MSDS
MATERIAL SAFETY DATA SHEET
C & W UNLIMITED HAZARD RATING HMIS RATING
217-A WASHINGTON AVE. 4 = EXTREME HEALTH 1
CARLSTADT, NJ 07072 3 = HIGH FLAMMABILITY 0
2 = MODERATE REACTIVITY 0
EMERGENCY TELEPHONE NUMBER 1 = SLIGHT PERSONAL
201-933-4343 0 = INSIGNIFICANT PROTECTION X
DATE ISSUED: JULY, 10, 2002
REVISION DATE: MAY, 15, 2003
SECTION I PRODUCT INFORMATION
PRODUCT NAME : Pacesetter 990 Fountain Solution
CHEMICAL NAME : Complex Mixtures
MOLECULAR FORMULA : Mixture
SYNONYMS :
CHEMICAL FAMILY : Organic Gum and Complex Mixture
SECTION II COMPONENT INFORMATION
CAS# CONTENT % TLV
COMPONENTS : Glycol 107-21-1 <10% 100 ppm ACGIH
SECTION III PHYSICAL PROPERTIES
BOILING POINT : 210掳F MELTING POINT : N/A
SPECIFIC GRAVITY (H2O = 1) : 1.12 / 20掳C VAPOR PRESSURE : 16 mm Hg / 20掳C
SOLUBILITY IN WATER : Miscible VAPOR DENSITY (AIR = 1) : Nil
PERCENT VOLATILE : 9% pH (as is) : 3.6
VOC鈥檚 (lbs. per gallon) : .83 lbs per gal EVAPORATION RATE
APPEARANCE & ODOR : Brown Liquid, Mild Odor (n-BuOAc = 1.0) : 0.5
SECTION IV FIRE & EXPLOSION DATA
FLASH POINT : Not Combustible
FLAMMABLE LIMITS : Lower - 0 Upper - 0
EXTINGUISHING MEDIA : Water, Carbon Dioxide or Dry Chemical
SPECIAL FIRE FIGHTING PROCEDURES:
Wear self-contained breathing apparatus
UNUSUAL FIRE AND EXPLOSIVE HAZARDS:
In contact with easily oxidize able substances or heated to dryness it may cause ignition,
combustion or explosion.
SECTION V HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE : Not established.
PRIMARY ROUTES OF ENTRY :
EFFECT OF OVEREXPOSURE :
EYES : May cause irritation
SKIN : May cause irritation.
INHALATION : May cause irritation
INGESTION : May cause headache, nausea, vomiting, gastrointestinal irritation, convulsions and unconsciousness.
EMERGENCY AND FIRST AID TREATMENT:
EYES : Flush eyes with plenty of water for at least 15 minutes Seek medical attention
SKIN : Wash with plenty of soap and water for at least 15 minutes
INHALATION : If breathing is difficult, remove individual to fresh air. Seek medical attention.
INGESTION : If person is conscious, induce vomiting at once by giving 2 glasses of warm water
and inserting finger down throat. Seek medical attention.
CHRONIC EFFECT(S) OF OVEREXPOSURE: No known chronic effects.
SECTION VI REACTIVITY DATA
STABILITY : Stable at ordinary condition
INCOMPATIBILITY / AVOID CONTACT WITH : Oxidizing agents
HAZARDOUS DECOMPOSITION PRODUCT : Decomposes at 626掳F releasing nitric fumes and sometimes nitrogen tetroxide
HAZARDOUS POLYMERIZATION : Will not occur
CONDITION TO AVOID : None
SECTION VII SPILL OR LEAK PROCEDURE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Flush the exposed area with large quantities of water. Flush into salvage tanks or industrial sewer.
WASTE DISPOSAL METHOD:
Flush into an industrial sewer with copious quantities of water.
Comply with all applicable federal, state and local regulations.
SECTION VIII SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (SPECIFY TYPE) : None
VENTILATION :
LOCAL EXHAUST : Not required
MECHANICAL (GENERAL) :
OTHER :
PROTECTIVE GLOVES : Rubber gloves
EYE PROTECTION : Safety goggles
OTHER PROTECTIVE EQUIPMENT : Rubber apron
SECTION IX SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
Store away from readily oxidizing material. Store in closed containers and label corrosive.
OTHER PRECAUTIONS:
Avoid contact of foods.
SECTION X REQUIREMENTS FOR TRANSPORTATION
PROPER SHIPPING NAME : Pacesetter 990 Fountain Solution
HAZARDOUS CLASSIFICATION : Not DOT regulated
IDENTIFICATION NUMBER : None
REPORTABLE QUANTITY : None
IMCO CLASS (International Travel) :
ADDITIONAL LABELING : None
SECTION XI REGULATORY INFORMATION
Status on Substance List
FEDERAL EPA
Comprehensive Environmental Response, Compensation, and Liability Act of 1980 (CERCLA) requires notification of the
National Response Center of release of quantities of hazardous substances equal to or greater than the reportable quantities
(RQ鈥檚) in 40 CFR 302.4
Components present in this product at a level, which could require reporting under the statute, are:
Glycol CAS# 107-21-1 Content <10 % 100 ppm ACGIH
Superfund Amendments and Reauthorization Act of 1986 (SARA) Title III requires emergency planning based on
Threshold Planning Quantities (TPQs) and release reporting based on Reportable Quantities (RQs) in 40 CFR 355 used
for SARA 302, 304, 311 and 312.
Components present in this product at a level, which could require reporting under the statute, are:
Glycol CAS# 107-21-1 Content <10 % 100 ppm ACGIH
Requires submission of annual reports of release of toxic chemicals that appear in 40 CFR 372 (for SARA 313).
This information must be included in all Material Safety Data Sheets that are copied and distributed for this material.
Components present in this product at a level, which could require reporting under this statue, are:
Glycol CAS# 107-21-1 Content <10% 100 ppm ACGIH
The information in this document is believed to be correct as of the date issued, however, no warranty of merchantability, fitness for any
particular purpose, or any other warranty is expressed or is to be implied regarding the accuracy or completeness of this information, the
results to be obtained from the use of this information or the product, the safety of this product, or the hazards related to its use. This
information and product are furnished on the condition that the person receiving them shall make his own determination as to the
suitability of the product for his particular purpose and on the condition that he assumes the risk of his use thereof.
C&W UNLIMITED
CARLSTADT, NJ 07072
(201) 933-4343
|