MATERIAL SAFETY DATA SHEET
ACCUMETRIC LLC
350 RING ROAD
ELIZABETHTOWN, KY 42701
270-769-3385
BOSS庐 662 CARB AND CHOKE CLEANER
SECTION 1. MANUFACTURER IDENTIFICATION
MANUFACTURERS NAME: ACCUMETRIC INC.
350 RING ROAD
ELIZABETHTOWN, KY 42701
TELEPHONE NUMBER: 270-769-3385
HMIS CODES: H F R
2* 4 0
SECTION 2. HAZARDOUS INGREDIENTS/SARA III INFORMATION
REPORTABLE COMPONENTS CAS NUMBER mm Hg @ TEMP PERCENT
* TOLUNE 108-88-3 10 81 40
OSHA PEL: 200PPM TWA, ACGIH TLV:
100 PPM,: 200PPM ACC
*METHYLENE CHLORIDE, DICHLOROMETHANE 75-09-2 420 77 25.0
OSHA PEL: 500 PPM, ACGIH TLV: 50 PPM,:
1000 CEIL
ACETONE 67-64-1 181 68 11
OSHA PEL: 750 PPM ACGIH TLV: 750 PPM
*METHANOL 67-56-1 100 70 9
OSHA PEL: 200 PPM, ACGIH TLV: 200 PPM,:
SKIN
PROPANE 74-98-6 6350 68 15
OSHA PEL: 1000 PPM, ACGIH TLV:
ASPHYXIANT
*INDICATES TOXIC CHEMICAL(S) SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III OF
40 CFR 372.
SECTION 3. PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING RANGE: -44 DEG F 鈥? 231 DEG F
SPECIFIC GRAVITY (H2O=1): 0.83
VAPOR DENSITY: UNKNOWN
EVAPORATION RATE: UNKNOWN
SOLUBILITY IN WATER: SLIGHT
APPEARANCE AND ODOR: AEROSOL PRODUCT
SECTION 4. FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: -156 DEG F
METHOD USED: ESTIMATED
FLAMMABLE LIMITS IN AIR BY VOLUME - LOWER: 1.2 UPPER: 36
EXTINGUISHING MEDIA:
FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES:
WATER SPRAY MY BE INEFFECTIVE. WATER MAY BE USED TO COOL CONTAINERS TO
PREVENT BUILD-UP AND EXPLOSION WHEN EXPOSED TO EXTREME HEAT. IF WATER IS USED,
FOG NOZZLES ARE PREFERRED. WEAR GOGGLES AND SELF-CONTAINED BREATHING
APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
CLOSED CONTAINERS MAY EXPLODE FROM INTERNAL PRESSURE BUILD-UP WHEN EXPOSED
TO EXTREME HEAT AND DISCHARGE CONTENTS. VAPOR ACCUMUATION CAN FLASH OR
EXPLODE IF IGNITED. OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A
HEALTH HAZARD. SYMPTOMS MAY NOT BE READILY APPARENT. OBTAIN MEDICAL
ATTENTION.
SECTION 5. REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID:
APPLICATION TO HOT SURFACES. STORAGE ABOVE 120 DEG F. EXPOSURE TO OPEN FLAME.
INCOMPATIBILITY (MATERIALS TO AVOID):
STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION OR BY PRODUCTS:
MAY PRODUCE FUMES WHEN HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON
MONOXIDE, CHLORINE, AND HYDROGEN CHLORIDE
HAZAROUS POLYMERIZATION:
WILL NOT OCCUR
SECTION 6. HEALTH HAZARD DATA
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE:
RESPIRATORY IRRITATION, HEADACHE, NAUSEA, FATIGUE, DROWSINESS, IMPAIRED CO-
ORDINATION, POSSIBLE UNCONSCIOUSNESS.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE:
SKIN: CONTACT MAY DRY THE SKIN; PROLONGED CONTACT MAY CUASE IRRITATION.
EYES: LIQUID OR VAPOR CAN CAUSE SEVERE IRRITATION, REDNESS, TEARING, AND
BLURRED VISION; PROLONGED CONTACT MAY LEAD TO CORNEAL DAMAGE.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE:
SOLVENT ACTION CAN DRY AND DEFAT THE SKIN, CAUSING THE SKIN TO CRACK, LEADING
TO DERMATITIS.
INGESTION HEALTH RISKS AND SYMPTOM OS EXPOSURE:
NOT A LIKELY ROUTE TO EXPOSURE. CAN CAUSE GASTRO-INTESTINAL IRRITATION,
VOMITING, DIARRHEA, BLINDNESS AND DEATH. IF SWALLOWED, DO NOT INDUCE VOMITING.
SEEK MEDICAL ADVICE AND/OR ATTENTION.
HEALTH HAZARDS (ACUTE AND CHRONIC):
ACUTE: EYE IRRITANT. SKIN IRRITANT. NARCOTIC IN HIGH CONCENTRATIONS.
CHRONIC: UNKOWN FOR PRODUCT AS A WHOLE
CARCINOGENICITY: NTP CARCINOGEN: Yes IACR MONOGRAPHS: Yes
OSHA REGULATED: Yes
METHYLENE CHLORIDE IS A SUSPECTED ANIMAL CARCINOGEN;
STUDIES OF WORKERS IN THE WORKPLACE HAVE NOT CONFIRMED
THESE RESULTS. NOT ON OSHA LIST.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
ACUTE AND CHRONIC LIVER AND KIDNEY DISEASE, ANEMIA, CORONARY DISEASE OR
RHYTHM DISORDERS OF THE HEART.
EMERGENCY AND FIRST AID PROCEDURES:
INAHALATION: REMOVE TO FRESH AIR. ADMINISTER OXYGEN IF NEEDED. APPLY
ARTIFICIAL RESPIRATION IF BREATHING HAS STOPPED. GET MEDICAL ATTENTION.
SKIN: WIPE OFF WITH TOWEL. WASH WITH SOAP AND WATER. GET MEDICAL ATTENTION IF
IRRITATION PERSISTS.
EYES: WASH IMMEDIATELY WITH LARGE VOLUMES OF FRESH WATER FOR AT LEAST 15
MINUTES. GET MEDICAL ATTENTION.
SECTION 7. PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
AVOID BREATHING VAPORS. VENTILATE AREA. REMOVE ALL SOURCES OF IGNITION. CLEAN
UP AREA WITH ABSORBENT MATERIAL AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
WASTE DISPOSAL METHOD:
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. BEFORE
ATTEMPTING CLEAN UP, REFER TO OTHER SECTION OF THIS MSDS FOR HAZARD CAUTION
INFORMATION.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING:
STORE AND USE IN COOL, DRY, WELL-VENTILATED AREAS. DO NOT STORE ABOVE 120 DEG. F.
DO NOT PUNCTURE OR INCINERATE (BURN) CANS. DO NOT STICK PIN, NAIL OR ANY OTHER
SHARP OBJECT INTO OPENING ON TOP OF CAN. DO NOT SPRAY IN EYES. DO NOT TAKE
INTERNALLY. SEE PRODUCT LABEL FOR ADDITIONAL INFORMATION.
OTHER PRECAUTIONS:
SMALL PRESSURIZED CONTAINERS OF FLAMMABLE PRODUCTS MAY BE STORED IN AREAS
SUITABLE FOR ORDINARY COMBUSTIBLES WITH RESPECT TO CONSTRUCTION, DRAINAGE,
CONTROL OF IGNITION SOURCES, AND VENTILATION EXCEPT THAT THEY SHOULD NOT BE
STORED IN BASEMENTS.
SECTION 8. CONTROL MEASURES
RESPIRATORY PROTECTION:
NONE UNDER NORMAL USE. AVOID BREATHING VAPORS. IN RESTRICTED AREAS, USE
APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO REMOVE A COMBINATION OF
PARTICLES AND VAPOR. IN CONFINED AREAS, USE APPROVED AIR LINE TYPE RESPIRATOR
OR HOOD. SELF-CONTAINED BREATHING APPARATUS IS REQUIRED FOR VAPOR
CONCENTRATIONS ABOVE PEL/TLV LIMITS.
VENTILATION:
SUFFICIENT TO PREVENT INHALATION OF SOLVENT VAPORS. GENERAL DILUTION AND/OR
LOCAL EXHAUST VENTILATION IN VOLUME OR PATTERN TO KEEP PEL/TLV OF MOST
HAZARDOUS INGREDIENT BELOW ACCEPTABLE LIMIT AND LEL BELOW STATED LIMIT.
PROTECTIVE GLOVES:
NONE UNDER NORMAL USE. SOLVENT RESISTANT REQUIRED FOR PROLONGED OR REPEATED
CONTACT.
EYE PROTECTION:
NONE UNDER NORMAL USE; HOWEVER, USE OF SAFETY GLASSES WITH SPLASH GUARDS OR
FULL FACE SHIELD IS RECOMMENDED.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT:
NONE UNDER NORMAL USE, HOWEVER, USE OF SOLVENT RESISTANT APRONS OR OTHER
CLOTHING IS RECOMMENDED.
WORK/HYGIENIC PRACTICES:
EYE WASHES AND SAFETY SHOWERS IN THE WORKPLACE ARE RECOMMENDED.
SECTION 9. DISCLAIMER
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER, NO
WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE DATA OR THE RESULTS
TO BE OBTAINED FROM THE USE THEREOF. BECAUSE THE INFORMATION CONTAINED HEREIN MAY
BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL, WE ASSUME NO RESPONSIBILITY FOR ITS
USE.
DATE: MARCH 19, 2000
|