C & W PRESSROOM PRODUCTS HAZARD RATING HMIS RATING
180 EAST UNION AVE. 4 = EXTREME HEALTH 1
EAST RUTHERFORD, NJ 07073 3 = HIGH FLAMMABILITY 0
2 = MODERATE REACTIVITY 0
EMERGENCY TELEPHONE NUMBER 1 = SLIGHT PERSONAL
201-933-4343 0 = INSIGNIFICANT PROTECTION X
DATE ISSUED: APRIL 1, 1999
SECTION I PRODUCT INFORMATION
PRODUCT NAME : PACESETTER 800W
CHEMICAL NAME : Ethylene Glycol & Phosphates
MOLECULAR FORMULA : Complex Mixture
SYNONYMS :
CHEMICAL FAMILY : Glycol and inorganic chemicals
SECTION II HAZARDOUS COMPONENT INFORMATION
CAS# CONTENT TLV
SECTION III PHYSICAL PROPERTIES
BOILING POINT : 212掳F MELTING POINT : N/A
SPECIFIC GRAVITY (H2O = 1) : 1.069 VAPOR PRESSURE : 22.0 mm Hg @ 24掳C
SOLUBILITY IN WATER : 100% VAPOR DENSITY (AIR = 1) :
% VOC鈥檚 : 5% by volume / 0.38# per gallon pH (as is) : 6.78
APPEARANCE & ODOR : Reddish, clear solution EVAPORATION RATE
No apparent odor (n-BuOAc = 1.0) : 0.5
SECTION IV FIRE & EXPLOSION DATA
FLASH POINT : Not Combustible
FLAMMABLE LIMITS :
EXTINGUISHING MEDIA : Foam, carbon dioxide or dry chemical
SPECIAL FIRE FIGHTING PROCEDURES:
None required. Not combustible at ordinary conditions.
UNUSUAL FIRE AND EXPLOSIVE HAZARDS:
No explosion hazards
SECTION V HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE : See page 1 for components
EFFECT OF OVEREXPOSURE :
EYES : Contact with eyes may cause irritation.
SKIN : Contact with skin may cause irritation
INHALATION : Prolonged or repeated breathing of vapor harmful
INGESTION : Effects relating to swallowing not currently known.
EMERGENCY AND FIRST AID TREATMENT:
EYES : Flood eyes with plenty of water. If irritation persists, seek medical attention.
SKIN : Wash exposed areas of skin with soap and water for 15 minutes.
If symptoms persist, seek medical attention.
INHALATION : Remove individual to fresh air. Seek medical attention
INGESTION : Drink large quantities of water or milk. Induce vomiting by inserting finger down throat.
Seek medical attention.
CHRONIC EFFECT(S) OF OVEREXPOSURE: None currently know.
SECTION VI REACTIVITY DATA
STABILITY : Stable
INCOMPATIBILITY / AVOID CONTACT WITH : Strong oxidizing agents
HAZARDOUS DECOMPOSITION PRODUCT : Carbon monoxide and/or dioxide
HAZARDOUS POLYMERIZATION : Will not occur
CONDITION TO AVOID : None
SECTION VII SPILL OR LEAK PROCEDURE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Dike large spills and remove to salvage tanks. Flush remaining with large amount of water.
Disposal should be carried out in compliance with federal, state and local regulations.
WASTE DISPOSAL METHOD:
Flush into an industrial sewer with copious quantities of water.
Comply with all applicable federal, state and local regulations.
SECTION VIII SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (SPECIFY TYPE) : None required at ordinary conditions.
VENTILATION:
LOCAL EXHAUST : Not required
MECHANICAL (GENERAL) : Acceptable
OTHER : None
PROTECTIVE GLOVES : Neoprene or rubber gloves
EYE PROTECTION : Safety goggles and eye bath
OTHER PROTECTIVE EQUIPMENT : Apron
SECTION IX SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
Avoid prolonged periods of storage at high temperatures
OTHER PRECAUTIONS:
SECTION X REQUIREMENTS FOR TRANSPORTATION
PROPER SHIPPING NAME : PACESETTER 800W
HAZARDOUS CLASSIFICATION : Not DOT Regulated
IDENTIFICATION NUMBER : None
REPORTABLE QUANTITY : None
IMCO CLASS (International Travel) :
ADDITIONAL LABELING : None
SECTION XI REGULATORY INFORMATION
Status on Substance List
FEDERAL EPA
Comprehensive Environmental Response, Compensation, and Liability Act of 1980 (CERCLA) requires notification of the
National Response Center of release of quantities of hazardous substances equal to or greater than the reportable quantities
(RQ鈥檚) in 40 CFR 302.4
Components present in this product at a level which could require reporting under the statute are:
Ethylene Glycol 107-21-1 < 5% 100 ppm ACGIH
Superfund Amendments and Reauthorization Act of 1986 (SARA) Title III requires emergency planning based on
Threshold Planning Quantities (TPQs) and release reporting based on Reportable Quantities (RQs) in 40 CFR 355 used
for SARA 302, 304, 311 and 312.
Components present in this product at a level which could require reporting under the statute are:
Ethylene Glycol 107-21-1 < 5% 100 ppm ACGIH
Requires submission of annual reports of release of toxic chemicals that appear in 40 CFR 372 (for SARA 313).
This information must be included in all Material Safety Date Sheets that are copied and distributed for this material.
Components present in this product at a level which could require reporting under the statue are:
Ethylene Glycol 107-21-1 < 5% 100 ppm ACGIH
The information in this document is believed to be correct as of the date issued, however, no warranty of merchantability, fitness for any
particular purpose, or any other warranty is expressed or is to be implied regarding the accuracy or completeness of this information, the
results to be obtained from the use of this information or the product, the safety of this product, or the hazards related to its use. This
information and product are furnished on the condition that the person receiving them shall make his own determination as to the
suitability of the product for his particular purpose and on the
condition that he assume the risk of his use thereof.
C&W PRESSROOM PRODUCTS
EAST RUTHERFORD, NJ 07072
(201) 933-4343
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP