SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET IX 235
Threshold Limited Value TWA: 400 ppm; 983 mg/m3. STEL: 500 ppm, 1230 mg/m3 (ACGIH 1992-93).
ALDON 1533 W.Henrietta Rd.
Human, oral LDLo 2371 mg/kg. Rabbit, skin LD50 16 mg/kg.
IX 235
Avon, New York 14414 MSDS No.
庐
CORPORATION September 13, 1996
Effective Date
(716) 226-6177
Effects of Overexposure INHALATION: Exposure to high concentrations (>400 ppm) may cause eye,
nose, and throat irritation and excessively high concentrations may cause
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE narcosis (drowsiness, sleepiness). EYES: Liquid may cause irritation.
SKIN: Prolonged or repeated skin contact may cause irritation and drying,
Product ISOPROPYL ALCOHOL
CHEMTREC cracking and defatting of the skin. INGESTION: 100 mL. can be fatal.
3 1
Health
800-424-9300
Chemical
Emergency and
Isopropanol; 2-Propanol 1 0 INHALATION: Remove to fresh air. If breathing is difficult, give oxygen. If
Synonyms 3
Fire
Day 716-226-6177 breathing has stopped, give artificial respiration. Get emergency medical
First Aid Procedures
(CH ) CHOH
Formula attention. SKIN: Flush thoroughly with water, then wash with mild soap and
2
Reactivity
32
NFPA water. EYES: Flush thoroughly with water for at least 15 minutes, lifting
HAZARD RATING HMIS *
Unit Size up to 20 Lt. lower and upper eyelids occasionally. Get immediate medical attention.
LEAST SLIGHT MODERATE HIGH EXTREME
INGESTION: If swallowed, if conscious, give one or two glasses of water to
0 1 2 3 4
C.A.S. No. 67-63-0 drink. Call physician immediately. Never give anything by mouth to an
SECTION II INGREDIENTS OF MIXTURES unconscious person.
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable
Isopropyl Alcohol >99% See Section V. Excessive temperatures, heat, spark or flame.
Stable X
Incompatibility Strong oxidizing materials can react vigorously with this alcohol. Aluminum, metal,
nitroform, oleum.
(Materials to Avoid)
WARNING! FLAMMABLE! CAUSES EYE
Hazardous Thermal decomposition or burning will produce carbon dioxide and/or
IRRITATION. HARMFUL IF SWALLOWED.
carbon monoxide.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) -90掳C (-130掳F) 0.786 @ 20/20掳C
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 82掳C (180掳F) 100% X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) 33 mm @ 20掳C 1.5
( n-Butyl Acetate =1)
Steps to be taken in case
Vapor Density (Air=1) 2.1 Remove all ignition sources. Provide adequate ventilation. This material
material is released or spilled is handled and disposed of as a flammable liquid. Absorb small spills on
Solubility in Water Complete. paper; evaporate isopropyl alcohol in an exhaust hood; burn paper after
evaporation. Prevent flow to sewers and public water ways.
Appearance & Odor Clear, colorless liquid; mild alcohol odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
% by Volume
(Method Used) 11.7掳C (53掳F) TCC 2.5 @ 26掳C 12.1% @ 66掳C Dispose of in accordance with federal, state and local regulations.
Extinguisher 鈥淎lcohol foam鈥?; carbon dioxide (CO ); dry chemical (ABC); water spray.
SECTION VIII SPECIAL PROTECTION INFORMATION
2
Media
None needed in normal laboratory handling. If misty conditions prevail,
Respiration Protection
work in ventilation hood or wear a NIOSH/MSHA-approved respirator.
(Specify Type)
SPECIAL FIREFIGHTING
Wear a NIOSH/MSHA-approved self-contained breathing apparatus Recommended. No.
Local Exhaust Special
PROCEDURES Ventilation
and full protective equipment. Recommended. Adequate to maintain below exposure limit.
Mechanical (General) Other
Protective Gloves Eye Protection
Rubber. Chemical safety glasses.
Autoignition Temperature: 399掳C (750掳F) (ASTM-E659-78).
Cool Flame: 360掳C (680掳F) (ASTM-E659-78). Other Protective
Goggles, lab coat, eye wash station, proper gloves, ventilation hood, fire extinguisher.
Equipment
SECTION IX SPECIAL PRECAUTIONS
(1993 EMERGENCY RESPONSE GUIDEBOOK, DOT P 5800.6, GUIDE PAGE NO. 26)
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place away from strong oxidizing materials and fire
in Handling & Storing
hazards. Wash thoroughly after handling.
EXPLOSION HAZARDS Vapors are heavier than air and may travel along the ground Keep container tightly closed when not in use.
or may be moved by ventilation and ignited by pilot lights,
Read label on container before using. Do not wear contact lenses when working with chemicals.
other flames, sparks, heaters, smoking, electric motors, or Other Precautions Avoid contact with eyes and skin. Avoid prolonged or repeated breathing
ignition sources at locations distant from material handling
of vapors. Use with adequate ventilation. Keep away from heat, sparks,
point. CAUTION! Flame may not be visible in daylight. Fire
and flame. Keep container tightly closed when not in use. Remove and
or excessive heat may produce hazardous decomposition wash contaminated clothing.
products; can react vigorously with oxidizing materials.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date
No. 7 9/13/96 Michael Raszeja MR
Coordinator
D.O.T. Isopropyl alcohol, 3, UN 1219, PG II The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|