MATERIAL SAFETY DATA SHEET
ACCUMETRIC LLC
350 RING ROAD
ELIZABETHTOWN, KY 42701
TELEPHONE: 270-769-3385
FAX: 270-765-2412
______________________________________________________________________________
BOSS庐 615
______________________________________________________________________________
SECTION 1 - IDENTITY INFORMATION
PRODUCT NAME: BOSS庐 SILICONE LUBRICANT 鈥? BOSS庐 615
PRODUCT CLASS: SILICONE LUBRICANT
------------------------------------------------------------------------------------------------------------------
SECTION 11 - HAZARDOUS INGREDIENTS
INGREDIENT: HYDROTREATED HEAVY NAPTHA
CAS #: 64742-48-9
WT.%: 15%
ACGIH OSHA: 400 PPM
KNOWN OR
SUSPECTED CARCINOGEN: NO
SEC 313: NO
VAPOR PRESSURE
MMGH20C: 30.0
INGREDIENT: LIQUIFIED PETROLEUM GAS
CAS #: 68476-85-7
WT.%: 20%
ACGIH OSHA: 1000 PPM
KNOWN OR SUSPECTED
CARCINOGEN: NO
SEC 313: NO
VAPOR PRESSURE
MMGH20C: 55.0
------------------------------------------------------------------------------------------------------------------
SECTION 111. PHYSICAL DATA
BOILING POINT: 240-283 F
ODOR: ALIPHATIC ODOR
APPEARANCE: AEROSOL
VOLATILE BY WEIGHT: 97.0%
VOLATILE BY VOLUME: 97.5%
VAPOR DENSITY: IS HEAVIER THAN AIR
EVAPORATION RATE: IS SLOWER THAN AIR
SOLUBILITY: PARTIALLY
PRODUCT DENSITY: 6.8 LBS./GAL. (U.S.)
------------------------------------------------------------------------------------------------------------------
SECTION IV. FIRE AND EXPLOSION DATA
FLAMMABILITY CLASSIFICATION:
OSHA - FLAMMABLE LIQUID - CLASS IB
DOT - CONSUMER COMMODITY ORM-D
FLASH POINT: -50 T (TAGLIABUE CLOSED CUP)
LEL: 0.9%
UEL: 9.5%
EXTINGUISHING MEDIA: FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS: MATERIAL IS HIGHLY VOLATILE
AND READILY GIVES OFF VAPORS WHICH MAY TRAVEL ALONG THE GROUND OR
MOVE BY VENTILATION AND IGNITED. POSSIBLE IGNITION SOURCES SUCH AS:
PILOT LIGHTS, OTHER FLAMES, SPARKS, HEATERS, SMOKING, ELECTRIC MOTORS,
STATIC DISCHARGE OR OTHER IGNITION SOURCES AT LOCATIONS DISTANT
FROM MATERIAL HANDLING POINT.
SPECIAL FIREFIGHTING PROCEDURES: WATER MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP AND POSSIBLE AUTOIGNITION
OR EXPLOSION WHEN EXPOSED TO EXTREME HEAT. WEAR A FULL FACE
POSITIVE PRESSURE SELF CONTAINED BREATHING APPARATUS WHEN FIGHTING
FIRES.
------------------------------------------------------------------------------------------------------------------
SECTION V. HEALTH HAZARD DATA
EFFECTS OF OVER EXPOSURE:
INHALATION: SHORTNESS OF BREATH, DIZZINESS, AND
LIGHTHEADEDNESS.
EYE: CAN CAUSE EYE IRRITATION.
SKIN IRRITATION: CAN CAUSE DERMATITIS.
INGESTION: MAY CAUSE CHEMICAL PNEUMONIA IF
ASPIRATED INTO LUNG.
MEDICAL CONDITIONS PRONE TO AGGRAVATION BY EXPOSURE:
NONE RECOGNIZED.
PRIMARY ROUTE(S) OF ENTRY: DERMAL, INHALATION
EMERGENCY AND FIRST AID PROCEDURES: CALL PHYSICIAN IMMEDIATELY!!!:
IF IN EYES: FLUSH WITH LARGE AMOUNTS OF WATER LIFTING UPPER AND
LOWER LIDS OCCASIONALLY, GET MEDICAL ATTENTION. IF SWALLOWED: DO
NOT INDUCE VOMITING. IMMEDIATELY DRINK TWO GLASSES OF WATER.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CALL
PHYSICIAN IMMEDIATELY. IF BREATHED: IF AFFECTED, REMOVE INDIVIDUAL
TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN. IF BREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. KEEP PERSON WARM, QUIET, GET
MEDICAL ATTENTION. IF ON SKIN: THOROUGHLY WASH EXPOSED AREA WITH
SOAP AND WATER, REMOVE CONTAMINATED CLOTHING. LAUNDER
CONTAMINATED CLOTHING BEFORE RE-USE.
------------------------------------------------------------------------------------------------------------------
SECTION VI. REACTIVITY DATA
STABILITY: THIS PRODUCT IS STABLE UNDER NORMAL STORAGE CONDITIONS.
INCOMPATIBILITY:
AVOID CONTACT WITH STRONG OXIDIZING AGENTS, STRONG ALKALIES,
AND STRONG MINERAL ACIDS.
HAZARDOUS POLYMERIZATION:
WILL NOT OCCUR UNDER NORMAL CONDITIONS.
HAZARDOUS DECOMPOSITION PRODUCTS:
BURNING CAN PRODUCE CARBON MONOXIDE AND/OR CARBON DIOXIDE
AND TRACE PHOSGENE GAS.
CONDITIONS TO AVOID:
OPEN FLAMES OR ELECTRICAL ARCS.
------------------------------------------------------------------------------------------------------------------
SECTION VII. OTHER REGULATORY INFORMATION
OTHER REGULATORY INFORMATION:
DISCLAIMER: THE FOREGOING INFORMATION HAS BEEN COMPILED FROM
SOURCES BELIEVED TO BE ACCURATE BUT IS NOT WARRANTED TO BE.
RECIPIENTS ARE ADVISED TO CONFIRM IN ADVANCE OF NEED THAT DATA IS
CORRECT. STANDARDS CHANGE WITHOUT NOTICE. IT IS THE RESPONSIBILITY
OF THE RECIPIENT TO ASSURE THAT THEIR PERSONNEL HAVE BEEN NOTIFIED OF
ANY CHANGES WHICH MAY AFFECT THEM. THE DATA PROVIDED ON THIS MSDS
ARE NOT MEANT TO BE USED AS SPECIFICATIONS, ONLY AS GUIDELINE
INFORMATION AS TO THE SAFE USE OF THE PRODUCT. USER SHOULD REFER TO
APPLICABLE LAWS BEFORE USE. THIS MSDS COMPLIES WITH GUIDELINES SET
BY 29 CFR 1910.1200.
PROPOSITION 65 STATEMENT:
THE INFORMATION CONTAINED HEREIN IS, TO THE BEST OF OUR KNOWLEDGE
AND BELIEF, ACCURATE, HOWEVER, SINCE THE CONDITIONS OF HANDLING AND
USE ARE BEYOND OUR CONTROL, WE MAKE NO GUARANTEE OF RESULTS, AND
ASSUME NO LIABILITY FOR DAMAGES INCURRED BY USE OF THIS MATERIAL. IT
IS THE RESPONSIBILITY OF THE USER TO COMPLY WITH ALL APPLICABLE
FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.
REVISION DATE: 06/24/2002
|