SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET LL 140
Threshold Limited Value None established for Lead Oxide, Yellow. (ACGIH 1992-93). TWA for
ALDON Lead [CAS No. 7439-92-1], inorganic dust and fumes, as Pb 0.15 mg/m3.
1533 W.Henrietta Rd.
LL 140
Avon, New York 14414 MSDS No.
庐
CORPORATION February 28, 1996
Effective Date
(716) 226-6177
Effects of Overexposure INHALATION AND INGESTION: Acute effects are weakness, fatigue,
sleep disturbance, headache, aching bones and muscles, abdominal pains,
constipation and decreased appetite. Chronic effects include anemia,
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE
pallor, blue 鈥渓ead line鈥? on the gums, severe headache, convulsions, coma,
Product LEAD OXIDE, YELLOW delirium, kidney injury and possible death.
CHEMTREC 2
Health
800-424-9300
Chemical
Emergency and INHALATION: Remove to fresh air. If not breathing, give artificial
Lead Monoxide
Synonyms 0
Fire
Day 716-226-6177 respiration. If breathing is difficult, give oxygen. Get medical attention.
First Aid Procedures
Formula PbO INGESTION: If swallowed, if conscious, give one or two glasses of water to
1
Reactivity
NFPA drink, induce vomiting. Repeat until vomit fluid is clear. Call physician
HAZARD RATING HMIS *
Unit Size up to 2.5 Kg. immediately. Never give anything by mouth to an unconscious person.
LEAST SLIGHT MODERATE HIGH EXTREME
EYES: Flush thoroughly with water for at least 15 minutes, lifting lower and
0 1 2 3 4
C.A.S. No. 1317-36-8 upper eyelids occasionally. Get medical attention. SKIN: Flush thoroughly
SECTION II INGREDIENTS OF MIXTURES with water, then wash with mild soap and water.
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
Lead Oxide, Yellow 99.9% See Section V. Excessive temperature and heat.
Stable X
Incompatibility
None known to us.
(Materials to Avoid)
WARNING! MAY BE HARMFUL
Hazardous
IF SWALLOWED OR INHALED. When heated emits toxic fumes of lead.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
888掳C (1630掳F) 9.53 at 20掳C
Melting Point (掳F)
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) Decomposes to Pb O Non-volatile (NA). X
by Volume (%)
34
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Negligible as solid. Non-volatile (NA).
Vapor Pressure (mm Hg) =1)
(
Steps to be taken in case
7.72
Vapor Density (Air=1)
Wear suitable protective clothing; avoid making dust, sweep material
material is released or spilled
up and place in a suitable container. Dispose of in an approved
Solubility in Water Insoluble.
chemical landfill. Wash spill area well with soap and water.
Appearance & Odor Yellow powder; no odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
Dispose of in an approved chemical landfill or contract with a licensed waste
% by Volume
(Method Used) Non-flammable (NA). NA -------- --------
disposal service.
Extinguisher
Use any media suitable for extinguishing supporting fire. SECTION VIII SPECIAL PROTECTION INFORMATION
Media
None should be needed in normal laboratory handling. If dusty conditions prevail, work
Respiration Protection
in a fume hood or wear a NIOSH/MSHA-approved dust mask.
(Specify Type)
SPECIAL FIREFIGHTING
Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation Recommended. No.
Mechanical (General) Other
In fire conditions, wear a NIOSH/MSHA-approved self-contained
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
breathing apparatus.
Other Protective
Smock, apron, eye wash station, goggles, ventilation hood, proper gloves.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place away from strong oxidizing agents.
in Handling & Storing
EXPLOSION HAZARDS Wash thoroughly after handling.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
Highly toxic as dust. When heated emits toxic fumes of
Do not breathe dust or fumes. Use with adequate ventilation.
lead.
Remove and wash contaminated clothing promptly.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 3 2/28/96 Michael Raszeja MR
Coordinator
D.O.T. NON-REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|