MSDS
MATERIAL SAFETY DATA SHEET
C & W PRESSROOM PRODUCTS HAZARD RATING HMIS RATING
180 EAST UNION AVE 4 = EXTREME HEALTH 1
EAST RUTHERFORD, NJ 07073 3 = HIGH FLAMMABILITY 1
2 = MODERATE REACTIVITY 0
EMERGENCY TELEPHONE NUMBER 1 = SLIGHT PERSONAL
201-933-4343 0 = INSIGNIFICANT PROTECTION X
DATE ISSUED: July 10, 2004
SECTION I PRODUCT INFORMATION
PRODUCT NAME : SAFE CF 127P
CHEMICAL NAME : Complex Mixture
MOLECULAR FORMULA : Mixture
SYNONYMS : None
CHEMICAL FAMILY : Complex Mixture of Organic Compounds
SECTION II HAZARDOUS COMPONENT INFORMATION
CAS# CONTENT % TLV/TWA
COMPONENTS : Glycol Ether 112-34-5 < 8% 25 ppm (skin) ACGIH
SECTION III PHYSICAL PROPERTIES
BOILING POINT : 214掳F MELTING POINT : N/A
SPECIFIC GRAVITY (H2O = 1) : 1.04 / 25掳C VAPOR PRESSURE : Not Available
SOLUBILITY IN WATER : Miscible VAPOR DENSITY (AIR = 1) :
pH (as is) : 3.7
EVAPORATION RATE
VOC鈥檚 (lbs. per gallon) : .61 Method 24 (n-BuOAc = 1.0) : 0.5
APPEARANCE & ODOR : Teal Liquid With No Apparent Odor
SECTION IV FIRE & EXPLOSION DATA
FLASH POINT : Not Combustible
FLAMMABLE LIMITS : None
EXTINGUISHING MEDIA : Water fog or water spray
SPECIAL FIRE FIGHTING PROCEDURES:
Water may be used to keep fire-exposed containers cool until fire is out.
UNUSUAL FIRE AND EXPLOSIVE HAZARDS :
No explosion hazards
SECTION V HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE : Not established. See page 1 for individual components
EFFECT OF OVEREXPOSURE :
EYES : May cause irritation
SKIN : May cause irritation.
INHALATION : May cause coughing and difficult breathing.
INGESTION : May cause headache, nausea, vomiting, gastrointestinal irritation, convulsions and unconsciousness.
EMERGENCY AND FIRST AID TREATMENT:
EYES : Flush eyes with plenty of water for at least 15 minutes
SKIN : Wash with plenty of soap and water for at least 15 minutes
INHALATION : If breathing is difficult, remove individual to fresh air. Seek medical attention.
INGESTION : If person is conscious, immediately give large amounts of water. Do not induce vomiting
Seek medical attention.
CHRONIC EFFECT(S) OF OVEREXPOSURE: No known chronic effects.
SECTION VI REACTIVITY DATA
STABILITY : Stable at ordinary condition
INCOMPATIBILITY / AVOID CONTACT WITH : Strong oxidizing agents
HAZARDOUS DECOMPOSITION PRODUCT : Carbon dioxide and/or monoxide
HAZARDOUS POLYMERIZATION : Will not occur
CONDITION TO AVOID : None
SECTION VII SPILL OR LEAK PROCEDURE
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
If possible recover free liquid prior to disposal. Soak up small spills with suitable absorbents.
Flush the exposed area with large quantities of water into sewer or suitable container.
WASTE DISPOSAL METHOD:
Small quantities may be run to sewer.
Comply with all applicable federal, state and local regulations.
SECTION VIII SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION (SPECIFY TYPE) : Use NIOSH-approved respirator during fire fighting conditions
VENTILATION :
LOCAL EXHAUST : Use general ventilation if necessary
MECHANICAL (GENERAL) : Acceptable
OTHER :
PROTECTIVE GLOVES : Impervious
EYE PROTECTION : Safety goggles
OTHER PROTECTIVE EQUIPMENT : Uniform or apron
SECTION IX SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE :
Keep in tightly sealed container. Suitable for any general chemical storage area. Isolate from incompatible materials
OTHER PRECAUTIONS :
Avoid contact of foods.
SECTION X REQUIREMENTS FOR TRANSPORTATION
PROPER SHIPPING NAME : Safe CF 127P
Chemicals, N.O.S. (Non-regulated)
HAZARDOUS CLASSIFICATION : Not DOT regulated
IDENTIFICATION NUMBER : None
REPORTABLE QUANTITY : None
IMCO CLASS (International Travel) : Chemicals, N.O.S. (Non-regulated)
ADDITIONAL LABELING : None
SECTION XI REGULATORY INFORMATION
Status on Substance List
FEDERAL EPA
Comprehensive Environmental Response, Compensation, and Liability Act of 1980 (CERCLA) requires notification of the
National Response Center of release of quantities of hazardous substances equal to or greater than the reportable quantities
(RQ鈥檚) in 40 CFR 302.4
Components present in this product at a level which could require reporting under the statute are:
Glycol Ether CAS# 112-34-5 Content 7.1 % TLV/TWA 25 ppm (skin) ACGIH
Superfund Amendments and Reauthorization Act of 1986 (SARA) Title III requires emergency planning based on
Threshold Planning Quantities (TPQs) and release reporting based on Reportable Quantities (RQs) in 40 CFR 355 used
for SARA 302, 304, 311 and 312.
Components present in this product at a level which could require reporting under the statute are:
Glycol Ether CAS# 112-34-5 Content 7.1 % TLV/TWA 25 ppm (skin) ACGIH
Requires submission of annual reports of release of toxic chemicals that appear in 40 CFR 372 (for SARA 313).
This information must be included in all Material Safety Data Sheets that are copied and distributed for this material.
Components present in this product at a level which could require reporting under this statue are:
Glycol Ether CAS# 112-34-5 Content 7.1 % TLV/TWA 25 ppm (skin) ACGIH
The information in this document is believed to be correct as of the date issued, however, no warranty of merchantability, fitness for any
particular purpose, or any other warranty is expressed or is to be implied regarding the accuracy or completeness of this information, the
results to be obtained from the use of this information or the product, the safety of this product, or the hazards related to its use. This
information and product are furnished on the condition that the person receiving them shall make his own determination as to the
suitability of the product for his particular purpose and on the condition that he assumes the risk of his use thereof.
C&W PRESSROOM PRODUCTS
E. RUTHERFORD, NJ 07073
(201) 933-4343 mw 2004
|