ELECTRONIC SPACE PRODUCTS INTERNATIONAL
1050 Benson Way, Ashland, OR 97520
Toll Free (800) 638-2581 * Fax (541) 488-8313
E-Mail: sales@espimetals.com
MATERIAL SAFETY DATA SHEET
I PRODUCT IDENTIFICATION
Magnesium Magnesium M etal
Trade Name: Synonym:
Plasma Standards Mg
Ch em ical Fam ily: Form ula:
7439-9 5-4 24.31
CAS #: Molecular Weight:
II HAZAR DOUS INGRED IENTS
Haz ardous C omp onents % OSHA/PEL ACGIH/TLV
15 m g/m 3 (For M gO fum e, as Mg) 10 m g/m 3 (For MgO fume, as Mg)
Magnesium 0-100
III PHYSICAL DATA
1107 oC 648.8 oC
Boiling Point 760 mm Hg: Melting Point:
1.74 No t Applicab le
Specific Gravity: Vapo r Density:
No t Applicab le Insoluble
% V olatiles by Weight: Solubility in H 2O:
Silver-white metal
Appearance and Odor:
IV FIRE AND EXPLOSION H AZARDS DATA
Flash Point: N/A
Flam mab le Limits: Upper: N/A Lower: N/A
Extingu ishing Media: Melting flux, dry sand, metal extinguishing powders such as G-1, MET-L -X, etc.
Special Fire Fighting Procedures: Use of water on a m agnesium fire will produce h ydrogen gas and m ay cause an exp losion. In
fire conditions, protect eyes and sk in against flying p articles. A void direct view ing o f magn esium fires as eye injury ma y resu lt.
Unusual Fire & Explosion Hazards: Com bustible m etal. Fine powd er, oil or turnings are easily ignited an d bu rn w ith inten se heat
and brilliant w hite flam e. Powd ers form explosive mix tures w ith air w hich ma y be ignited by a spark . Pieces >3 mm thick difficu lt to
ignite but possible when su fficient heat is applied. In finely divided form will react with w ater, haloge ns, oxidizing agen ts and acids.
V HEALTH HAZARD INFORMATION
Threshold Limit Value: For m agn esium oxid e fum e, as M g: TL V 1 0 m g/m 3 OSHA /PEL 15 m g/m 3.
Effects of Over Expo sure: Dust is an irritant to eyes and mucous m embranes. Small particles imbedded in skin may cause
ulceration which m ay becom e infected. Inhalation of excessive conc entrations of oxide fume m ay cause m etal fume fever.
Medical Conditions Aggravated by Exposure: Damaged skin, eye disorders, cardiopulmonary disease.
Carcino genicity: None identified.
EMERG ENCY AND FIRST AID PROCEDURES:
INHALATION/INGESTION: Remove from exposure, seek imm ediate medical attention.
SK IN: Rem ove any contam inated clothing, b rush ma terial off of skin, flush with running water, wash carefu lly with soap and w ater.
Remove splinters to avoid delays in healing.
EYE: Flush w ith copiou s amo unts of w ater for 15 minu tes.
VI REACTIVITY DATA
Stability: Stable
Incompatibility (Material to Avoid): Moisture, Acids
Haz ardous D ecomposition Produc ts: Acids to form hydrogen gas
Hazardous Polymerization: Will not occur
VII SPILL OR LEAK PROC EDURES
Steps to be Taken in Case Material is Released or Spilled: Clean up using n on-spark ing to ols. No sm okin g or open flam es in
clean up area.
Waste Disposal Method: In accord ance w ith Loca l, State and Federal W aste Dispo sal Regu lations.
VIII SPECIAL PROTECTION INFORMATION
Respiratory Protection (Specify Type): NIOSH-approved respirator for concentrations encountered.
Ventilation: Fume hood for dust, fumes
Protective Gloves: Rubber
Eye Protection: Safety Glasses
Other Protective Equipment: As needed to prev ent co ntact.
IX SPECIAL PRECAUTIONS
Other Handling and Storage Conditions: Protect against physical dama ge. Store finely divided ships or shavings in detached fire
resistive building protected from moisture and away from halogens, acids, and all sources of ignition. Heavier may be stored in the
open.
US Precautionary Labeling: POISON!! DANGER!! CAUSES SEVERE IRRITATION. HARMFUL IF SWALLOWED OR
INH ALE D. Do n ot get in eyes, on skin, on clothing. Do not breathe vap or. Keep in tightly closed container. Loosen closure
cautiously. Use with adequate ventilation. Wash thoroughly after handling. In case of spill neutralize with soda ash or lime and
place in dry container.
International Labeling: Avoid contact with eyes. After contact with skin, wash imm ediately with plenty of water. Keep container
tightly closed.
Issued By: S. Dierks
Date: December 2001
-Magnesium 2-
|