MATERIAL SAFETY DATA SHEET
ACCUMETRIC LLC
350 RING ROAD
ELIZABETHTOWN, KY 42701
270-769-3385
BOSS庐 663 BRAKE CLEANER
SECTION 1. MANUFACTURER IDENTIFICATION HMIS CODES
H F R
MANUFACTURERS NAME: ACCUMETRIC LLC 2* 2 0
350 RING ROAD
ELIZABETHTOWN, KY 42701
TELEPHONE NUMBER: 270-769-3385
SECTION 2. HAZARDOUS INGREDIENTS/SARA III INFORMATION
REPORTABLE COMPONENTS CAS NUMBER mm Hg @ TEMP PERCENT
HEPTANE 142-82-5 40 72 20
OSHA PEL: 400 PPM, ACGIH TLV: 400 PPM
* HEXANE (MIXED ISOMERS), INCLUDING n-HEXANE 110-54-3 137 68 20
FOR HEXANE ISOMERS: OSHA PEL: 500 PPM,
ACGIH TLV: 500 PPM, STEL: 1000 PPM,
FOR n-HEXANE: OSHA PEL: 50 PPM,
ACGIH TLV: 50 PPM
BUTANE 106-97-8 1640 68 30
OSHA PEL: 800 PPM, ACGIH TLV: 800 PPM
PROPANE 74-98-6 6350 68 10
OSHA PEL: 1000 PPM, ACGIH TLV: ASPHYXIANT
* INDICATES TOXIC CHEMICAL(S) SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III
AND OF 40 CFR 372.
SECTION 3. PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING RANGE: 250 DEG F 鈥? 310 DEG F
SPECIFIC GRAVITY (H20=1): 1.53
VAPOR DENSITY: HEAVIER THAN AIR
EVAPORATION RATE: SLOWER THAN ETHER
SOLUBILITY IN WATER: NIL
APPEARANCE AND ODOR: AEROSOL PRODUCT; COLORLESS LIQUID; MILDLY SWEET
Page 2
SECTION IV. FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: 105 DEG F
METHOD USED: TCC
FLAMMABLE LIMITS IN AIR BY VOLUME 鈥? LOWER: .7 UPPER: 6
EXTINGUISHING MEDIA: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIRE FIGHTING PROCEDURES:
WATER MAY BE USED TO COOL CONTAINERS TO PREVENT PRESSURE BUILD-UP AND
EXPLOSION WHEN EXPOSED TO EXTREME HEAT. IF WATER IS USED, FOG NOZZLES
PREFERRED. WEAR GOGGLES AND SELF-CONTAINED BREATHING APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
CLOSED CONTAINERS MAY EXPLODE FROM INTERNAL PRESSURE BUILD-UP WHEN EXPOSED
TO EXTREME HEAT AND DISCHARGE CONTENTS. VAPOR ACCUMATION CAN FLASH OR
EXPLODE IF IGNITED. OVEREXPOSURE TO DECOMPOSITION PRODUCT MAY CAUSE A HEALTH
HAZARD. SYMPTOMS MAY NOT BE READILY APPARENT. OBTAIN MEDICAL ATTENTION.
SECTION 5. REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID: APPLICATION TO HOT SURFACES. STORAGE ABOVE 120 DEG F.
EXPOSURE TO OPEN FLAME.
INCOMPATIBILITY (MATERIALS TO AVOID): STRONG OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
SECTION 6. HEALTH HAZARD DATA
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE:
RESPIRATORY IRRITATION, HEADACHE, NAUSEA, FATIGUE, DROWSINESS, IMPAIRED
CO-ORDINATION, CARDIAC SENSITIZATION
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE:
SKIN: CONTACT MAY DRY THE SKIN; PROLONGED CONTACT MAY CAUSE MODERATE
IRRITATION.
EYE: LIQUID OR VAPOR CAN IRRITATE; PROLONGED CONTACT MAY LEAD TO CORNEAL
DAMAGE.
SKIN ABSORBPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE:
NOT EASILY ABSORBED. SOLVENT ACTION CAN DRY AND DEFAT THE SKIN CAUSING THE
SKIN TO CRACK, LEADING TO DERMATITIS.
Page 3
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE:
NOT A LIKELY ROUTE OF EXPOSURE. IF SWALLOWED, DO NOT INDUCE VOMITING. SEEK
IMMEDIATE MEDICAL ADVICE AND/OR ATTENTION.
HEALTH HAZARDS (ACUTE AND CHRONIC):
ACUTE: EYE IRRITANT. SKIN IRRITANT. NARCOTIC IN HIGH CONCENTRATIONS. CHRONIC:
LIVER AND KIDNEY DISEASE. SKIN IRRITATION AND DERMATITIS. CHRONIC
OVEREXPOSURES HAVE CAUSED LIVER AND KIDNEY TOXIC EFFECTS IN EXPERIMENTAL
ANIMALS. CAN CAUSE CENTRAL NERVOUS SYSTEM EFFECTS, IRREGULAR HEARTBEAT AND
POSSIBLE DEATH IF TOO MUCH IS BREATHED. DELIBERATE CONCENTRATION AND
INHALATION OF CONTENTS MAY BE HARMFUL OR FATAL. CAN ELEVATE
CARBOXYHEMOGLOBIN LEVELS FOLLOWING EXPOSURE
CARCINOGENICITY: NTP CARCINOGEN: YES IARC MONOGRAPHS: YES
OSHA REGULATED: YES
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
ACUTE AND CHRONIC LIVER AND KIDNEY DISEASE, ANEMIA, CORONARY DISEASE OR
SHYTHM DISORDERS OF THE HEART.
EMERGENCY AND FIRST AID PROCEDURES:
INHALATION: REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF NEEDED. APPLY ARTIFICIAL
RESPIRATION IF BREATHING HAS STOPPED. GET MEDICAL ATTENTION. DO NOT ADMINISTER
ADRENALIN TO AN AFFECTED PERSON.
INGESTION: DO NOT INDUCE VOMITING; CALL A DOCTOR IF CONDITION REMAINS, GET
MEDICAL ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSIOUS PERSON.
SKIN: WIPE OFF WITH TOWEL. WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF
IRRITATION PERSISTS.
EYES: WASH IMMEDIATELY WITH LARGE VOLUMES OF FRESH WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION.
SECTION 7. PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
AVOID BREATHING VAPORS. VENTILATE AREA. REMOVE ALL SOURCES OF IGNITION. CLEAN
UP AREA WITH ABSORBENT MATERIAL AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
WASTE DISPOSAL METHOD:
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. BEFORE
ATTEMPTING CLEANUP, REFER TO OTHER SECTIONS OF THIS MSDS FOR HAZARD CAUTION
INFORMATION.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
STORE AND USE IN COOL, DRY, WELL-VENTILATED AREAS. AVOID CONTACT WITH HOT
METAL SURFACES. KEEP AWAY FROM EXCESSIVE HEAT OR OPEN FALME. CONTENTS UNDER
PRESSURE. DO NOT PUNCTURE OR INCINERATE CONTAINER OR STORE ABOVE 120 DEG F.
OTHER PRECAUTIONS:
THE STORAGE OF NON-FLAMMABLE PRODUCTS WITH NON-FLAMMABLE OR FLAMMABLE
PRESSURIZING AGENT, IN CARTONS, IS THE SAME FOR ORDINARY CANNED GOODS IN
CARTONS.
Page 4
SECTION 8. CONTROL MEASURES
RESPIRATORY PROTECTION
IN RESTRICTED AREAS, USE APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO
REMOVE A COMBINATION OF PARTICLES AND VAPOR. IN CONFINED AREAS, USE APPROVED
AIR LINE TYPE RESPIRATOR OR HOOD. SELF CONTAINED BREATHING APPARATUS IS
REQUIRED FOR VAPOR CONCENTRATIONS ABOVE PEL/TLV LIMITS.
VENTILATION:
SUFFICIENT TO PREVENT INHALATION OF SOLVENT VAPORS. GENERAL DILUTION AND/OR
LOCAL EXHAUST VENTILATION IN VOLUME OR PATTERN TO KEEP PEL/TLV OF MOST
HAZARDOUS INGREDIENT BELOW ACCEPTABLE LIMIT AND LEL BELOW STATED LIMIT.
PROTECTIVE GLOVES:
SOLVENT RESISTANT REQUIRED FOR PROLONGED OR REPEATED CONTACT.
EYE PROTECTION:
SAFETY GLASSES WITH SPLASH GUARDS OR FULL FACE SHIELD.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:
SOLVENT RESISTANT APRONS.
WORK/HYGIENIC PRACTICES:
EYE WASHES AND SAFETY SHOWERS IN THE WORKPLACE ARE RECOMMENDED.
SECTION 9. DISCLAIMER
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE.
HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE
DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF. BECAUSE THE
INFORMATION CONTAINED HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR
CONTROL, WE ASSUME NO RESPONSIBILITY FOR ITS USE.
DATE: MARCH 19, 1998
|