Huntsman Advanced Materials Americas Inc.
Distributed by Freeman Mfg & Supply Co.
800-321-8511 www.freemansupply.com
24-Hour Emergency Phone: (800) 328-8501
MSDS No: 6099
Effective Date: 8/26/05 Material Safety Data Sheet
Health: 2
1. PRODUCT IDENTIFICATION 1
Flammability: 1
2 0
Reactivity: 0
Trade Name: Ren 6402-1
Personal Protection:
Chemical Family: Polyol
HMIS RATING
NFPA RATING
Synonyms:
RP 6402-1 Hardener
TDT 178-75 Hardener
Intended Use or Product Type: Polyol hardener
2. COMPOSITION / INFORMATION ON INGREDIENTS
O CAS No. CHEMICAL IDENTITY EXPOSURE LIMITS CARCINOGEN
S STATUS
H ACGIH OSHA MFR. IARC NTP OSHA
A TWA STEL PEL STEL
* 120-07-0 Ethanol, 2,2'-(Phenylimino)bis- NE NE NE NE NE NR NR NR
Common N,N-Hydroxyethyl aniline
Name:
* = OSHA Hazardous Ingredient
3. HAZARDS IDENTIFICATION
Emergency Overview: Causes skin and eye irritation.
Primary Route(s) of Entry: Dermal; heated product may produce inhalable vapors.
4. FIRST AID MEASURES
Ingestion: If conscious, give 2 - 4 glasses of water to drink. Do not induce vomiting. Call a physician.
Skin: Immediately wash with soap and water. Remove contaminated clothing and launder before reuse. Destroy contaminated
shoes.
Inhalation: Remove to fresh air. Call a physician.
Printed: 9/16/2005 Page 1 of 1
Ren 6402-1 Huntsman Advanced Materials
Americas Inc. (EL)
Effective Date: 8/26/05
Eyes: Immediately flush eyes with water for at least 15 minutes. Call a physician.
Overexposure Effects: Causes skin and eye irritation.
Medical Conditions Aggravated by Exposure: Skin and eye conditions.
Additional Information: Referral to a physician is recommended if there is any question about the seriousness of any injury.
5. FIRE FIGHTING MEASURES
Flash Point: > 200掳F (> 93 掳C)
Flash Point Method Used: Estimated
Flammable Limits in Air (Lower - % by volume): Not established
Flammable Limits in Air (Upper - % by volume): Not established
Fire Fighting Extinguishing Media: Carbon dioxide, dry chemical, foam, water.
Fire Fighting Equipment: Use self-contained breathing apparatus.
Fire and Explosion Hazards: Decomposition and combustion products may be toxic.
6. ACCIDENTAL RELEASE MEASURES
Accidental Release Measures: Remove spillage by absorbing in absorbent material.
7. HANDLING AND STORAGE
Signal Word: Warning!
Precautions: Can cause skin and eye irritation. Avoid contact with eyes, skin, and clothing. Wash thoroughly after handling.
Other Handling Information: Nuisance dust may be generated when sanding or sawing cured material.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Skin Protection: Wear impermeable gloves.
Respiratory Protection: Use NIOSH approved organic vapor cartridge respirator when vapor/mist exposure is likely.
Eye Protection: Wear splash-proof chemical goggles.
Engineering Controls: General mechanical and local exhaust in accordance with ACGIH recommendations.
9. PHYSICAL AND CHEMICAL PROPERTIES
Color: Off White
Physical State: Liquid
Printed: 9/16/2005 Page 2 of 2
Ren 6402-1 Huntsman Advanced Materials
Americas Inc. (EL)
Effective Date: 8/26/05
Solubility in Water: Slight
Vapor Pressure: Not Determined
Specific Gravity: 1.04 (water = 1)
Boiling Point: Not Determined
Evaporation Rate: Not Determined
Vapor Density: Not Determined
VOC: 0.0853 g/L
pH: Not Determined
Percent Volatile: Negligible.
10. STABILITY AND REACTIVITY
Conditions to Avoid: Excessive heat for prolonged periods of time.
Stability: Stable.
Incompatibility: Strong oxidizers, acids and bases.
Hazardous Decomposition Products: Combustion may form toxic materials, such as carbon dioxide, carbon monoxide.
Hazardous Polymerization: Will not occur.
11. TOXICOLOGICAL INFORMATION
Skin Irritation: Irritant.
Eye Irritation: Irritant.
12. ECOLOGICAL INFORMATION
13. DISPOSAL CONSIDERATIONS
Waste Disposal Method: Consult qualified local or corporate personnel for method that will comply with local, state and federal
health and environmental regulations.
Additional Information: Disposal of Cured Product: This product when cured may contain very small quantities of organic
mercury compounds. It is the responsibility of the user to determine if the selected disposal method complies with applicable
regulations.
14. TRANSPORT INFORMATION
DOT: Non-Bulk
Proper Shipping Name: Resin compounds, N.O.I.
Department of Transportation: Not regulated as a hazardous material by the U.S. Dept. of Transportation (DOT) 49 CFR
172.101 hazardous materials table.
Printed: 9/16/2005 Page 3 of 3
Ren 6402-1 Huntsman Advanced Materials
Americas Inc. (EL)
Effective Date: 8/26/05
15. REGULATORY INFORMATION
US Federal Regulations:
Occupational Safety and Health Act (OSHA): This Material Safety Data Sheet (MSDS) has been prepared in compliance with
the federal OSHA Hazard Communication Standard 29 CFR 1910.1200. This product is considered to be a hazardous chemical
under that standard.
Resource Conservation and Recovery Act (RCRA): D 009 contains mercury.
SARA Title III: Section 313 Toxic Chemical List (TCL): This product does not contain any chemicals for routine annual toxic
chemical release reporting under Section 313 (40 CFR 372).
TSCA Section 8(b) - Inventory Status: All chemical components of this product are in compliance with TSCA inventory
requirements.
TSCA Section 12(b) - Export Notification: This product does not contain any chemical(s) that are subject to a Section 12(b)
export notification.
State Regulations:
California Proposition 65: The following is required composition information. This product contains the following chemical(s)
which are currently listed on the California list of Known Carcinogens and Reproductive Toxins:
Chemical Name: Mercury catalyst
CAS Number: Held confidential by our supplier
Percent in Composition: 0.2 % by wt
Comment: Warning! This chemical is known to the State of California to cause birth defects or other reproductive harm.
Chemical Name: 2- Propenenitrile
Common Name: Acrylonitrile
CAS Number: 107-13-1
Percent in Composition: 0.0023 % by wt
Comment: Warning! This chemical is known to the State of California to cause cancer.
Pennsylvania Right-to-Know: The following is required composition information:
Chemical Name: Polymer Polyol
CAS Number: Confidential
Comment: Not on Pennsylvania Hazardous Substance List
Chemical Name: 1,4- Butanediol
Common Name: 1,4-Butanediol
CAS Number: 110-63-4
Comment: Not on Pennsylvania Hazardous Substance List
16. OTHER INFORMATION
MSDS No: 6099
Approved By: Dianne Blessing
Title: EH&S Specialist
Printed: 9/16/2005 Page 4 of 4
Ren 6402-1 Huntsman Advanced Materials
Americas Inc. (EL)
Effective Date: 8/26/05
Disclaimer: The information and recommendations contained herein are based upon tests in controlled laboratory conditions, are
believed to be correct, and are provided for the sole purpose of hazard communication as part of Huntsman鈥檚 product safety
program. This product has not been tested for, and therefore is not recommended or suitable for, uses for which prolonged contact
with mucous membranes, abraded skin, or blood is intended or likely, or for uses for which implantation within the human body is
intended, and Huntsman assumes no liability for any such uses.
The information and recommendations contained herein are not intended to constitute performance information concerning the
product, which is available in separate technical data sheets available from Huntsman upon request. Users are urged, and are urged
to urge others who may come in contact with the product, to obtain and consult data sheets prior to purchase, use, transportation or
storage of the product.
HUNTSMAN MAKES NO REPRESENTATION OR WARRANTY, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY, QUALITY, OR FITNESS FOR A PARTICULAR PURPOSE. HUNTSMAN鈥橲 LIABILITY IS
STRICTLY LIMITED TO REIMBURSEMENT OF BUYER鈥橲 PURCHASE PRICE, OR IN HUNTSMAN鈥橲 DISCRETION
REPLACEMENT, OF THE PRODUCT IN RESPECT OF WHICH SUCH CLAIM IS MADE. HUNTSMAN鈥橲 LIABILITY IS
STRICTLY LIMITED BY LEGAL NOTICES IN TECHNICAL DATA SHEETS, PRODUCT LITERATURE AND/OR SALE
DOCUMENTS. The foregoing DISCLAIMERS and LIMITATION OF LIABILITY supercede inconsistent or contradictory
provisions in Buyer鈥檚 documents.
USER SHOULD CONSULT A LEGAL ADVISOR OR THE APPROPRIATE GOVERNMENTAL AGENCY TO DETERMINE
THE APPLICABILITY OR EFFECT OF ANY LAW OR REGULATION WITH RESPECT TO THE PRODUCT. HUNTSMAN
DOES NOT UNDERTAKE TO FURNISH ADVICE ON SUCH MATTERS.
Printed: 9/16/2005 Page 5 of 5
|