Product Code: DURASOMA3475
Revision Date: 11/12/2007
Revised By: MSDS Dept.
Page: 1
5353 Spring Grove Avenue, Cincinnati, OH 45217 USA 513-471-8770
Material Safety Data Sheet
Section 1 - Product Identification
Product Name: Durasol MA-3475
Hazard Rating
Health Fire Reactivity
NFPA Code: 1 1 0
0=Least 1=Slight 2=Moderate 3=High 4=Extreme
________________________________________________________________________________
Section 2 - Hazardous Ingredients / Identity Information
Specific Identity; Common Names OSHA PEL ACGIH TLV Other
Proprietary Formula - Specific Chemical Identities Have Been Withheld
110-97-4
Diisopropanolamine - -
34590-94-8
Dipropylene Glycol Monomethyl Ether 100 ml/m3 100 ml/m3
(skin) (skin)
64742-52-5
Severely hydrotreated heavy naphthenic distillates 5mg/m3 5mg/m3
Mineral Oil (mist) (mist)
7732-18-5
Water - -
8002-26-4
Distilled tall oil - -
________________________________________________________________________________
Section 3 - Physical/Chemical Characteristics
Appearance Amber liquid
Boiling Point, Deg. F Not Known
Evaporation, BuAcetate=1 Slower than
Odor Mild
pH Diluted in water 9.5 (5%)
Solubility in water Emulsifies
Vapor Density (Air=1) Not Known
Vapor Pressure Not Known
Pounds per Gallon 8.039
Specific Gravity 0.965
________________________________________________________________________________
Section 4 - Fire and Explosion Hazard Data
Flash Point COC: >350F Flammable Limits: LEL-Not Known UEL-Not Known
Extinguishing Media: Foam, dry chemical, water fog, carbon dioxide. Do not
use a direct stream of water.
Special Fire Fighting Procedures: Cool fire exposed containers with water.
Do not enter a confined fire space without full bunker gear and NIOSH
approved supplied air breathing apparatus.
Unusual Fire and Explosion Hazards: Not Applicable
continued...
Product Code: DURASOMA3475
Revision Date: 11/12/2007
Revised By: MSDS Dept.
Page: 2
5353 Spring Grove Avenue, Cincinnati, OH 45217 USA 513-471-8770
Material Safety Data Sheet
...continued
________________________________________________________________________________
Section 5 - Reactivity Data
Stability - Stable.
Incompatibility - Alkali. Oxidizing agents. Reducing agents.
This product contains amines. Do not mix with nitrite or other nitrosating
agents due to the potential for nitrosamine formation.
Hazardous Decomposition Products - Hydrogen chloride gas. Iodine vapors. Organic
compounds. Oxides of carbon. Oxides of nitrogen.
Hazardous Polymerization - Will not occur.
Other - Not Applicable.
________________________________________________________________________________
Section 6 - Health Hazard Data
Routes of Entry: Inhalation-yes Skin-yes Ingestion-yes
Health Hazards :
The health hazards listed below are for components to this mixture. The active
ingredients are diluted in mineral oil in this mixture and the severity of the
listed health hazards for this product may be reduced. This product is
designed to be diluted significantly with water before product use. The
severity of these health hazards may be reduced further at usage concentrations.
(Acute and Chronic Overexposure)
Eyes - Irritation. Redness. Slight excess redness.
Component may cause eye tissue injury and result in permanent damage.
Skin - Irritation.
Prolonged and repeated contact can defat the skin which may result in dryness,
dermatitis, and cracking of the skin.
Persons sensitized by contact with rosin may develop an allergic reaction.
Inhalation - Excessive exposures may affect central nervous system. Heated
vapors may cause irritation. Irritation. Vapors may cause irritation.
Ingestion - Component is considered moderately toxic by ingestion.
Gastrointestinal irritation. Nausea. Stomach discomfort.
Pulmonary aspiration hazard if swallowed and vomiting occurs.
Signs And Symptoms of Exposure - As Noted Above.
Medical Conditions Generally Aggravated By Exposure - None Known.
Other Precautions - NA
Other - NA
Carcinogenicity NTP-No IARC-No OSHA-No
Emergency and First Aid Procedures:
Inhalation - remove to fresh air. If breathing is difficult, give oxygen.
If breathing is stopped, begin artificial respiration. Get medical attention.
Skin contact - wash skin thoroughly with soap and water. Remove and wash
contaminated clothing before reuse. If product is injected into or under the
skin, or into any part of the body, regardless of the appearance of the wound
or its size, the individual should be evaluated immediately by a physician as
a surgical emergency. Even though initial symptoms from high pressure injection
may be minimal or absent, early surgical treatment within the first few hours
may significantly reduce the ultimate extent of the injury.
Eye contact - flush with water for at least 15 minutes or until irritation
continued...
Product Code: DURASOMA3475
Revision Date: 11/12/2007
Revised By: MSDS Dept.
Page: 3
5353 Spring Grove Avenue, Cincinnati, OH 45217 USA 513-471-8770
Material Safety Data Sheet
...continued
subsides, get medical attention.
Ingestion - DO NOT induce vomiting; get medical attention immediately.
________________________________________________________________________________
Section 7 - Precautions for Safe Handling and Use
Steps to be Taken in Case Material is Released or Spilled:
Dike area. Recover free product. Add a dry absorbent material to spill
area.
Waste Disposal Method: Dispose by methods consistent with local state and
federal regulations.
Precautions to be Taken in Handling and Storing: Keep containers tightly
closed. Use and store this product with adequate ventilation. Avoid
inhalation of vapors and personal contact with the product. To
dissipate static electricity during transfer, ground and/or bond both
containers. Since emptied containers retain product residue, follow
warnings even after container is emptied. Residue or vapors may
explode on ignition; do not cut, drill, grind or weld on or near
container even when empty.
Other Precautions:
Not Applicable
________________________________________________________________________________
Section 8 - Control Measures
Respiratory Protection: Not normally required. Use NIOSH approved supplied
air breathing equipment if vapors are excessive.
Ventilation: Local Exhaust : Not normally required.
Mechanical (General): Use general ventilation.
Protective Gloves: Use chemical-resistant gloves, if needed, to avoid skin
contact.
Eye Protection: Use splash goggles or face shield when eye contact may
occur.
Other Protective Clothing or Equipment: To prevent repeated or prolonged
skin contact, wear impervious apron/clothing and boots.
Work/Hygienic Practices: Minimize breathing vapor, mist or fumes. Wash
skin with soap and water after contact. Launder contaminated
clothing.
________________________________________________________________________________
Section 9 - Regulatory Information
DOT Information
DOT Proper Shipping Name: None
DOT Hazard Code: None
UN Number: None
TSCA
All components of this product are included in the TCSA inventory or are
regulated under FIFRA.
Section 313 Supplier Notification
This product contains the following chemicals subject to the reporting
requirements of section 313 of the Emergency Planning and Community Right-
To-Know Act of 1986 (40 CFR 372):
CAS# Common Name Weight%
This information should be included in all MSDSs that are copied and
continued...
Product Code: DURASOMA3475
Revision Date: 11/12/2007
Revised By: MSDS Dept.
Page: 4
5353 Spring Grove Avenue, Cincinnati, OH 45217 USA 513-471-8770
Material Safety Data Sheet
...continued
distributed for this material.
________________________________________________________________________________
Prepared according to the OSHA Hazard Communication Standard
(29 CFR 1910.1200) by
________________________________________________________________________________
The information set forth herein is furnished free of charge and is based
on technical data that we believe to be reliable. It is intended for
use by persons having technical skill and at their own discretion and risk.
Since conditions of use are outside our control, we make no warranties,
express or implied, and assume no liability in connection with any use of
the information. Nothing herein is to be taken as a license to operate
under or a recommendation to infringe any patents.
End of MSDS
|