SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET MM 170
Threshold Limited Value None established by (ACGIH 1992-93). TXDS: Oral-rat LD50: 1310 mg/kg;
ALDON 1533 W.Henrietta Rd. IRDS: Skn-rbt 500 mg/24 H MLD, eye-rbt 100 mg SEV.
MM170
Avon, New York 14414 MSDS No.
庐
CORPORATION December 13, 1996
Effective Date
(716) 226-6177
Effects of Overexposure SKIN: Strong skin irritant on contact. EYES: Strong eye irritant on
contact and may cause burns. INHALATION: Dust may cause upper
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE respiratory tract irritation. INGESTION: No data available. Moderately
toxic; when dissolved in water it is a strong acid.
Product MALONIC ACID CHEMTREC 1
Health
800-424-9300
Chemical
Emergency and
Propanedioic Acid
Synonyms SKIN: Flush with water for 15 minutes. Follow by washing with mild soap
1
Fire
Day 716-226-6177
First Aid Procedures and water. INGESTION: If swallowed, if conscious, give milk or water to
CH (COOH)
Formula 1
Reactivity
2 2
NFPA drink. Call physician. Never give anything by mouth to an unconscious
HAZARD RATING HMIS * person. EYES: Flush thoroughly with water for at least 15 minutes, lifting
up to 500 grams
Unit Size
LEAST SLIGHT MODERATE HIGH EXTREME lower and upper eyelids occasionally. Get medical attention. INHALATION:
0 1 2 3 4 Remove to fresh air. If not breathing, give artificial respiration. If breathing is
C.A.S. No. 141-82-2
difficult, give oxygen. Get medical attention.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
Malonic Acid 100% None established. Excessive temperature and heat.
Stable X
Incompatibility
Strong oxidizers.
(Materials to Avoid)
WARNING! STRONG IRRITANT TO EYES, SKIN AND MUCOUS
Hazardous Thermal decomposition or burning will produce carbon dioxide and/or
MEMBRANES. MAY BE HARMFUL IF INHALED OR SWALLOWED.
Decomposition Products carbon monoxide.
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) 135掳C (275掳F) decomposes. 1.63-1.67 at 20掳C
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) Sublimes in vacuum. Negligible as solid. X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) Negligible as solid. N/A
=1)
(
Steps to be taken in case
Vapor Density (Air=1) 3.6
material is released or spilled Sweep up and place in a suitable container for disposal by
Solubility in Water 154 grams per 100 mL. water at 20掳C. incineration. Wash spill area well with soap and water.
Appearance & Odor Small flat, white crystalline powder; no odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
157掳C (315掳F) C.O.C. N/A
% by Volume
(Method Used) Dispose of in an approved incinerator.
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Water spray; carbon dioxide (CO ); dry chemical.
Media 2
Respiration Protection
Work in fume hood or if dusty conditions prevail, wear NIOSH/MSHA-approved dust mask.
(Specify Type)
SPECIAL FIREFIGHTING
Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation Recommended. No.
Mechanical (General) Other
In fire conditions, wear a NIOSH/MSHA-approved self-contained
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
breathing apparatus and protective clothing to prevent contact with
Other Protective
skin and eyes.
Goggles, smock, apron, eye wash station, ventilation hood, proper gloves.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place away from strong oxidizing materials.
in Handling & Storing
EXPLOSION HAZARDS Wash thoroughly after handling.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Fire or excessive heat may produce hazardous decomposition
products; can react with oxidizing materials. Avoid contact with eyes, skin and clothing. Avoid breathing dust. Use
with adequate ventilation. Wash contaminated clothing before reuse.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date Michael Raszeja MR
No. 5 12/13/96 Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|