MATERIAL SAFETY DATA SHEET
THE HALLSTAR COMPANY
Section 1 - Identification of Substance and Company
Product Name: HALLCO庐 CaOP Product Code: 2210
Chemical Name: Di 2-Ethylhexyl Phthalate and Calcium Hydroxide
The HallStar Company (1)
Supplier: HMIS
120 S. Riverside Plaza Suite 1620 Health: 2
Chicago, IL 60606 PH: 877-427-4255 Flammability: 0
USA Reactivity: 0
Gloves, Safety Goggles, Dust Mask
Emergency Phone Numbers: The HallStar Company: (708) 594-5999
CHEMTREC: (800)424-9300
Section 2 - Information on Ingredients
Chemical Name CAS#
Calcium Hydroxide 1305-62-0
Section 313 Supplier Information: This product contains the following toxic chemicals subject to the reporting
requirements of Section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and of
40 CFR 372:
Chemical Name CAS# Percent by Weight
Di(2-Ethylhexyl)Phthalate 117-81-7 20
Section 3 - Hazard Identification
Appearance/Odor: Light brown powder; mild odor.
CAUTION: Di(2-ethylhexyl) Phthalate may cause cancer based on animal data; risk of cancer depends on duration
and level of exposure. The relevance to potential human cancer is unknown. DEHP is considered an IARC 2B
carcinogen: Possible human carcinogen, human evidence inadequate, animal evidence sufficient.
Potential Health Effects
Skin Contact: Repeated or prolonged skin contact may cause burns or irritation.
Eye Contact: Avoid contact with eyes, will cause irritation.
Ingestion: Substance may be harmful if swallowed. May irritate mouth, throat and stomach.
Inhalation: May cause dizziness.
Page 1 of 4
Revision 06/07
Product Name: HALLCO庐 CaOP
Section 4 - First Aid Measures
Skin Contact: Wash affected skin with soap and water. Seek medical attention if symptoms persist.
Eye Contact: Flush eyes with large amounts of water for at least 15 minutes. If irritation persists,
consult a physician.
Ingestion: Seek medical advice.
Inhalation: Person should be moved to a fresh air environment.
Section 5 - Explosion and Fire-Fighting Measures
Extinguishing Media: Not flammable or explosive.
Special Fire-Fighting Procedures: N/A
Unusual Fire and Explosion Hazards: None
Section 6 - Accidental Release/Spill Procedures
Steps to be Taken in Case Material is Released or Spilled: Dike and contain the spill with inert material (i.e., sand,
earth, sawdust) and transfer solid diking material to separate containers for recovery or disposal. Wash floor area with
hot water solution. Remove contaminated clothing and wash before reuse. Wash affected skin areas with soap and
water. Keep spills out of all sewers and bodies of water.
Section 7 - Handling and Storage
Any use of this product in an elevated process should be evaluated to establish and maintain safe operating
procedures.
Containers should be kept tightly closed and stored in a dry well-ventilated place.
Precautions to be Taken in Handling and Storing: Material may ignite when exposed to conditions of high heat.
Avoid open flames and excessive heat.
Section 8 - Personal Protection
OSHA Permissible Exposure Limit (PEL): For DOP: 5 mg/m3 TWA
Hand Protection: Neoprene or Viton gloves
Eye Protection: Safety Goggles
Respiratory Protection: Dust mask. If the PEL for DOP is exceeded, a respirator with appropriate cartridges
should be worn.
Engineering Measures: For normal operation, local exhaust ventilation should suffice.
Other: Long sleeve shirts, long pants, and protective creams on exposed skin. Eyewash facility
in vicinity.
Page 2 of 4
Revision 06/07
Product Name: HALLCO庐 CaOP
Section 9 - Physical and Chemical Properties
Boiling Point: N/A Specific Gravity: 2.07
Flash Point (COC): N/A Evaporation Rate: N/A
Vapor Density (Air=1): N/A Solubility in Water (25掳C): N/A
掳
Vapor Pressure (20掳C): N/A pH: N/A
Appearance and Odor: Light brown powder; mild odor.
Section 10 - Stability and Reactivity
Stability: This product is stable in airtight containers.
Conditions to Avoid: Excessive heat, humidity. Substance decomposes upon heating, producing
calcium oxide.
Hazardous Polymerization: Will not occur under normal circumstances; oxides of carbon when burned.
Incompatibility (materials to avoid): Acids, CO2
Section 11 - Toxicological Information
See Section 3 - Hazard Identification
Section 12 - Ecological Information
This product does not contain any ozone depleting compounds (ODC鈥檚).
Section 13 - Disposal Considerations
Waste Disposal Methods: Material should be disposed of in accordance to current local, state and national
regulations. Contacting a waste disposal service is recommended.
Section 14 - Transport Information
Air: This product is not regulated under IATA regulations when shipped in quantities less than 500 lbs. in one
container.
Ocean: This product is not regulated under IMDG regulations when shipped in quantities less than 500 lbs. in one
container.
Ground: This product is not regulated under DOT regulations when shipped in quantities less than 500 lbs. in one
container. When shipped in quantities of 500 lbs. or greater the following information is applicable:
Proper Shipping Name: Environmentally Hazardous Substance, Solid, N.O.S.
Technical Name: (Bis(2-ethylhexyl) Phthalate)
Hazard Class: 9
ID Number: UN 3077
Packing Group: III
RQ: 500 lbs.
Page 3 of 4
Revision 06/07
Product Name: HALLCO庐 CaOP
Section 15 - Regulatory Information
Toxic Substances Control Act (TSCA): This product is in compliance with the TSCA regulation of the United
States.
Superfund Amendments and Reauthorization Act (SARA): This product has the following hazards as defined in
Section 311/312 of 40 CFR Part 372:
Hazards
Acute
Chronic
This product contains the following chemicals subject to the reporting requirements of Section 313 or Title III of
SARA and 40 CFR Part 372:
Ingredients CAS # %
Di(2-ethylhexyl) Phthalate 117-81-7 20
California Proposition 65: This product contains the following substances known to the State of California to cause
cancer, birth defects, or other reproductive harm per the Safe Drinking Water and Toxic Enforcement Act of 1986:
Ingredients
Di(2-ethylhexyl) Phthalate
Section 16 - Other Information
Prepared By: AAC Revision Date: 06/07
Supersedes: 04/05
All information is presented in good faith using available information. The HallStar Company makes no representation of the
accuracy or completeness of the information. The user should consider this information as a supplement to other information that
may be available. User should also determine suitability of information in their situation to determine proper use and disposal,
protection of persons and the environment.
(1)
Affiliated companies include RTD*HallStar Company, HallStar Solutions Corp., Ester Solutions Company, Memphis Solutions
Company and Marine Magnesium & Minerals Company.
Page 4 of 4
Revision 06/07
|