MATERIAL SAFETY DATA SHEET
(This MSDS complies with 29 CFR 1910.1200)
Product Name: BC 4578 Model Board Filler BCC PRODUCTS, INC. HMIS
Product Class: Polyester Mixture 2140 Earlywood Drive H-2
Issue Date: 09/11/03 P.O. Box 327 F-2
Approved By: Kenneth E. Poucher Franklin, IN 46131 R-1
317-736-4090 P-H
24 HOUR EMERGENCY NO. 1-800-424-9300 CHEMTREC
SECTION 1 - HAZARDOUS INGREDIENTS
Chemical Name Wt. % OSHA (PEL) ACGIH (TLV) CAS NO.
(optional)
Unsaturated Polyester Resin N.E. N.E. 34-540-93-7
Styrene Monomer 50 ppm 50 ppm 100-42-5
m-Tolyl-Diethanolamine N.E. N.E. 91-99-6
Toluhydroquinone N.E. N.E. 95-71-6
SECTION 2 - PHYSICAL DATA
Boiling Point: 295 掳 F Specific Gravity (H20=1): 0.85
Vapor Pressure (mm Hg): 4.3 Vapor Density (Air = 1): 4.3
Solubility in Water: Insoluble Reactivity in Water: N.A.
Appearance and odor: Paste, styrene odor.
SECTION 3 - FIRE AND EXPLOSION HAZARD
Flash Point: 105 掳 F Flammable Limit: 1.1
LEL:
Method Used: T.O.C. 6.1
UEL:
(In Air % by volume)
Auto Ignition Temperature: N.A.
Extinguishing Media: Carbon Dioxide, dry chemical, chemical foam, water spray.
Fire & Explosion Hazards: Decomposition and combustion products may be toxic.
Fire Fighting Procedures: Fire fighters must wear self-contained breathing apparatus to protect
against toxic and irritating vapors. Full protective clothing should also
be worn.
SECTION 4 - REACTIVITY DATA
Stability (Conditions to avoid): Stable. Open flames, heat, high temperatures and
contaminants.
Incompatibility: Strong acids, peroxides, and other oxidizing agents.
Hazardous Decomposition Products: Carbon monoxide from incomplete burning.
Hazardous Polymerization (Materials to avoid): Will not occur.
N.E. - Not Established N.D.A. - No Data Available N.A . - Not Applicable
BC 4578 Model Board Filler - Page 2
SECTION 5 - ENVIRONMENTAL AND DISPOSAL INFORMATION
Spill: Remove spillage by absorbing in sand, vermiculite, sawdust, or absorbent sweeping
compound. For small spills, rubbing alcohol may be used. Dike to prevent entry into
water system.
Disposal: Use approved incineration in accordance with federal, state and local environmental
regulations. Material must be disposed of in approved landfill.
SECTION 6 - HEALTH AND FIRST AID INFORMATION
FIRST AID
Routes of Entry
Inhalation: Remove victim to uncontaminated area, administer oxygen if necessary. Seek medical
attention..
Eyes: Flush with water for 15 minutes. Seek medical attention.
Skin: Remove contaminated clothes and wash affected areas with soap and water. Seek medical
attention.
Ingestion: DO NOT Induce vomiting. Seek medical attention.
EFFECTS OF OVER EXPOSURE
Acute: Excessive exposure may result in anesthetic or narcotic effects. Upper respiratory
irritation.
Chronic: Repeated, excessive exposure may cause liver or kidney damage. Epidemiology data is
inadequate in substantiating that styrene is a human carcinogen.
Existing Health Conditions: Persons with existing liver or kidney ailment.
Carcinogen: NTP (National Toxicology Program): IARC (Monographs): POTENTIAL OSHA: POTENTIAL
No
SECTION 7 - SPECIAL HANDLING & STORAGE PRECAUTIONS
Should be stored in a ventilated storage area between 65-85 掳 F. Avoid excessive temperatures. Do not
store in direct sunlight. Keep away from oxidizing agents and open flame.
SECTION 8 - SPECIAL PROTECTION INFORMATION
Respiratory Protection: Use NIOSH approved respirator.
Ventilation: Use local exhaust to maintain concentration below the PEL.
Eye Protection: Fitted chemical goggles, or safety glasses.
Personal Protection: Rubber gloves, boots and rubber apron to avoid skin contact. Contaminated
clothing or equipment should be cleaned or disposed of, after use.
Hygienic Practices: Educate and train employees on safe use of product. Shower and eye wash
station should be available.
The information contained herein is, to the best of our knowledge and belief, accurate. However, since the conditions of handling and use are
beyond our control, we make no guarantee of results, and assume no liability for damages incurred by use of this material. It is the
responsibility of the user to comply with all applicable federal, state, and local laws and regulations.
|