SECTION V HEALTH HAZARD DATA
MATERIAL SAFETY DATA SHEET IX 210
Threshold Limited Value
ALDON None established. (ACGIH 1992-93).
1533 W.Henrietta Rd.
IX 210
Avon, New York 14414 MSDS No.
庐
CORPORATION December 10, 1996
Effective Date
(716) 226-6177
Effects of Overexposure
Iron dust is a skin, eye and mucous membrane irritant, can cause
SECTION I NAME 24 HOUR EMERGENCY ASSISTANCE irritation and inflammation of the eyes and lungs. Exercise appropriate
procedures to minimize potential hazards.
Product IRON METAL FILINGS CHEMTREC Health 1
800-424-9300
Chemical
Emergency and
Iron Metal
Synonyms 3
Fire
Day 716-226-6177 EYES: Flush thoroughly with water for at least 15 minutes, lifting lower
First Aid Procedures
Fe
Formula and upper eyelids occasionally. If irritation develops or persists, get
1
Reactivity
NFPA medical attention. SKIN: Flush with water, then wash with soap and
HAZARD RATING HMIS *
up to 2.5 Kg.
Unit Size water. INHALATION AS DUST: Remove to fresh air. If not breathing,
LEAST SLIGHT MODERATE HIGH EXTREME
give artificial respiration. If breathing is difficult, give oxygen. If
0 1 2 3 4
C.A.S. No. 7439-89-6
symptoms of illness develop, get medical attention.
SECTION II INGREDIENTS OF MIXTURES
SECTION VI REACTIVITY DATA
Principal Component(s) % TLV Units
Conditions to Avoid
Stability Unstable Oxidizes readily in moist air.
Iron Metal 100% None established.
Stable X
Incompatibility
Strong oxidizers, acids. Reacts violently with Cl2 , ClF2 , F2 , H2O2, NO2 , P, H2SO4 .
(Materials to Avoid)
CAUTION! IRON DUST DISPERSED IN AIR MAY
Hazardous
CONSTITUTE A FIRE AND/OR EXPLOSION HAZARD. None.
Decomposition Products
SECTION III PHYSICAL DATA
Conditions to Avoid
Hazardous Polymerization
Specific Gravity (H2O = 1)
Melting Point (掳F) 1535掳C (2795掳F) 7.86
May Occur Will Not Occur Not applicable.
Percent Volatile
Boiling Point (掳F) 3000掳C (5432掳F) Negligible. X
by Volume (%)
Evaporation Rate
SECTION VII SPILL OR LEAK PROCEDURES
Vapor Pressure (mm Hg) 1 mm at 1787掳C Not applicable.
=1)
(
Steps to be taken in case
Vapor Density (Air=1) 1.93
material is released or spilled
Sweep up for recycling or place in a suitable container for disposal.
Solubility in Water Insoluble.
Appearance & Odor Gray-black granulated or powder; no odor.
Discharge, treatment, or disposal may be subject to Federal, State or Local laws.
Waste Disposal Method
SECTION IV FIRE AND EXPLOSION HAZARD DATA These disposal guidelines are intended for the disposal of catalog-size quantities only.
Lower
Flammable Limits in Air Upper
Flash Point
% by Volume
Non-flammable. N/A
(Method Used) Uncontaminated material may be disposed of in a sanitary landfill.
Extinguisher
Use any media suitable for extinguishing supporting fire. SECTION VIII SPECIAL PROTECTION INFORMATION
Media
None should be needed in normal laboratory handling. If dusty conditions prevail,
Respiration Protection
wear a NIOSH/MSHA-approved dust mask.
(Specify Type)
SPECIAL FIREFIGHTING
None needed. No.
Local Exhaust Special
PROCEDURES Ventilation If dusty. No.
Mechanical (General) Other
Protective Gloves Eye Protection
None needed. Chemical safety glasses.
Wear a NIOSH/MSHA-approved self-contained breathing apparatus.
Other Protective
Goggles, eye wash station, lab coat.
Equipment
SECTION IX SPECIAL PRECAUTIONS
Precautions to be Taken
UNUSUAL FIRE AND Store in a cool, dry place, away from acids and oxidizers.
in Handling & Storing
EXPLOSION HAZARDS Wash thoroughly after handling.
Keep container tightly closed when not in use.
Read label on container before using. Do not wear contact lenses when working with chemicals.
Other Precautions
A fire hazard in the form of a fine dust or by chemical reaction
with strong oxidizers.
Remove and wash contaminated clothing.
For laboratory use only. Not for drug, food or household use. Keep out of reach of children.
Chemical Safety
Approved
Revision Date Michael Raszeja MR
No. 6 12/10/96 Coordinator
D.O.T. NON REGULATED. The information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information
gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these
Approved by U.S. Department of Labor "essentially similar" to form OSHA-20 materials and the safety and health of employees. * Hazardous Materials Industrial Standards. Printed on recycled paper.
|