SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET LL 30
Threshold Limited Value TWA 3.5 mg/m3 OSHA; STEL 7 mg/m3;
ALDON 1533 W.Henrietta Rd. 3
NIOSH recommended 10 hr. TWA 3.5 mg/m .
LL 30
Avon, New York 14414 MSDS No.
庐
CORPORATION December 12, 1996
Effective Date
(716) 226-6177
Effects of Overexposure
INHALATION: May cause irritation of the nose and respiratory tract. SKIN:
May cause irritation on prolonged contact. EYES: May cause irritation and
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE
discolorization of the lids and conjunctiva. INGESTION: No data available.
Product LAMPBLACK CHEMTREC Health 0
800-424-9300
Chemical
Emergency and
Carbon Black, C.I. No. 77266
Synonyms INHALATION: Remove to fresh air. If breathing has stopped, give artificial
0
Fire
Day 716-226-6177
First Aid Procedures respiration. If breathing is difficult, give oxygen. Get medical attention.
Formula C 0
Reactivity SKIN: Flush thoroughly with water, then wash with mild soap and water.
NFPA
EYES: Flush thoroughly with water for at least 15 minutes, lifting upper and
HAZARD RATING HMIS *
Unit Size up to 2.5 Kg.
lower eyelids occasionally. Get immediate medical attention. INGESTION:
LEAST SLIGHT MODERATE HIGH EXTREME
0 1 2 3 4 Treat symptomatically and supportively. Get medical attention immediately.
C.A.S. No. 1333-86-4
If vomiting occurs, keep head lower than hips to prevent aspiration.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable Excessive temperature and heat.
Lampblack 100% See Section V.
Ignition source.
Stable X
Incompatibility
Strong oxidizers, such as chlorates, bromates, nitrates.
(Materials to Avoid)
CAUTION! DO NOT BREATHE DUST.
Hazardous
Thermal decomposition products may include toxic oxides of carbon.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) 3680掳C (6656掳F) 1.8-2.1
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 4200掳C (7592掳F) Negligible as solid.
by Volume (%) X
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) Negligible as solid. Not applicable.
=1)
(
Steps to be taken in case
Vapor Density (Air=1) Not applicable.
material is released or spilled Recover for use if not contaminated. Sweep up and place in
Solubility in Water Insoluble. suitable container for proper disposal. Avoid dust dispersion.
Appearance & Odor Odorless, fine black powder.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved incinerator or contract with a licensed
% by Volume
(Method Used) Not applicable. N/A
waste disposal agency.
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Water fog; foam; carbon dioxide (CO ); dry chemical (ABC).
Media 2
None needed in normal laboratory handling. If dusty conditions prevail, work in
Respiration Protection
(Specify Type) ventilation hood or wear a NIOSH/MSHA-approved dust mask or respirator.
SPECIAL FIREFIGHTING
Local Exhaust Special
Recommended. No.
PROCEDURES Ventilation
If involved in fire situation, wear a NIOSH/MSHA approved self-contained Mechanical (General) Other
Recommended. No.
breathing apparatus and full protective clothing.
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
Autoignition Temperature: 900掳C (1652掳F) (Layer). Other Protective
Lab coat, apron, eye wash station, proper gloves.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry area away from oxidizing materials, sparks or
in Handling & Storing
EXPLOSION HAZARDS ignition sources. Wash thoroughly after handling.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Avoid dispersion of dust in air. Finely divided particles, dust or
fume may be a slight fire hazard. Avoid inhalation of dust. Use with adequate ventilation. Remove and
wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 4 MR
12/12/96 Michael Raszeja Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|