TECH LINE COATINGS, INC.
26844 Adams Ave. MURRIETA, CA 92562 USA
Phone 951-304-0498
Fax 951-461-9658
www.techlinecoatings.com
MATERIAL SAFETY DATA SHEET
SECTION I
COMMON NAME(S): TLHB
CHEMICAL NAME(S) AND SYNONYM(S): BONDED SOLID FILM COATING
CHEMICAL FAMILY: N/A
FORMULA: Complex Mixture
EMERGENCY PHONE: (Chemtrec) 1-800-424-9300
INFORMATION PHONE: 951-304-0498
DATE PREPARED: 7/2/2003 (update)
SECTION II
HAZARDOUS INGREDIENTS
COMPONENT CAS# CONCENTRATIONS
METHYL ETHYL KETONE 78-93-3 20-40%
ACGIH TLV: 200 PPM
OSHA PEL: 200 PPM
ETHANOL 64-17-5 20=30%
ACGIH TLV: 1000 PPM
OSHA PEL: 1000 PPM
METHANOL 67-56-1 <5%
ACGIH TEL: 200 PPM
OSHA PEL: 200 PPM
RESIDUAL PHENOL 108-95-2 TRACE
ACGIH TLV: 5 PPM (SKIN)
OSHA PEL: 5 PPM (SKIN)
RESIDUAL FORMALDEHYDE 50-00-0 TRACE
ACGIH TLV: 1 PPM
OSHA PEL: 1 PPM
MOLYBDENUM DISULFIDE 1317-33-5 10%
ACGIH TLV: 10 mg/m3
OSHA PEL: 10 mg/m3
SECTION III
PHYSICAL CHARACTERISTICS____________________________________
BOILING POINT: NOT AVAILABLE.
VAPOR DENSITY ( AIR = 1) : >1
VAPOR PRESSURE: NOT AVAILABLE
MELTING POINT: NOT AVAILABLE
APPEARANCE AND ODOR: GRAY LIQUID/SOLVENT SMELL
SOLUBILITY IN WATER: MODERATE
REACTIVITY IN WATER: NOT AVAILABLE
VOC'S: 810 GRAMS/L
SHIPPING: Flammable Liquid UN1263, PG II
SECTION IV
FIRE AND EXPLOSION HAZARD DATA_____________________________
FLASH POINT: 16F.
FLAMMABLE LIMITS:
LEL- NOT ESTABLISHED
UEL- NOT ESTABLISHED
DOT: FLAMMABLE LIQUID
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL
Page 1
SPECIAL FIRE FIGHTING PROCEDURES: USE FULL PROTECTIVE EQUIPMENT, INCLUDING SELF CONTAINED BREATHING APPARATUS.
DO NOT EXTINGUISH WITH WATER
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE
SECTION V
REACTIVITY DATA
STABILITY: STABLE
INCOMPATIBILITY ( MATERIALS TO AVOID ) : CONTACT WITH STRONG OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION PRODUCTS: IRRITATING AND/OR TOXIC FUMES INCLUDING OXIDES OF CARBON AND SULFUR, AND
HYDROGEN SULFIDE MAY BE RELEASED
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
CONDITIONS TO AVOID: OPEN FLAME
SECTION VI
HEALTH HAZARD DATA__________________________________________________
ROUTES OF ENTRY:
INHALATION ? YES
SKIN ? YES
INGESTION ? YES
TOXICITY (ACUTE AND CHRONIC )
METHYL ETHYL KETONE ( CAS# 78-93-3 ) IS AN EYE AND SKIN IRRITANT, AFFECTS THE NERVOUS SYSTEM, AND IS A TERATOGEN IN LAB
ANIMALS.
CARCINOGENICITY: NPT-NO IARC-NO OSHA-NO
ETHANOL ( CAS# 64-17-5 ) IS A MILD IRRITANT TO RABBIT SKIN AND A SEVERE EYE IRRITANT. ETHANOL IS REPORTED TO CAUSE
TERATOGENICITY, CNS DEPRESSION, GASTROINTESTINAL DISTRESS FROM ORAL CONSUMPTION BY HUMANS. NO TOXICITY IS
REPORTED FROM INHALATION BELOW TWA.
CARCINOGENICITY: NPT-NO IARC-NO OSHA-NO
METHANOL ( CAS# 67-56-1 ) IS A SKIN, EYE AND INHALATION IRRITANT. IT IS TOXIC ORALLY AND POSSESSES NARCOTIC PROPERTIES.
TOXIC EFFECTS MANIFESTED IN THE CENTRAL NERVOUS SYSTEM AND PARTICULARLY IN THE OPTIC NERVE. METHANOL IS A
CUMULATIVE POISON. SEVERE EXPOSURE TO METHANOL CAN CAUSE DIZZINESS, UNCONSCIOUSNESS, SIGNING RESPIRATION, CARDIAC
DEPRESSION AND EVENTUAL DEATH. LESS SEVERE EXPOSURE TO METHANOL CAN CAUSE BLURRING OF VISION, PHOTOPHOBIA,
CONJUNCTIVITIS, EYE LESIONS, HEADACHE, GASTROINTESTINAL DISTURBANCES, DIZZINESS AND A FEELING OF INTOXICATION. DEATH
FROM INGESTION OF LESS THAN 30ml HAS BEEN REPORTED. USUAL FATAL DOSE IS 100-250 ml.
CARCINOGENICITY: NTP-NO IARC-NO OSHA-NO
THE ORAL LD50 OF PHENOL ( CAS# 108-95-2 ) IS 414 mg/kg AND IT'S INHALATION LC50 (RAT) IS 316 mg/m3. PHENOL IS CONSIDERED TOXIC
ORALLY. IT IS A SEVERE SKIN AND EYE IRRITANT IN RABBITS.
(PHENOL)
CARCINOGENICITY: NTP-NO IARC-NO OSHA-NO
FORMALDEHYDE (CAS# 50-00-0 ) IS HIGHLY IRRITATING TO SKIN, EYES, MUCOUS MEMBRANES, AND CAN CAUSE HYPERSENSITIVITY
LEADING TO CONTACT DERMATITIS. FORMALDEHYDE IS LISTED BY THE IARC AS AN INDEFINITE HUMAN CARCINOGEN AND A POSITIVE
ANIMAL CARCINOGEN. IT MAY REASONABLY BE ANTICIPATED TO BE A HUMAN CARCINOGEN ACCORDING TO THE NTP ANNUAL REPORT
CARCINOGENICITY: NTP-YES IARC-YES OSHA-NO
(ANIMAL POSITIVE)- (HUMAN INDEFINITE)
MOLYBDENUM COMPOUNDS MAY BE SLIGHTLY IRRITATING.
CARCINOGENICITY: NPT-NO IARC-NO OSHA-NO
HEALTH HAZARDS:
EYES: IRRITATION, REDNESS, TEARING AND BLURRED VISION
SKIN: PROLONGED OR REPEATED CONTACT CAN CAUSE IRRITATION, DERMATITIS
INHALATION: EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL
AND RESPIRATORY IRRITATION, DIZZINESS, FATIGUE, NAUSEA, HEADACHE, POSSIBLE UNCONSCIOUSNESS, DEATH
INGESTION: CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND DIARRHEA.
EMERGENCY AND FIRST AID:
EYES: IMMEDIATELY FLUSH WITH PLENTY OF WATER, CALL A PHYSICIAN
( FLUSH FOR AT LEAST 15 MIN., INCLUDING UNDER EYELIDS )
SKIN: WASH WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING IF IRRITATION OCCURS GET MEDICAL ATTENTION
INHALATION: REMOVE INDIVIDUAL TO FRESH AIR. ADMINISTER OXYGEN IF
BREATHING IS DIFFICULT. CALL A PHYSICIAN
Page 2
INGESTION: CALL A PHYSICIAN IMMEDIATELY. DO NOT INDUCE VOMITING , KEEP WARM
* INTENTIONAL MISUSE BY DELIBERATE CONCENTRATING AND INHALING THE CONTENTS MAY BE HARMFUL OR FATAL
SECTION VII
SPILL OR LEAK PROCEDURES___________________________________
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: CLEAN SPILL WITH ABSORBENT MATERIAL, ELIMINATE IGNITION
SOURCES, WEAR PROTECTIVE GLOVES, GOGGLES AND MASK IF TWA'S ARE EXCEEDED
WASTE DISPOSAL METHOD: DISPOSAL SHOULD BE MADE IN ACCORD WITH FEDERAL, STATE AND LOCAL REGULATIONS.
OTHER PRECAUTIONS: NONE
SECTION VIII
SPECIAL PROTECTION / CONTROL MEASURES:____________________
RESPIRATORY PROTECTION: USE NIOSH APPROVED RESPIRATOR IF TWA/TLV LIMITS ARE EXCEEDED
VENTILATION:
LOCAL EXHAUST: USE TO MAINTAIN BELOW TWA LIMITS
MECHANICAL: USE NON-SPARKING EQUIPMENT
PROTECTIVE GLOVES: CHEMICAL RESISTANT
EYE PROTECTION: SAFETY GLASSES WITH SIDE SHIELDS OR GOGGLES
OTHER PROTECTIVE EQUIPMENT: WEAR PROTECTIVE CLOTHING, CHEMICAL RESISTANT OR OTHER PROTECTIVE OUTERWEAR, AVOID
CONTACT WITH SKIN OR EYES
WORK / HYGIENIC PRACTICES: WASH THOROUGHLY AFTER HANDLING PRODUCT AND BEFORE EATING, DRINKING OR SMOKING
SECTION IX
SPECIAL PRECAUTIONS___________________________________________
HANDLING AND STORAGE: STORE IN A COOL DRY PLACE, SUITABLE FOR OSHA CLASS 1 FLAMMABLE LIQUIDS
FEDERAL REGULATIONS:
Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA).
This product contains a chemical or chemicals which are subject to the reporting requirements of the 鈥淎ct and Title 40 of the
Code of Federal Regulations, Part 372.
CHEMICAL CAS NUMBER PERCENTAGE
DIMETHYL PHTHALATE 131-11-3 45.64840000
FEDERAL REGULATIONS:
Clean Air Act, Section 112 Hazardous Air Pollutants (HAPs), under the reporting requirements of 40 CFR 61. This product
contains the following HAPs:
CHEMICAL
DIMETHYL PHTHALATE 131-11-3 45.64840000
TOXIC SUBSANCES CONTROL ACT (TSCA): All chemicals in this product appear in the Toxic
Substance Control Act Chemical Substance Inventory.
SARA Title III Section 313 Supplier Notification
This product is known to contain the following chemicals, which are listed in 40 CFR 372.65 as toxic chemicals requiring
notification. This information must be included in all MSDS鈥檚 that are copied and distributed for this product.
COMPONENT CAS# % BY WEIGHT
Phenol 108-95-2 7.5 max.
Methanol 67-56-1 4.0 max.
Formaldehyde 50-00-0 0.5 max.
California safe Drinking Water and Toxic Enforcement Act (Proposition 65) :
This Product contains the following substance(s) known to the State of California to cause cancer:
Formaldehyde
------------------------------------------------------------------------------------------------------------------
THIS INFORMATION IS FURNISHED WITHOUT WARRANTY, REPRESENTATION, INDUCEMENT OR LICENSE OF ANY KIND, EXCEPT
THAT IT IS ACCURATE TO THE BEST OF TECH LINE COATINGS, INC., KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY
TECH LINE COATINGS, INC. TO BE ACCURATE, AND TECH LINE COATINGS, INC., DOES NOT ASSUME ANY LEGAL RESPONSIBILITY
FOR USE OR RELIANCE UPON SAME. BEFORE USING ANY CHEMICAL, READ ITS LABEL, INSTRUCTIONS AND MATERIAL SAFETY
DATA SHEET.
Page 3
|