SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET LL 122
Threshold Limited Value None established for Lead Chloride. (ACGIH 1992-93). TWA for Lead:
ALDON (CAS No. 7439-92-1), inorganic dust and fumes, as Lead 0.15 mg/m3 .
1533 W.Henrietta Rd.
RTECS No. OF9450000
LL 122
Avon, New York 14414 MSDS No.
庐
CORPORATION December 12, 1996
Effective Date
(716) 226-6177
Effects of Overexposure INHALATION AND INGESTION: Acute effects are weakness, fatigue, sleep
disturbance, headache, aching bones and muscles, abdominal pains,
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE constipation and decreased appetite. Chronic effects include anemia, pallor,
blue 鈥渓ead line鈥? on the gums, severe headache, convulsions, coma, delirium,
Product LEAD CHLORIDE
CHEMTREC kidney injury and possible death.
3
Health
800-424-9300
Chemical
Emergency and
Lead Chloride INHALATION: Remove to fresh air. If not breathing, give artificial
Synonyms 0
Fire
Day 716-226-6177 respiration. If breathing is difficult, give oxygen. Get medical attention.
First Aid Procedures
PbCl
Formula INGESTION: If swallowed, if conscious, give one or two glasses of water to
0
Reactivity
2
NFPA drink, induce vomiting. Repeat until vomit fluid is clear. Call physician
HAZARD RATING HMIS *
Unit Size up to 2.5 Kg. immediately. Never give anything by mouth to an unconscious person.
LEAST SLIGHT MODERATE HIGH EXTREME
EYES: Flush thoroughly with water for at least 15 minutes, lifting upper and
0 1 2 3 4
C.A.S. No. 7758-95-4
lower eyelids occasionally. Get medical attention. SKIN: Flush thoroughly
SECTION II INGREDIENTS OF MIXTURES with water, then wash with mild soap and water.
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable Excessive temperature and heat.
Lead Chloride 100% See Section V.
X
Stable
Incompatibility Acids, soluble sulfates, citrates, tartrates, chlorides, carbonates, alkalies, tannin,
phosphates, resorcinol, salicylic acid, phenol, chloral hydrate, sulfites, strong oxidizers.
(Materials to Avoid)
DANGER! POISON. MAY BE FATAL IF
Hazardous When heated to decomposition, emits toxic fumes of lead, Hydrogen
SWALLOWED, INHALED OR ABSORBED THROUGH SKIN.
Chloride gas.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
501掳C (933掳F) Specific Gravity (H2O = 1) 5.85 at 20掳C
Melting Point (掳F)
May Occur Will Not Occur Not applicable.
Percent Volatile
950掳C (1742掳F) N/A
Boiling Point (掳F) X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
1 mm at 547掳C N/A
Vapor Pressure (mm Hg) =1)
(
Steps to be taken in case
Greater than 1. Wear suitable protective clothing; avoid making dust, sweep
Vapor Density (Air=1)
material is released or spilled material up and place in a suitable container. Dispose of in an
1 gram per 100 mL. water at 20掳C.
Solubility in Water approved chemical landfill. Wash spill area well with soap and
water.
White crystalline powder; no odor.
Appearance & Odor
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point Dispose of in an approved chemical landfill or contract with a licensed
Non-flammable. N/A
% by Volume
(Method Used)
waste disposal service.
Extinguisher Use any media suitable for extinguishing supporting fire.
SECTION VIII SPECIAL PROTECTION INFORMATION
Media
None should be needed in normal laboratory handling. If dusty conditions prevail,
Respiration Protection
work in a fume hood or wear a NIOSHMSHA-approved dust mask.
(Specify Type)
SPECIAL FIREFIGHTING
Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation
In fire conditions, wear a NIOSH/MSHA-approved self-contained
Recommended. No.
Mechanical (General) Other
breathing apparatus and full protective clothing to prevent contact
Protective Gloves Eye Protection
with skin and eyes. Rubber. Chemical safety glasses.
Other Protective
Goggles, lab coat, ventilation hood, proper gloves.
Equipment
SECTION IX SPECIAL PRECAUTIONS
(1993 EMERGENCY RESPONSE GUIDEBOOK, DOT P 5800.6, GUIDE PAGE NO. 53)
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place away from strong oxidizing agents.
in Handling & Storing
Wash thoroughly after handling.
EXPLOSION HAZARDS Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
When heated emits toxic fumes of lead.
Avoid contact with eyes, skin and clothing. Do not breathe dust
or fumes. Use with adequate ventilation. Remove and wash
contaminated clothing promptly.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 7 Michael Raszeja
12/12/96 MR
Coordinator
D.O.T. Lead compounds, soluble, n.o.s. , (Lead chloride), 6.1, UN 2291, PG III The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|