NuGenTec
NuBrite CK Page 1 of 4
PRD Number: SDB133 ___ April 18, 2003
MATERIAL SAFETY DATA SHEET
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Identification Product Name: NuBrite
Product Number: SDB133 CAS Number: Blend
Company Identification
NuGeneration Technologies, LLC
7200 C.E. Dixon Street, Stockton, CA 95206 USA
(209) 234-5930 (For product information)
1-800-424-9300 or 1-202-483-7616 (CHEMTREC: For emergencies)
2. COMPOSITION/INFORMATION ON INGREDIENTS
100.0% NuBrite CONTAINING: HAZARDOUS AND/OR REGULATED COMPONENTS
Chemical Name Amount CAS Number
------------- -------- ----------
PHOSPHORIC ACID < 30.0 % 7664-38-2
DIPROPYLENE GLYCOL MONOMETHYL ETHER < 15.0 % 34590-94-8
NON-IONIC SURFACTANT < 5.0 % 68603-25-8
Water Balance 7732-18-5
(See Section 8 for exposure guidelines) (See Section 15 for regulatory information)
HAZARDS DISCLOSURE: This product contains hazardous materials as defined by
the OSHA Hazard Communication Standard 29 CFR 1910.1200. As defined under
Sara 311 and 312, this product contains materials that are acute hazards.
MISCELLANEOUS: Contains Phosphoric Acid.
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
DANGER
May cause skin or eye irritation, rash, or burns.
HMIS Rating NFPA Rating
Health: 3 Health: 3
Flammability: 0 Flammability: 0
Reactivity: 0 Reactivity: 0
Personal Protection Index: C Special Hazard: Corrosive
NFPA/HMIS Definitions: (0-Least, 1-Slight, 2-Moderate, 3-High,
4-Extreme). These values are obtained using the guidelines or published
evaluations prepared by the National Fire Protection Association (NFPA) or
the National Paint and Coating Association (for HMIS ratings).
POTENTIAL HEALTH EFFECTS
EYE: Contact causes severe eye irritation and or burns.
SKIN: Contact may cause severe skin irritation and possible burns.
INHALATION: No known hazards in normal industrial use.
INGESTION: Ingestion is not considered a potential route of exposure.
May cause diarrhea, nausea, abdominal cramps. If ingested seek prompt
medical attention. Corrosive and may cause severe and permanent damage to
mouth, throat, and stomach.
SIGNS AND SYMPTOMS OF EXPOSURE: If exposed areas are flushed promptly
and thoroughly with water, there should be little or no harm. This product
is completely soluble in water.
CARCINOGENICITY INFORMATION: No known cancer hazards.
MISCELLANEOUS: Slippery, can cause falls if walked on.
NuGenTec
NuBrite CK Page 2 of 4
PRD Number: SDB133 ___ April 18, 2003
4. FIRST AID MEASURES
EYE CONTACT FIRST AID: Flush eye with water for 15 minutes. Contact a
physician.
SKIN CONTACT FIRST AID: Immediately flush skin with plenty of water.
Remove contaminated clothing and shoes. Get medical attention.
INHALATION FIRST AID: Although this product is not known to cause
respiratory problems, if breathing is difficult, remove to fresh air and
provide oxygen. Get immediate medical attention.
INGESTION FIRST AID: Get medical attention immediately. Do not induce
vomiting. Give milk or water.
STATEMENT OF PRACTICAL TREATMENT: Have plenty of water available for first
aid.
NOTES TO PHYSICIAN: Treat patient symptomatically.
5. FIRE FIGHTING MEASURES
FLAMMABLE PROPERTIES: Autoignition Temperature: None
COC Flash Point: None TCC Flash Point: None
FLAMMABLE LIMITS IN AIR LEL: None UEL: None
EXTINGUISHING MEDIA: Will not burn.
FIRE FIGHTING INSTRUCTIONS: Contaminated extinguishing water must be
disposed of in accordance with applicable regulations.
6. ACCIDENTAL RELEASE MEASURES
SAFEGUARDS (PERSONNEL): Protect skin and eyes from exposure.
INITIAL CONTAINMENT: Contain spilled material.
LARGE SPILLS PROCEDURE: Forms smooth, slippery surfaces on floors,
posing an accident risk. Dilute with water and wash to waste water
treatment system. Large spills may be neutralized with dilute alkaline
solutions of soda ash, or lime. Treat or dispose of waste material in
accordance with all local, state/provincial, and national requirements.
SMALL SPILLS PROCEDURE:
Floor may become slippery. Dispose into waste water treatment facility.
7. HANDLING AND STORAGE
RECOMMENDED STORAGE TEMPERATURE
Minimum: 4.4 C (39.9 F) Maximum: 48.9 C (120.0 F)
HANDLING (PERSONNEL): Avoid contact with eyes, skin, and clothing.
HANDLING (PHYSICAL ASPECTS): Keep out of reach of children. Keep from freezing.
Keep container closed to avoid contamination. Store in a cool dry area.
STORAGE PRECAUTIONS: Do not stack pails more than three pallets high. Do
not stack drums more than two pallets high. Keep from freezing. Keep
container closed when not in use.
MISCELLANEOUS: Do not stack over two pallets high.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
ENGINEERING CONTROLS: No special ventilation requirements.
EYE / FACE PROTECTION REQUIREMENTS: When splashing of the material may
occur, chemical goggles and a face shield are recommended.
SKIN PROTECTION REQUIREMENTS: Wear protective gloves to minimize skin
contamination.
RESPIRATORY PROTECTION REQUIREMENTS: Under normal use conditions, with
adequate ventilation, no special handling equipment is required.
MISCELLANEOUS: Where an apron and protective clothing.
EXPOSURE GUIDELINES: PHOSPHORIC ACID OSHA TWA: 1 mg/m^3
NuGenTec
NuBrite CK Page 3 of 4
PRD Number: SDB133 ___ April 18, 2003
9. PHYSICAL AND CHEMICAL PROPERTIES
FORM ...............................: Liquid
COLOR ..............................: Colorless
ODOR ...............................: Mild
BOILING POINT ......................: >212 F
SOLUBILITY IN WATER ................: Complete
SPECIFIC GRAVITY ...................: 1.18 (Water = 1)
BULK DENSITY .......................: 9.8
MELTING/FREEZING POINT .............: 32 F
PH .................................: 1.0
% VOLATILES ........................: 12 %
VOLATILE ORGANIC COMPOUNDS (VOC) ...: 120 g/L
10. STABILITY AND REACTIVITY
STABILITY: Stable.
POLYMERIZATION: Hazardous polymerization will not occur.
INCOMPATIBILITY WITH OTHER MATERIALS: None known.
DECOMPOSITION:
Decomposition will not occur if handled and stored properly.
CONDITIONS TO AVOID: Avoid contact with this material and ferrous metal
surfaces. This material is safe under normal storage and handling conditions.
11. TOXICOLOGICAL INFORMATION
EYE EFFECTS: Can cause severe eye irritation.
SKIN EFFECTS: Contact may cause skin irritation, rash or burns.
ACUTE ORAL EFFECTS: No know hazards in normal industrial use.
ACUTE INHALATION EFFECTS: No know hazards in normal industrial use.
12. ECOLOGICAL INFORMATION
No information available.
13. DISPOSAL CONSIDERATIONS
WASTE DISPOSAL:
Treat or dispose of waste material in accordance with all local,
state/provincial, and national requirements. For additional waste
disposal information contact your local NuGenTec representative at (888)
99-NuGen. Uncleaned empty containers should be disposed of in the same
manner as the contents.
CONTAMINATED MATERIALS: Wash contaminated clothing before reuse.
CONTAINER DISPOSAL: Clean out containers prior to disposal.
14. TRANSPORTATION INFORMATION
PRODUCT LABEL .............: NuBrite
D.O.T. SHIPPING NAME ......: Corrosive Liquid
TECHNICAL SHIPPING NAME ...: Corrosive Liquid, n.o.s. (phosphoric acid)
D.O.T. HAZARD CLASS .......: Corrosive
UN NUMBER .................: 1760 Corrosive Liquid, n.o.s.
PRODUCT RQ (LBS) ..........: 16,650
D.O.T. LABEL ..............: Corrosive Liquid, Packing Group III
D.O.T. PLACARD ............: #8
BULK CLASS ................: N/A
PACKAGE CLASS .............: 55
NuGenTec
NuBrite CK Page 4 of 4
PRD Number: SDB133 ___ April 18, 2003
MISCELLANEOUS:
Export Classification, organic surface active agents (other than soap),
washing preparations and cleaning preparations, schedule B # 3402.90.5030.
15. REGULATORY INFORMATION
EEC Symbols and Indications of Danger: Corrosive (C)
R-Phrases: R34 - Causes burns.
S-Phrases: S25 - Avoid contact with eyes.
S26 - In case of contact with eyes, rinse immediately with
plenty of water and seek medical advice.
WHMIS Hazard Symbols: Class E - Corrosive Material
Canadian Disclosure List PHOSPHORIC ACID (7664-38-2)
SARA Title III - Section 313 PHOSPHORIC ACID (7664-38-2)
CERCLA Hazardous Substances
PHOSPHORIC ACID (7664-38-2) -- RQ 5000 lb
RCRA Hazardous Substances - None
Clean Air Act - Section 112 none
Title V: PHOSPHORIC ACID (7664-38-2)
SC Toxic Air Pollutants List PHOSPHORIC ACID (7664-38-2)
FDA (FOOD AND DRUG ADMINISTRATION): This Product Meets FDA/USDA requirements for
cleaning in the food processing industry.
MISCELLANEOUS INFORMATION:
This material or all of its components are listed on the Inventory of
Existing Chemical Substances under the Toxic Substance Control Act
(TSCA). This material or all of its components are listed on the
Canadian Domestic Substances List (DSL). This material or all of its
components are listed (or considered as having been notified) on the
European Inventory of Existing Chemical Substances (EINECS).
16. OTHER INFORMATION
PREPARED BY .......: Donato Polignone
APPROVED BY .......: Milan Malek
TITLE .............: VP Research & Development
APPROVAL DATE .....: April 18, 2003
SUPERCEDES DATE ...: July 28, 2000
PRD NUMBER ........: SDB133 (Official Copy)
ADDITIONAL INFORMATION:
The data in this Material Safety Data Sheet relates only to the specific
material designated herein. It does not relate to use in combination
with any other material or in any process.
**********************************************************************
This information is furnished without warranty, expressed or implied,
except that it is accurate to the best knowledge of NuGeneration
Technologies, LLC. The data on this sheet are related only to the
specific material designated herein. NuGeneration Technologies, LLC
assumes no legal responsibility for use or reliance upon these data.
**********************************************************************
END OF MSDS
**********************************************************************
|