SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET GG 225
Threshold Limited Value
ALDON 3
15 Count mppcf; (2.5) mg/m (Respirable mass for mineral dust.)
1533 W.Henrietta Rd.
GG 225
Avon, New York 14414 MSDS No.
庐
CORPORATION March 2, 1995
Effective Date
(716) 226-6177
Effects of Overexposure Dust may cause possible minor irritation to eyes and nasal passages.
Nuisance dust-possibly allergenic. Cases of pulmonary fibrosis,
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE emphysema and corpulmonale have resulted from prolonged inhalation
of graphite dust. Excerise appropriate procedures to minimize potential
Product GRAPHITE, POWDER hazards.
CHEMTREC Health 1
800-424-9300
Chemical
Emergency and
Graphite, Natural; Carbon, Black Lead
Synonyms INHALATION: Remove to fresh air, treat symptomatically and get
Fire 0
Day 716-226-6177
First Aid Procedures medical attention. SKIN: Flush with water, then wash with soap and
Formula C Reactivity 0
NFPA water. EYES: Flush thoroughly with water for at least 15 minutes, lifting
HAZARD RATING HMIS * upper and lower eyelids occasionally. If irritation develops or persists, get
Unit Size up to 2.5 Kg.
LEAST SLIGHT MODERATE HIGH EXTREME medical attention. INGESTION: If swallowed, if conscious, give one or
0 1 2 3 4
C.A.S. No. two glasses of water or milk to drink. Induce vomiting and call physician.
7782-42-5
Never give anything by mouth to an unconscious person.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
Graphite, Powder 96% See Section V. Excessive temperature, flame.
Stable X
Graphite is not a hazardous or toxic material. Incompatibility
None known.
(Materials to Avoid)
Hazardous
CAUTION! DO NOT BREATHE DUST. Burning will produce carbon dioxide and/or carbon monoxide.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) Decomposes on heating. 2.0-2.5
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) Not applicable. Negligible at 70掳F
by Volume (%) X
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) Not applicable. Not applicable.
=1)
(
Steps to be taken in case
Vapor Density (Air=1) Negligible as solid.
Recover for use if not contaminated. Wear protective safety
material is released or spilled
equipment and use adequate ventilation. Avoid making dust.
Solubility in Water Negligible.
Sweep up and place in a suitable container for disposal.
Appearance & Odor Dark gray black, crystalline powder; no odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved incinerator or uncontaminated material may be
% by Volume
Non-volatile solid (NA). NA -------- --------
(Method Used)
disposed of in a sanitary landfill.
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Carbon dioxide (CO ); dry chemical (ABC); water spray.
Media 2
None needed in normal laboratory handling. If dusty conditions prevail, work in
Respiration Protection
(Specify Type) ventilation hood or wear a NIOSH-approved dust mask or respirator.
SPECIAL FIREFIGHTING
Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation Recommended. No.
Mechanical (General) Other
Protective Gloves Eye Protection
Wear NIOSH-approved self-contained breathing apparatus. Rubber. Chemical safety glasses.
Other Protective
Safety glasses, smock, apron, eye wash station, ventilation hood, proper gloves, fire extinguisher.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place away from fire hazards.
in Handling & Storing
EXPLOSION HAZARDS Wash thoroughly after handling.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
No known hazard.
Avoid inhalation of dust. Use adequate ventilation.
Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date Michael Raszeja MR
No. 3 3/2/95 Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|