SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET LL 180
Threshold Limited Value
ALDON None established. (ACGIH 1992-93).
1533 W.Henrietta Rd.
LL 180
Avon, New York 14414 MSDS No.
庐
CORPORATION December 12, 1996
Effective Date
(716) 226-6177 Boiled linseed oil (e.g., treated with drier and heated to enhance the oils ability to react
Effects of Overexposure
with oxygen and form a hard film) is more dangerous and should never be taken
internally, because lead and other toxic elements (e.g., manganese, cobalt) have usually
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE be added. INHALATION: None indicated. SKIN: May cause allergic reaction. EYES:
No specific hazard known. Contact may cause irritation. Exercise appropriate
Product LINSEED OIL, BOILED
CHEMTREC procedures to minimize potential hazards.
1 Health 1
800-424-9300
Chemical
Emergency and
Flaxseed Oil 0 0 INGESTION: If swallowed, if conscious, give one or two glasses of water
Synonyms Fire 1
Day 716-226-6177 to drink, induce vomiting and call physician. Never give anything by
First Aid Procedures
Mixture (Natural Product)
Formula mouth to an unconscious person. EYES: Flush thoroughly with water for
Reactivity 1
NFPA 15 minutes, lifting lower and upper eyelids occasionally. If irritation
HAZARD RATING HMIS *
up to 4 Lt.
Unit Size develops or persists, get medical attention. SKIN: Flush with water, then
LEAST SLIGHT MODERATE HIGH EXTREME
wash with soap and water. INHALATION: Remove to fresh air. If not
0 1 2 3 4
8001-26-1
C.A.S. No. breathing, give artificial respiration. If breathing is difficult, give oxygen.
SECTION II INGREDIENTS OF MIXTURES Get medical attention.
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
Exposure to air.
Linseed Oil, Boiled 100% None established. Excessive temperatures, heat.
Stable X
Incompatibility
Strong oxidizers.
(Materials to Avoid)
WARNING! COMBUSTIBLE.
Hazardous Thermal decomposition or burning will produce carbon dioxide and/or
MAY BE HARMFUL IF SWALLOWED.
Decomposition Products carbon monoxide.
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) -19掳C (-2.0掳F) 0.931-0.936
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 316掳C+ (600掳F+) Data not available.
by Volume (%) X
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) Data not listed. Ether Greater than 1.
=1)
(
Steps to be taken in case
Vapor Density (Air=1) Data not listed.
material is released or spilled Absorb spill with an inert dry material and place in a suitable
Solubility in Water Water insoluble. container for disposal. Wash spill area with soap and water.
Appearance & Odor Yellow-brown or amber colored, light oily liquid; peculiar odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
403掳F (206掳C) cc N/A
% by Volume
(Method Used) Dispose of in an approved incinerator equipped with an afterburner and scrubber.
Extinguisher
SECTION VIII SPECIAL PROTECTION INFORMATION
Carbon dioxide (CO ); dry chemical; water spray; foam.
Media 2
None needed in normal laboratory handling at room temperature. If necessary, work in a
Respiration Protection
ventilation hood or wear a NIOSH/MSHA-approved respirator.
(Specify Type)
SPECIAL FIREFIGHTING
Yes. No.
Local Exhaust Special
PROCEDURES Water spray may be used to flush spills away from exposures and to Ventilation Not required. No.
Mechanical (General) Other
dilute spills to non-flammable mixtures. Wear a NIOSH/MSHA
approved self-contained breathing apparatus and protective clothing. Protective Gloves Eye Protection
Rubber if sensitive. Chemical safety glasses.
Other Protective
Ignition Temperature: 650掳F (343掳C). Smock, apron, eye wash station, fire extinguisher.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place away from strong oxidizing materials
in Handling & Storing
EXPLOSION HAZARDS and fire hazards. Wash thoroughly after handling.
Keep container tightly closed when not in use.
Oily clothes should be spread to dry or burned promptly after use. Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Develops heat spontaneously; slight fire risk. Fire or excessive
heat may produce hazardous decomposition products; can react
Remove and wash contaminated clothing.
vigorously with oxidizing materials.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date MR
No. 3 12/12/96 Michael Raszeja Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|