, expressed or implied and is
not responsible for loss claim of damages resulting from the use of it鈥檚 products.
Rev 01/03
|