TECH LINE COATINGS, INC.
MATERIAL SAFETY DATA SHEET
Section 1
Product Identification
Product Name: Colorgard Stainless Date Prepared: 1/25/2007 (update)
Part Number: CGSS Formula:
Manufacturer / Supplier: Chemical Family:
Techline Coatings, Inc
26844 ADAMS AVE.
MURRIETA, CA 92562
USA
Emergency Phone:
Phone 972-775-6130
Chemtrec
Fax 951-461-9658
1-800-424-9300
www.techlinecoatings.com
1-703-527-3887
Section 2
Composition / Data On Components
Component CAS# % of Weight OSHA PEL ACGIH TLV Sara 313
PARACHLOROBENZOTRIFLUORIDE 98-56-6 >40 Not Established Not Established
XYLENE 1330-20-7 <10 100 PPM 100 PPM YES
ISOBUTYL ALCOHOL 78-83-1 <10 500 PPM 50 PPM
ALUMINUM POWDER 7429-90-5 >25% 10mg/M3
Stainless Steel Flake Trade Secret
CRYSTALLINE SILICA 14808-60-7 <2 .1 mg/m3 .1 mg/m3
Components not listed above are non-hazardous or are a trade secret.
Section 3
Hazards Identification
Appearance and Odor:
Grey Colored Liquid / Solvent Smell
Hazard Description:
Flammable Liquid
Potential Health Effects:
PARACHLOROBENZOTRIFLUORIDE:
Target Organs: Central Nervous System, Kidneys, and Liver
Irritancy:
Eyes, Respiratory Tract, and Skin
Inhalation:
May produce symptoms of Central Nervous System depression including Headache, Dizziness, Nausea, Loss of Balance and Drowsiness
NOTE: XYLENE IS CONSIDERED BY SOME AUTHORITIES TO BE A CARCINOGEN
CHRONIC OVEREXPOSURE TO XYLENE (CAS# 1330-20-7) HAS BEEN SUGGESTED TO CAUSE CARDIAC ABNORMALITIES IN HUMANS.
Section 4
First Aid Measures
After EYE Contact:
鈥? Immediately irrigate with plenty of water for 15 minutes. Obtain medical attention if irritation persists.
After SKIN Contact:
鈥? Remove contaminated clothing without delay. Flush skin thoroughly with water. Do not reuse clothing without laundering.
After INHALATION:
鈥? Administer oxygen if there is difficulty in breathing. Obtain medical attention immediately if necessary.
After SWALLOWING:
鈥? Call a physician immediately, ONLY induce vomiting at the instructions of a physician. Never give anything by mouth to an
Page Page numbers
unconscious person.
Section 5
Fire Fighting Measures
Flashpoint: >76潞 F. Flammable Limits LEL-: Flammable Limits UEL-: Stability: See Section 10
Not Established Not Established
Method: TCC
Extinguishing Media: FOAM, ALCOHOL FOAM, CO2, DRY Special Fire Fighting Procedures: USE FULL PROTECTIVE
CHEMICAL EQUIPMENT, INCLUDING SELF CONTAINED BREATHING
APPARATUS
Unusual Fire And Explosion Hazards: DURING
EMERGENCY CONDITIONS, OVEREXPOSURE TO
DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH
HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT.
OBTAIN MEDICAL ATTENTION
Section 6
Accidental Release Measures
Steps to be taken in case material is released or spilled:
鈥? Remove sources of ignition.
鈥? Warn other workers of spill.
鈥? Wear protective equipment
鈥? NIOSH Approved Respirator
鈥? Gloves
鈥? Safety Glasses
鈥? Do not allow material to be released into the environment without proper governmental permits
Measures for cleaning / collecting:
鈥?
Additional Information:
鈥? See Section 7 for safe handling information.
鈥? See Section 8 for PPE information
鈥? See Section 13 for disposal information
Section 7
Handling and Storage
Do not breathe vapors or mists from spraying. Avoid contact with skin and eyes. Use with adequate ventilation to maintain exposure
levels below established exposure limits. If required wear an appropriate NIOSH approved respirator with paint prefilter.
Vapor is harmful. May cause eye irritation, burning sensation on skin. If inhaled, may cause headache, dizziness or nausea. Contains
petroleum distillate, harmful or fatal if swallowed.
Storage:
STORE IN A COOL DRY PLACE, SUITABLE FOR OSHA CLASS 1 FLAMMABLE LIQUIDS
Section 8
Exposure Controls and Personal Protection
Engineering Controls: Exhaust ventilation.
Showers
Eyewash stations
Use in a well ventilated area.
Respiratory Protection: Use NIOSH approved respirator if TWA/TLV limits are exceeded
Protective Gloves:
Eye Protection:
Other Protective Equipment:
Ventilation: Local Exhaust: Use To Maintain Below TWA Limits
Mechanical: Use Non-Sparking Equipment
Work / Hygienic Practices: wash thoroughly after handling product and before eating, drinking or smoking
Section 9
Physical And Chemical Properties
Appearance and Odor: Grey Colored Liquid / Solvent Smell
Boiling Point: 172潞 鈥? 355潞 F.
Page Page numbers
Vapor Density (Air = 1): <1
Vapor Pressure: Not Established
Melting Point: Not Applicable
Solubility in Water: POOR
Reactivity in Water: None
VOC's: As blended <1 Lb./Gal
SECTION 10
STABILITY AND REACTIVITY
Stability: STABLE
Incompatibility (Materials to Avoid): CONTACT WITH STRONG OXIDIZING AGENTS, ACIDS OR BASES
Hazardous Decomposition Products: Carbon Monoxide and Unidentified Organics may be formed, Chlorine and Fluorine containing gases
can be produced
Hazardous Polymerization: WILL NOT OCCUR
Conditions to Avoid: Avoid contact with Oxidizing Agents, Sparks or Flame
Section 11
Toxicological Information
Effects on Eyes: Severe Irritation, Redness, Tearing and Blurred Vision. Contact Lenses Pose A Special Hazard; Soft Lenses
May Absorb, All Lenses Concentrate Irritants
Effects on Skin: Prolonged Or Repeated Contact Can Cause Moderate Irritation, Defatting And Dermatitis
Effects from Inhalation: Excessive Inhalation Of Vapors Can Cause Nasal And Respiratory Irritation, Dizziness, Headache, Possible
Unconsciousness, Death
Effects from Swallowing: Can Cause Gastrointestinal Damage, Irritation, Nausea, Vomiting, And Diarrhea. Aspiration Of The Material
Into The Lungs Can Cause Chemical Pneumonitis Which Can Be Fatal
Section 12
Ecological Information
General Comments: Do not allow material to be released into the environment without proper governmental permits
Section 13
Disposal Considerations
Waste Disposal Method:
Disposal should be made in accordance with federal, state and local regulations. Recovered non-usable material is a RCRA
hazardous waste. Treatment, storage, transportation and disposal must be in accordance with EPA and State regulation under the
authority of the Resource Conservation and Recovery Act (RCRA) 40 CFR parts 260-271
A competent and properly permitted contractor should do appropriate disposal.
Section 14
Transportation Information
Hazardous for Shipping: Yes (ORMD in Quarts and smaller)
DOT Shipping Name: Paint
DOT Hazard Class: Class 3
DOT Labels: Flammable Liquid
UN Number: UN1263
Placards: Flammable Liquid
Packing Group: Packing Group III
Air (IATA): Paint, Class 3, Flammable Liquid UN1263, Packing Group III
Sea (IMDG): Paint, Class 3, Flammable Liquid UN1263, Packing Group III
Section 15
Regulations
Product Related Hazard Information:
Hazard Symbols: Flammable Liquid
Risk Phrases: Flammable Liquid
Safety Phrases: Flammable Liquid
National Regulations:
Canada:
WHMIS Hazard Class: B3
Page Page numbers
Other Regulations, Limitations, and Prohibitive Regulations:
OSHA Status鈥︹?︹?︹?︹?︹?︹?︹?︹?︹?︹?︹?? This product is hazardous under the criteria of the Federal OSHA Hazard Communication Standard
鈥?.: 29 CFR 1910.1200
TSCA Status鈥︹?︹?︹?︹?︹?︹?︹?︹?︹?︹?︹?︹??.: On TSCA Inventory
CERCLA Reportable Quantity鈥︹?︹?︹?︹?︹??.: None.
SARA Title III:
Section 302 Extremely Hazardous Substances.: None.
Section 311 / 312 Hazard Categories鈥︹?︹?? Chronic Health Hazard; Acute Health Hazard
鈥?: XYLENE
Section 313 Toxic Chemicals鈥︹?︹?︹?︹?︹??...:
The following chemicals are specifically listed by individual states; other product specific health and safety data in other sections of the MSDS may also be applicable
for state requirements. For details on your regulatory requirements you should contact the appropriate agency in your state.
Component Name CAS Number Concentration State Code
XYLENE 1330-20-7 <5% PA1, MA,
NJ1
Ethylbenzene 100-41-4 <3% MA, NJ1, PA1, CA
Toluene 108-88-3 <1% CA, MA, NJ1, PA1
n-BUTANOL 71-36-3 < 5% PA1, MA, NJ1
CA = Warning! This Chemical is known to the State of California to cause cancer and/or birth defects and/or other reproductive harm.
MA = Massachusetts Hazardous Substance List
NJ1 = New Jersey Hazardous Substance List
NJ2 = New Jersey RTK Special Hazardous Substance List
NJ4 = New Jersey Other 鈥? included in 5 predominant ingredients > 1%
PA1 = Pennsylvania Hazardous Substance List
* Please note that these were random sample analyses and content may vary from batch to batch.
Section 16
Other Information
This information is furnished without warranty, representation, inducement or license of any kind, except that it is accurate to
the best of Tech Line Coatings, Inc., knowledge or obtained from sources believed by Tech Line Coatings, Inc. to be accurate.
Tech Line Coatings, Inc. does not assume any legal responsibility for use or reliance upon same. Before using any chemical,
read its label, instructions and material safety data sheet.
Page Page numbers
|