ACCUMETRIC LLC
350 RING ROAD
ELIZABETHTOWN, KY 42701
INFORMATION PHONE NUMBER: (270) 769-3385
EMERGENCY PHONE NUMBER (DAY): (270) 769-3385
EMERGENCY PHONE NUMBER (NIGHT): (270) 769-3385
MATERIAL SAFETY DATA SHEET
______________________________________________________________________________
SECTION 1 - PRODUCT
BOSS庐 383 CONSTRUCTION ADHESIVE
NAME:
CLASS: ADHESIVE
CAS NO.: NONE-MIX
UN NO.: UN1133
E M I S HAZARD CODES
HEALTH: 2 MODERATE
FLAMMABILITY: 3 SERIOUS
REACTIVITY: 0 MINIMAL
PERSONAL PROTECTIVE
EQUIPMENT: G
______________________________________________________________________________
SECTION II - HAZARDOUS INGREDIENTS
INGREDIENT PERCENT BY C.A.S. LEL VAPOR
MATERIAL WEIGHT REGISTRY NO. PRESSURE mm
DESCRIPTION Hg @ 20 C
ACETONE < 10 67-64-1 3. 56.3
HEXANE 10 - 20 110-54-3 1. 180
TOLUENE <10 108-88-3 1. 23.0
______________________________________________________________________________
SECTION 111 - PHYSICAL DATA
130 - 150oF
BOILING RANGE:
VAPOR PRESSURE: >100 mm @ 20oC
SPEC GRAVITY: 1.44
EVAPORATION RATE: FASTER
(relative to n-butyl acetate)
ODOR THRESHOLD: NO DATA
N/A oF
FREEZING POINT:
VAPOR DENSITY: HEAVIER THAN AIR
H2O SOLUBLE: NEGLIGIBLE (<0.1%)
% VOLATILE BY
VOLUME: 40 - 50%
pH: NO DATA
APPEARANCE
AND ODOR: TAN SEMI-PASTE WITH STRONG SOLVENT ODOR.
______________________________________________________________________________
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
<0.0oF
FLASH POINT:
(METHOD USED) TAG
FLAMMABILITY CLASSIFICATION:
OSHA FLAMMABLE LIQUID CLASS IB
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL
EXPLOSIVE LIMITS:
LEL UEL (% V IN AIR)
1.1 13.0
DOT: FLAMMABLE LIQUID
SPECIAL FIRE FIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND PROTECTIVE
CLOTHING. USE WATER TO COOL EXPOSED CONTAINERS. WATER
STREAM DIRECTED INTO FIRE MAY CAUSE FROTHING WITH
SUBSEQUENT SPREAD OF FIRE.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
IRRITATING AND/OR TOXIC GASES OR FUMES MAY BE GENERATED BY
THERMAL DECOMPOSITION OR COMBUSTION. CLOSED CONTAINERS
MAY RUPTURE OR EXPLODE (DUE TO PRESSURE BUILD-UP) WHEN
EXPOSED TO EXTREME HEAT. VAPOR IS HEAVIER THAN AIR, AND MAY
TRAVEL ALONG THE GROUND TO BE REIGNITED AT LOCATIONS
DISTANT FROM THE SOURCE; FLASHBACK OF FLAME MAY OCCUR.
______________________________________________________________________________
SECTION V - TOXICOLOGICAL INFORMATION
INGREDIENT PEL TLV (twa) LD50 (mg/kg) LC50 (ppm)
MATERIAL ppm mg/mg3 - ppm (rat) - (rbt) (rat)
DESCRIPTION oral - dermal INHAL
750. 1780. - 750. N/A - 20.0g/kg N/A
ACETONE
(STEL=1000.
ppm)
50. 176. - 50.0 N/A - N/A N/A
HEXANE
100. 375. - 100.0 7000.0 - 4000.0 8000.0
TOLUENE
(STEL=150. ppm)
______________________________________________________________________________
SECTION VI - HEALTH HAZARD DATA
EFFECTS OF OVEREXPOSURE: THRESHOLD LIMIT VALUES: SEE SECTION V
EFFECTS OF ACUTE OVEREXPOSURE:
EYES: MODERATE IRRITANT. MAY CAUSE REVERSIBLE
CORNEAL INJURY.
SKIN: MODERATE IRRITANT. MAY CAUSE DERMATITIS AND
ALLERGIC RESPONSES.
INHALATION: RESPIRATORY IRRITANT, INTOXICANT, AND CENTRAL
NERVOUS SYSTEM DEPRESSANT. OVEREXPOSURE
SHOWN BY HEADACHE, DIZZINESS, AND CONFUSION
TO COMA.
INGESTION: MAY CAUSE IRRITATION OF MOUTH, THROAT, AND
STOMACH. SYMPTOMS INCLUDE NAUSEA,
ABDOMINAL PAIN AND POSSIBLE PNEUMONITIS.
***PREEXISTING PULMONARY AND DERMATOLOGICAL DISORDERS MAY
BE AGGRAVATED BY EXPOSURE TO HAZARDOUS COMPONENTS.
CHRONIC OVEREXPOSURE INFORMATION:
*NONE OF THE COMPONENTS OF THIS PRODUCT ARE LISTED AS KNOWN OR
SUSPECTED CARCINOGENS PER NTP, IARC, OR OSHA.
**PERIPHERAL POLYNEUROPATHY HAS BEEN SHOWN TO OCCUR IN INDIVIDUALS
EXPOSED REPEATEDLY TO N-HEXANE IN THE 1000 - 1500 ppm RANGE. EVIDENCE
IN LABORATORY ANIMALS AND HUMANS INDICATES THAT THE PRESENCE OF
METHYL ETHYL KETONE OR METHYL ISOBUTYL KETONE THE NEUROPATHY
ASSOCIATED WITH N-HEXANE IS PRODUCED IN A SHORTER TIME AT A LOWER
EXPOSURE LEVEL.
***ANIMAL STUDIES HAVE SHOWN THAT INHALATION OF HIGH LEVELS OF
TOLUENE PRODUCED CARDIAC SENSITIZATION SUCH SENSITIZATION MAY
CAUSE FATAL CHANGES IN HEART RHYTHMS. THERE IS NO EVIDENCE THAT
EXPOSURE TO VAPOR LEVELS AT OR BELOW THE TVL HAVE PRODUCED
CARDIAC EFFECTS IN HUMANS.
****STUDIES SUGGEST THAT SOLVENT CHRONIC OVEREXPOSURE AND/OR
SYSTEMATIC TOXICITY EFFECTS ARE TARGETED AT THE KIDNEYS AND
CENTRAL NERVOUS SYSTEM.
EMERGENCY FIRST AID PROCEDURES:
EYES: FLUSH WITH PLENTY OF WATER AT LEAST 15
MINUTES. OBTAIN IMMEDIATE MEDICAL ATTENTION.
SKIN: REMOVE CONTAMINATED CLOTHING. WASH
AFFECTED AREA(S) THOROUGHLY WITH SOAP AND
WATER. CONSULT A PHYSICIAN.
INHALATION: REMOVE TO FRESH AIR. IF BREATHING ID DIFFICULT,
GIVE OXYGEN. ADMINISTER ARTIFICIAL
RESPIRATION IF NOT BREATHING. OBTAIN MEDICAL
ATTENTION.
INGESTION: DO NOT INDUCE VOMITING.
GIVE WATER OR MILK IF VICTIM IS CONSCIOUS AND
NOT DROWSY. SHOULD VOMITING OCCUR, BE SURE
TO KEEP VICTIM'S HEAD BELOW HIPS TO AVOID
ASPIRATION OF VOMITUS INTO THE LUNGS. OBTAIN
IMMEDIATE MEDICAL ATTENTION.
______________________________________________________________________________
SECTION VII B REACTIVITY DATASECTION VII B REACTIVITY DATASECTION
VII B REACTIVITY DATA
STABILITY: STABLE
STABILITY CONDITIONS TO AVOID: SOURCES OF IGNITION
INCOMPATIBILITY (MATERIALS TO AVOID CONTACT WITH): STRONG BASES
OR OXIDANTS. STRONG LEWIS OR MINERAL ACIDS.
HAZARDOUS DECOMPOSITION PRODUCTS: ACRID SMOKE. OXIDES OF CARBON.
______________________________________________________________________________
SECTION VIII - SPILL OR LEAK PROCEDURES
STEPS FOR MATERIAL SPILLAGE:
VENTILATE AREA. WEAR APPROPRIATE PROTECTIVE EQUIPMENT
DURING CLEANUP. ELIMINATE SOURCES OF IGNITION. CONTAIN SPILL.
ABSORB WITH INERT MATERIAL. SWEEP OR SHOVEL INTO CONTAINERS
WITH LIDS. COVER LOOSELY AND REMOVE TO APPROPRIATE WASTE
AREA. WASH SPILL AREA WITH SOAP AND WATER. PREVENT WASHING
FROM ENTERING WATERWAYS.
WASTE DISPOSAL METHOD:
REVIEW ALL LOCAL, STATE AND FEDERAL REGULATIONS CONCERNING
HEALTH AND POLLUTION FOR APPROPRIATE DISPOSAL PROCEDURES.
______________________________________________________________________________
SECTION IX - SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION:
IF THE TLV IS EXCEEDED, IF USE IS PERFORMED IN A POORLY VENTILATED
SPACE OR AREA WITH LIMITED VENTILATION, USE NIOSH-APPROVED ORGANIC
VAPOR CARTRIDGE RESPIRATOR IN ACCORDANCE WITH 29 CFR 1910.134. IF
VAPOR LEVELS ARE 10 X TLV OR GREATER, OR IF USE IS PERFORMED IN
ACCORDANCE WITH APPLICABLE HEALTH AND SAFETY REGULATIONS.
VENTILATION: LOCAL EXHAUST AS NEEDED TO CONTROL VAPOR/DUST
LEVELS TO BELOW RECOMMENDED LIMITS.
PROTECTIVE GLOVES: NEOPRENE, NITRILE
EYE PROTECTION: CHEMICAL SAFETY GLASSES
OTHER PROTECTIVE EQUIPMENT: ACCESSIBLE EYE WASH AND SAFETY
SHOWER. CLEAN PROTECTIVE CLOTHING.
______________________________________________________________________________
SECTION X - SPECIAL PRECAUTIONS
HANDLING AND STORAGE PRECAUTIONS:
DO NOT TAKE INTERNALLY.
AVOID CONTACT WITH EYES, SKIN, AND CLOTHING.
AVOID BREATHING VAPOR.
WASH THOROUGHLY AFTER HANDLING.
TIGHTLY RESEAL ALL PARTIALLY USED CONTAINERS.
USE ONLY WITH ADEQUATE VENTILATION.
STORE AWAY FROM SOURCES OF IGNITION.
EXTINGUISH ALL PILOT LIGHTS BEFORE USE.
KEEP OUT OF REACH OF CHILDREN.
EMPTY CONTAINERS MAY CONTAIN DANGEROUS VAPORS OR RESIDUES. STORE
EMPTY CONTAINERS AWAY FROM HEAT AND FLAMES.
OTHER INFORMATION:
*N/A = INFORMATION OR DATA NOT AVAILABLE***
**NTP = NATIONAL TOXICOLOGY PROGRAM
**IARC = INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
**NIOSH = NATIONAL INSTITUTE OF OCCUPATIONAL SAFETY AND
HEALTH
**ACGIH = AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL
HYGIENISTS
**OSHA = OCCUPATION SAFETY AND HEALTH ADMINISTRATION
***PEL = PERMISSIBLE EXPOSURE LIMIT (8-HR. TWA) (OSHA)
***TLV = THRESHOLD LIMIT VALUE (8-HR. TWA) (ACGIH)
***STEL = SHORT-TERM EXPOSURE LIMIT (OSHA)
______________________________________________________________________________
SECTION XI - REGULATORY DATA
CALIFORNIA VOC: 2.8 lbs./gal
CALIFORNIA PROP 65: CONTAINS TOLUENE WHICH HAS BEEN LISTED BY
THE STATE OF CALIFORNIA AS A SUBSTANCE KNOWN
TO CAUSE REPRODUCTIVE HARM.
TRANSPORTATION
DOT UN
HAZARD CLASS FLAMMABLE LIQUID FLAMMABLE LIQUID
UN/NA NUMBER UN1133 UN1133
SHIPPING NAME ADHESIVE (HEXANE) ADHESIVE (HEXANE,
TOLUENE)
PLACARD AT 1000 LBS N/A
CLASS NUMBER 3 AIR: 3 - MARINE: 3.1
SUBSID. RISK N/A AIR: N/A - MARINE N/A
PACKING GROUP N/A AIR: II - MARINE II
REPORTING:
CERCLA REPORTABLE QUALITY:
AS PRODUCT: 8 lbs. AS WASTE: 100 lbs.
SARA SECTION 304 EMERGENCY RESPONSE REPORTABLE QUANTITY: NONE
SARA SECTION 311/312 INVENTORY REPORTING (Y/N): Y
SARA SECTION 311/312 HAZARD CLASS(ES): ACUTE, DELAYED HEALTH, FIRE
SARA SECTION 313 RELEASE REPORTING CHEMICALS: TOLUENE, 634%;
ACETONE, 4.8%
COMPONENTS ON TSCA INVENTORY (Y/N): Y
DISPOSAL:
EPA RCRA WASTE CLASS: IGNITABLE
EPA RCRA WASTE NUMBER: D001
CALIFORNIA LIST LAND BAN (Y/N): Y
______________________________________________________________________________
THIS INFORMATION IS FURNISHED WITHOUT WARRANTY, REPRESENTATION, OR
LICENSE OF ANY KIND, EXCEPT THAT THIS INFORMATION IS ACCURATE TO THE
BEST OF ACCUMETRIC'S KNOWLEDGE OR IS OBTAINED FROM SOURCES
BELIEVED BY ACCUMETRIC TO BE ACCURATE. NO WARRANTY IS EXPRESSED OR
IMPLIED REGARDING THE ACCURACY OF THIS INFORMATION OR THE RESULTS
TO BE OBTAINED FROM ITS USE THEREOF. ACCUMETRIC ASSUMES NO
RESPONSIBILITY FOR INJURIES PROXIMATELY CAUSED BY USE OF THE
MATERIAL IF REASONABLE SAFETY PROCEDURES ARE NOT FOLLOWED AS
STIPULATED IN THIS DATA SHEET. ADDITIONALLY, ACCUMETRIC ASSUMES NO
RESPONSIBILITY FOR INJURIES PROXIMATELY CAUSED BY ABNORMAL USE OF
THE MATERIAL EVEN IF REASONABLE SAFETY PROCEDURES ARE FOLLOWED.
BUYER ASSUMES THE RISK OF ITS USE OF THE MATERIAL.
DATE PREPARED: MAY 03,1999
|