SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET LL 205
Threshold Limited Value
ALDON None established (ACGIH 1992-93). RTECS No. OJ5800000
1533 W.Henrietta Rd. Toxicity data: Orl-rat LD50: 525 mg/kg.
LL 205
Avon, New York 14414 MSDS No.
庐
CORPORATION April 4, 1996
Effective Date
(716) 226-6177
Effects of Overexposure INGESTION: Large doses of lithium carbonate have caused dizziness and
prostration. Can cause kidney damage if sodium intake is limited. EYES:
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE Strong irritant. SKIN: Strong irritant. INHALATION: Airborne dust may
irritate nose and throat.
Product LITHIUM CARBONATE
CHEMTREC 2
Health
800-424-9300
Chemical
Emergency and
Carbonic Acid, Dilithium Salt
Synonyms 0 INGESTION: If swallowed, do NOT induce vomiting. If conscious, give one
Fire
Day 716-226-6177
First Aid Procedures or two glasses of water to drink. Call physician immediately. Never give
Formula Li2 CO3 0
Reactivity
NFPA anything by mouth to an unconscious person. EYES: Flush thoroughly with
HAZARD RATING HMIS * water for at least 15 minutes, lifting upper and lower eyelids occasionally.
Unit Size up to 2.5 Kg.
LEAST SLIGHT MODERATE HIGH EXTREME Get immediate medical attention. SKIN: Flush thoroughly with water, then
0 1 2 3 4
C.A.S. No. wash with mild soap and water. INHALATION: Remove to fresh air. If
554-13-2
illness develops, get medical attention.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
Lithium Carbonate 99.0% None established. Excessive temperature and heat.
Stable X
Incompatibility
Strong acids.
(Materials to Avoid)
WARNING! STRONG IRRITANT. MAY BE
Hazardous Thermal decomposition or burning may produce carbon dioxide and/or
HARMFUL IF INHALED OR SWALLOWED.
Decomposition Products carbon monoxide.
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) 720掳C (1330掳F) 2.111 @ 17.5掳C
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 1310掳C (2390掳F) dec. Non-volatile (NA). X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) Negligible as solid. Non-volatile (NA).
=1)
(
Steps to be taken in case
Vapor Density (Air=1) 2.56
Small spills: Dissolve in water and flush to sewer with copious
material is released or spilled
amounts of water. Large spills: Ventilate area. Sweep up and
Solubility in Water 1.3% by weight @ 25掳C (77掳F).
place in a suitable container for proper disposal.
Appearance & Odor White powder; no odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
% by Volume
(Method Used) Non-flammable (NA). NA -------- -------- Uncontaminated material may be disposed of in a sanitary landfill.
Extinguisher
Use any media suitable for extinguishing supporting fire. SECTION VIII SPECIAL PROTECTION INFORMATION
Media
None should be needed in normal laboratory handling. If dusty conditions prevail, work
Respiration Protection
(Specify Type) in a fume hood or wear a NIOSH/MSHA approved dust mask or respirator.
SPECIAL FIREFIGHTING
Not needed. No.
Local Exhaust Special
PROCEDURES Ventilation If dusty. No.
Mechanical (General) Other
In fire conditions, wear a NIOSH/MSHA-approved self-contained
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
breathing apparatus.
Other Protective
Goggles, eye wash station, ventilation hood, proper gloves, lab coat.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place away from acids or acid fumes.
in Handling & Storing
Wash thoroughly after handling.
EXPLOSION HAZARDS Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Fire or excessive heat may produce hazardous decomposition
products; can react with acids. Use with adequate ventilation. Avoid contact with eyes, skin
and clothing. Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 3 4/4/96 Michael Raszeja MR
Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|