NuGenTec
NuBrite 44S Page 1 of 8
PRD Number: SDA121 ___ May 30, 2007
MATERIAL SAFETY DATA SHEET
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Identification
----------------------
Product Name: NuBrite 44S
Product Number: SDA121
CAS Number: Blend
Company Identification
----------------------
NuGeneration Technologies, LLC www.nugentec.com
100 Professional Center Drive, Ste 101
Rohnert Park, CA 94928 USA
(707) 820-4080 (For product information)
1-202-483-7616 (For emergencies)
1-800-424-9300 or 1-202-483-7616 (CHEMTREC)
SPECIAL NOTES:
Contains HF Acid, use with caution.
2. COMPOSITION/INFORMATION ON INGREDIENTS
COMPONENT LISTING:
Chemical Name Amount CAS Number
------------- -------- ----------
NITRIC ACID < 40.0 % 7697-37-2
HYDROFLUORIC ACID < 10.0 % 7664-39-3
(See Section 8 for exposure guidelines)
(See Section 15 for regulatory information)
COMPOSITION COMMENT:
Contains Nitric and Hydrofluoric acid use with caution.
HAZARDS DISCLOSURE
This product contains hazardous materials as defined by the OSHA Hazard
Communication Standard 29 CFR 1910.1200.
As defined under Sara 311 and 312, this product contains materials that
are acute, reactive hazards.
MISCELLANEOUS:
Contains Phosphoric Acid & Hydroflouric acid.
3. HAZARDS IDENTIFICATION
NuGenTec
NuBrite 44S Page 2 of 8
PRD Number: SDA121 ___ May 30, 2007
***************** EMERGENCY OVERVIEW *****************
* *
* DANGER *
* *
* Harmful if absorbed through skin or swallowed. May *
* cause skin or eye irritation, rash, or burns. *
* *
**********************************************************
HMIS Rating - Health: 3
Flammability: 0
Reactivity: 1
Personal Protection Index: C
NFPA Rating - Health: 3
Flammability: 0
Reactivity: 1
Special Hazard: Corrosive
NFPA/HMIS Definitions: (0-Least, 1-Slight, 2-Moderate, 3-High,
4-Extreme). These values are obtained using the guidelines or published
evaluations prepared by the National Fire Protection Association (NFPA) or
the National Paint and Coating Association (for HMIS ratings).
POTENTIAL HEALTH EFFECTS
EYE:
Contact causes severe eye irritation and or burns.
SKIN:
Contact may cause severe skin irritation and possible burns.
INHALATION:
Irritating to the nose, throat, and respiratory tract and at higher
concentrations may cause burns of nose, throat, or respiratory tract.
INGESTION:
Ingestion is not considered a potential route of exposure. May cause
diarrhea, nausea, abdominal cramps. If ingested seek prompt medical
attention. Corrosive and may cause severe and permanent damage to mouth,
throat, and stomach.
SIGNS AND SYMPTOMS OF EXPOSURE:
If exposed areas are flushed promptly and thoroughly with water, there
should be little or no harm. This product is completely soluble in water.
CHRONIC EFFECTS:
Prolonged and/or repeated contact may produce mild to moderate skin
irritation or inflammation.
NuGenTec
NuBrite 44S Page 3 of 8
PRD Number: SDA121 ___ May 30, 2007
CARCINOGENICITY INFORMATION:
No known cancer hazards.
MISCELLANEOUS:
Slippery, can cause falls if walked on.
4. FIRST AID MEASURES
EYE CONTACT FIRST AID:
Flush eye with water for 15 minutes. Contact a physician.
SKIN CONTACT FIRST AID:
Immediately flush skin with plenty of water. Remove contaminated clothing
and shoes. Get medical attention.
INHALATION FIRST AID:
Although this product is not known to cause respiratory problems, if
breathing is difficult, remove to fresh air and provide oxygen. Get
immediate medical attention.
INGESTION FIRST AID:
Get medical attention immediately. Do not induce vomiting. Give milk or
water.
STATEMENT OF PRACTICAL TREATMENT:
Always have plenty of water available for first aid.
NOTES TO PHYSICIAN:
Treat patient symptomatically.
5. FIRE FIGHTING MEASURES
FLAMMABLE PROPERTIES
COC Flash Point: None
TCC Flash Point: None
Autoignition Temperature: None
FLAMMABLE LIMITS IN AIR
LEL: None
UEL: None
EXTINGUISHING MEDIA:
Will not burn.
FIRE FIGHTING INSTRUCTIONS:
Contaminated extinguishing water must be disposed of in accordance with
applicable regulations.
NuGenTec
NuBrite 44S Page 4 of 8
PRD Number: SDA121 ___ May 30, 2007
6. ACCIDENTAL RELEASE MEASURES
SAFEGUARDS (PERSONNEL):
Protect skin and eyes from exposure.
INITIAL CONTAINMENT:
Contain spilled material.
LARGE SPILLS PROCEDURE:
Forms smooth, slippery surfaces on floors, posing an accident risk.
Dilute with water and wash to waste water treatment system. Large spills
may be neutralized with dilute alkaline solutions of soda ash, or lime.
Treat or dispose of waste material in accordance with all local,
state/provincial, and national requirements.
SMALL SPILLS PROCEDURE:
Floor may become slippery. Dispose into waste water treatment facility.
7. HANDLING AND STORAGE
RECOMMENDED STORAGE TEMPERATURE
Minimum: 4.4 C (39.9 F)
Maximum: 48.9 C (120.0 F)
SHELF LIFE: (in original, sealed containers)
5 years @ 4.4 C
2 years @ 48.9 C
HANDLING (PERSONNEL):
Avoid contact with eyes, skin, and clothing.
HANDLING (PHYSICAL ASPECTS):
Keep out of reach of children. Keep from freezing. Keep container closed
to avoid contamination. Store in a cool dry area.
STORAGE PRECAUTIONS:
Do not stack pails more than three pallets high. Do not stack drums more
than two pallets high. Keep from freezing. Keep container closed when
not in use.
MISCELLANEOUS:
Do not stack over two pallets high.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
ENGINEERING CONTROLS:
Good general ventilation should be sufficient to control airborne levels.
NuGenTec
NuBrite 44S Page 5 of 8
PRD Number: SDA121 ___ May 30, 2007
EYE / FACE PROTECTION REQUIREMENTS:
When splashing of the material may occur, chemical goggles and a face
shield are recommended.
SKIN PROTECTION REQUIREMENTS:
Wear protective gloves to minimize skin contamination.
RESPIRATORY PROTECTION REQUIREMENTS:
Under normal use conditions, with adequate ventilation, no special
handling equipment is required.
MISCELLANEOUS:
Where an apron and protective clothing.
EXPOSURE GUIDELINES:
No Information Available.
9. PHYSICAL AND CHEMICAL PROPERTIES
FORM .....................: Liquid
COLOR ....................: Colorless
ODOR .....................: Mild
BOILING POINT ............: >212 F
SOLUBILITY IN WATER ......: Complete
SPECIFIC GRAVITY .........: 1.2 (Water = 1)
BULK DENSITY .............: 10.0
MELTING/FREEZING POINT ...: <32 F
PH .......................: <1.0
10. STABILITY AND REACTIVITY
STABILITY:
Stable.
POLYMERIZATION:
Hazardous polymerization will not occur.
INCOMPATIBILITY WITH OTHER MATERIALS:
None known.
DECOMPOSITION:
Decomposition will not occur if handled and stored properly.
CONDITIONS TO AVOID:
Avoid contact with this material and Ferrous metal surfaces. This
material is safe under normal storage and handling conditions.
NuGenTec
NuBrite 44S Page 6 of 8
PRD Number: SDA121 ___ May 30, 2007
11. TOXICOLOGICAL INFORMATION
EYE EFFECTS:
Can cause severe eye irritation.
SKIN EFFECTS:
Contact may cause skin irritation, rash or burns.
ACUTE ORAL EFFECTS:
May cause diarrhea and or vomiting along with tissue burns.
ACUTE INHALATION EFFECTS:
At elevated temperatures, >110 F, irration may develop without adaquate
ventilation. Caution should be taken to prevent aerozolization or
misting of this product. May be irritating if inhaled.
REPRODUCTION AND BIRTH EFFECTS:
There are no known or reported effects on reproductive function or fetal
development.
12. ECOLOGICAL INFORMATION
No information available.
13. DISPOSAL CONSIDERATIONS
WASTE DISPOSAL:
Treat or dispose of waste material in accordance with all local,
state/provincial, and national requirements. For additional waste
disposal information contact your local NuGenTec representative at (888)
99-NuGen. Uncleaned empty containers should be disposed of in the same
manner as the contents.
CONTAMINATED MATERIALS:
Wash contaminated clothing before reuse.
CONTAINER DISPOSAL:
Containers should be triple rinsed prior to disposal.
14. TRANSPORTATION INFORMATION
PRODUCT LABEL .............: NuBrite 44S
D.O.T. SHIPPING NAME ......: Corrosive Liquid
TECHNICAL SHIPPING NAME ...: Corrosive Liquid, n.o.s. (Nitric &
Hydroflouric acid mixture)
D.O.T. HAZARD CLASS .......: Corrosive
UN NUMBER .................: 1760 Corrosive Liquid, NOS
NuGenTec
NuBrite 44S Page 7 of 8
PRD Number: SDA121 ___ May 30, 2007
PRODUCT RQ (LBS) ..........: 1,000
D.O.T. LABEL ..............: Corrosive Liquid, Packing Group III
D.O.T. PLACARD ............: #8
BULK CLASS ................: N/A
PACKAGE CLASS .............: 70
15. REGULATORY INFORMATION
EEC Symbols and Indications of Danger:
Corrosive (C)
R-Phrases:
R34 - Causes burns.
S-Phrases:
S25 - Avoid contact with eyes.
S26 - In case of contact with eyes, rinse immediately with plenty of
water and seek medical advice.
WHMIS Hazard Symbols:
Class E - Corrosive Material
Canadian Disclosure List
NITRIC ACID (7697-37-2)
HYDROFLUORIC ACID (7664-39-3)
SARA Title III - Section 313
NITRIC ACID (7697-37-2)
HYDROFLUORIC ACID (7664-39-3)
CERCLA Hazardous Substances
NITRIC ACID (7697-37-2) -- RQ 1000 lb
HYDROFLUORIC ACID (7664-39-3) -- RQ 100 lb
RCRA Hazardous Substances
HYDROFLUORIC ACID (7664-39-3) -- RCRA Code: U134
Clean Air Act - Section 112
HYDROFLUORIC ACID (7664-39-3)
Title V
NITRIC ACID (7697-37-2)
HYDROFLUORIC ACID (7664-39-3)
SC Toxic Air Pollutants List
NITRIC ACID (7697-37-2)
MISCELLANEOUS INFORMATION:
This material or all of its components are listed on the Inventory of
NuGenTec
NuBrite 44S Page 8 of 8
PRD Number: SDA121 ___ May 30, 2007
Existing Chemical Substances under the Toxic Substance Control Act
(TSCA). This material or all of its components are listed on the
Canadian Domestic Substances List (DSL). This material or all of its
components are listed (or considered as having been notified) on the
Euproean Inventory of Existing Chemical Substances (EINECS).
16. OTHER INFORMATION
PREPARED BY .......: Donato Polignone
APPROVAL DATE .....: May 30, 2007
SUPERCEDES DATE ...: May 7 2002
PRD NUMBER ........: SDA121 (Official Copy)
ADDITIONAL INFORMATION:
The data in this Material Safety Data Sheet relates only to the specific
material designated herein. It does not relate to use in combination
with any other material or in any process.
**********************************************************************
This information is furnished without warranty, expressed or implied,
except that it is accurate to the best knowledge of NuGeneration
Technologies, LLC. The data on this sheet are related only to the
specific material designated herein. NuGeneration Technologies, LLC
assumes no legal responsibility for use or reliance upon these data.
**********************************************************************
END OF MSDS
**********************************************************************
|