1 CHEMICAL PRODUCT & COMPANY IDENTIFICATION
Trade Name MATT AGENT HK-1 CASHEW
325
MSDS Number
- -0
CAS Number
TRANS TECH AMERICA, INC.
Supplier
475 N. GARY AVENUE
CAROL STREAM, IL 60188 USA
Telephone Numbers - 24 Hour Emergency Assistance
Emergency (352)323-3500
Telephone Numbers - General Assistance
Information (630)752-4000
2 COMPOSITION / INFORMATION ON INGREDIENTS
Concentration
Ingredient Name CAS Number Exposure Limits / Health Hazards
TOLUENE 108-88-3 85 - 90 % ACGIH TLV: 385mg/m3
3 HAZARDS IDENTIFICATION
Signs & Symptoms of Short-Term (Acute) Exposure
Dizzy feeling, irritation of mucous membranes.
Effects of Long-Term (Chronic) Exposure
Loss of appetite, nose bleeds.
4 FIRST AID MEASURES
Skin
Wash affected areas with soap and water. Consult a physician if irritation persists.
Eye
Flush immediately with large amounts of water for at least 15 minutes. Take to a physician for medical treatment.
Inhalation
Remove to fresh air. Restore breathing. Treat symptomatically. Consult a physician.
Ingestion
Do not induce vomiting. Consult a physician or poison control center immediately.
Medical Conditions Aggravated by Exposure
ND
5 FIRE FIGHTING MEASURES
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
325 MATT AGENT HK-1 CASHEW
Material Id Trade Name 1/ 3
Extinguishing Media
Powder, foam, co gas.
Basic Fire Fighting Procedures
Wear self-contained breathing apparatus. Water may be unsuitable except as a cooling medium.
Unusual Fire & Explosion Hazards
Keep away from heat, spark and open flames.
4
Flash Point
1.2
Flammability Limits in Air, Lower, % by Volume
7
Flammability Limits in Air, Upper, % by Volume
6 ACCIDENTAL RELEASE MEASURES
Spill or Leak Procedure
Eliminate all sources vapor ignition. Ventilate areas.
7 HANDLING & STORAGE
Handling
Avoid exposure to vapors.
Storage
Keep away from heat, sparks and open flames.
Ventilation
Local exhaust: to maintain vapor concentration below tlv. Mechanical (general): handle with ventilation. Care should be
taken for sufficient ventilation of the work place.
8 EXPOSURE CONTROLS / PERSONAL PROTECTION
Eye Protection: Personal Protection Equipments (PPE)
Wear protective glasses.
Skin Protection: Personal Protection Equipments (PPE)
Required for repeated or prolonged contact protective gloves required to protect against splash.
9 PHYSICAL & CHEMICAL PROPERTIES
Odor and Appearance
White liquid. Solvent odor.
110 C
Boiling Point
0.923
Specific Gravity
NI
Melting Point
30 C
Vapor Pressure
NI
Evaporation Rate
NI
Vapor Density
Insoluble
Solubility In Water
10 STABILITY & REACTIVITY
Stability/Incompatibility
Stable Ni
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
325 MATT AGENT HK-1 CASHEW
Material Id Trade Name 2/ 3
Hazardous Reactions/Decomposition Products
Ni
Hazardous Polymerization
Will not occur.
11 TOXICOLOGICAL INFORMATION
Routes of Exposure
Inhalation, eyes, skin, ingestion.
12 ECOLOGICAL INFORMATION
13 DISPOSAL CONSIDERATIONS
Waste Disposal
Dispose according to federal, state and local regulations.
14 TRANSPORT INFORMATION
15 REGULATORY INFORMATION
NFPA Ratings
Health Flammability Reactivity Special Hazards
HMIS Ratings
Health 1 Flammability 3 Reactivity 1 Personal Prot. Equip. B
16 OTHER INFORMATION
Disclaimer
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of
Trans Tech America, Inc. The data on this sheet applies only to the specific material designated herein. Trans Tech
America, Inc. assumes no legal responsibility for use of reliance upon this data.
5/14/1998 5/13/1998
Replaces Sheet Dated
Completed On
TRANS TECH AMERICA, INC.
Completed By
Printed On 31-Mar-03
ND = No Data NA = Not Applicable NI = Not Indicated
325 MATT AGENT HK-1 CASHEW
Material Id Trade Name 3/ 3
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP