SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET HH 180
TWA: 1 ppm; 1.4 mg/m3 (Air). ACGIH 1992-93.
Threshold Limited Value
ALDON 1533 W.Henrietta Rd.
Material decreases in hazard as H2 O2 concentration decreases.
HH 180
Avon, New York 14414 MSDS No.
庐
CORPORATION December 10, 1996
Effective Date
(716) 226-6177
Effects of Overexposure
EYES: May cause irritation on contact. SKIN: Prolonged contact with skin
may produce irritation. INGESTION: May be harmful if swallowed.
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE
Exercise appropriate procedures to minimize potential hazards.
Product HYDROGEN PEROXIDE 3% CHEMTREC
0 Health 0
800-424-9300
Chemical
Emergency and
1 1
Hydrogen Peroxide 3%
Synonyms 0
Fire
Day 716-226-6177
First Aid Procedures EYES: Flush thoroughly with water for at least 15 minutes, lifting upper and
Formula Mixture. 1
Reactivity
NFPA lower eyelids occasionally. Get immediate medical attention. SKIN: Flush
HAZARD RATING HMIS * thoroughly with water, then wash with mild soap and water. INGESTION: If
Unit Size up to 4 Lt.
LEAST SLIGHT MODERATE HIGH EXTREME swallowed, if conscious, give one or two glasses of water to drink. Call a
0 1 2 3 4
C.A.S. No. physician. Never give anything by mouth to an unconscious person.
Mixture.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable Stability decreased by strong sunlight, heat,
Hydrogen Peroxide (Stabilized Acetanilide): (CAS No. 7722-84-1) 3% See Section V.
mixing.
Stable X
Acetanilide: (CAS No. 103-84-4) 0.05% None assigned. Incompatibility Do not add anything to this container - as violent reaction may occur. Readily
reacts with reducing agents, organic materials, dirt, rust, metals.
(Materials to Avoid)
Water: (CAS No. 7732-18-5) 97%
Hazardous
CAUTION! IRRITANT. MAY CAUSE IRRITATION TO SKIN AND EYES ON CONTACT. Decomposes to water and oxygen.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) Approx. 0掳C (32掳F) Approx. 1.00
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 100掳C (212掳F) 100% X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) 14 (water) =1)
Ether Greater than 1.
(
Steps to be taken in case
Vapor Density (Air=1) 0.7 (water)
material is released or spilled Dilute with water to 1% or less and flush to sewer with copious
Solubility in Water Complete. amounts of water.
Appearance & Odor Clear, colorless liquid; no odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dilute with water to 1% or less and flush to sewer with copious amounts
% by Volume
Non-flammable. None
(Method Used)
of water.
Extinguisher
Use water in large quantities for extinguishing supporting fire. SECTION VIII SPECIAL PROTECTION INFORMATION
Media
None needed in normal laboratory handling. If misty conditions prevail, work in ventilation
Respiration Protection
(Specify Type) hood or wear a NIOSH/MSHA-approved respirator.
SPECIAL FIREFIGHTING
Local Exhaust Special
None needed. No.
PROCEDURES Ventilation None needed. No.
Mechanical (General) Other
Use water in large amounts to fight fire in which this material is involved. In
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
fire conditions, wear a NIOSH/MSHA-approved self-contained breathing
apparatus and eye protection. Other Protective
Smock, apron, eye wash station, goggles, proper gloves.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken Store in a cool, dark place. Protect from strong sunlight, reducing agents
UNUSUAL FIRE AND in Handling & Storing and organics. Check after one year. Beware of bulging containers, which
EXPLOSION HAZARDS can burst from pressure.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Hydrogen peroxide is non-flammable, but it provides oxygen to facilitate or
initiate burning of surrounding combustibles. Avoid contact with eyes or prolonged contact with skin. Wash thoroughly
after handling. Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 4 12/10/96 Michael Raszeja MR
Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|