NuGenTec
NuBrite B 17 Page 1 of 6
PRD Number: SCB 103 ___ May 30, 2007
MATERIAL SAFETY DATA SHEET
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Identification
----------------------
Product Name: NuBrite B 17
Product Number: SCB 103
CAS Number: Blend
Company Identification
----------------------
NuGeneration Technologies, LLC www.nugentec.com
100 Professional Center Drive Suite 101
Rohnert Park, CA 94928 USA
(707) 820-4080 (For product information)
1-800-424-9300 or 1-202-483-7616 (CHEMTREC) (For emergencies)
SPECIAL NOTES:
This product is 100% Biodegradable. This product contains NO Chelates.
2. COMPOSITION/INFORMATION ON INGREDIENTS
100.0% NuBrite B 17
CONTAINING:
HAZARDOUS AND/OR REGULATED COMPONENTS
Chemical Name Amount CAS Number
------------- -------- ----------
DIPROPYLENE GLYCOL MONOMETHYL ETHER < 10.0 % 34590-94-8
NON-HAZARDOUS COMPONENTS
Chemical Name Amount CAS Number
------------- -------- ----------
POTASSIUM PHOSPHONATE < 5.0 % TRADESECRET
NONIONIC SURFACTANT BLEND < 5.0 % TRADESECRET
BALANCE NON-HAZARDOUS INGREDIENTS > 80.0 % N/A
This product contains hazardous materials as defined by the OSHA Hazard
Communication Standard 29 CFR 1910.1200.
EXPOSURE GUIDELINES:
Dipropylene Glycol Monomethyl Ether
OSHA PEL: 100 ppm, 600 mg/m^3
OSHA TWA: 100 ppm, 600 mg/m^3
3. HAZARDS IDENTIFICATION
NuGenTec
NuBrite B 17 Page 2 of 6
PRD Number: SCB 103 ___ May 30, 2007
***************** EMERGENCY OVERVIEW *****************
* *
* CAUTION *
* *
* Alkaline, liquid material. Can causes skin and eye *
* irritation. *
* *
**********************************************************
EYE:
Contact may cause eye irritation.
SKIN:
Contact may causes skin irritation.
INHALATION:
No known hazards in normal industrial use.
INGESTION:
Ingestion is not considered a potential route of exposure. May cause
diarrhea, nausea, abdominal cramps.
SIGNS AND SYMPTOMS OF EXPOSURE:
If exposed areas are flushed promptly and thoroughly with water, there
should be little or no harm.
CARCINOGENICITY INFORMATION:
No known cancer hazards.
MISCELLANEOUS:
Slippery, can cause falls if walked on. Otherwise, poses little or no
immediate hazard.
4. FIRST AID MEASURES
EYE CONTACT FIRST AID:
Flush eye with water for 15 minutes. Get medical attention if irritation
develops or persists.
SKIN CONTACT FIRST AID:
Immediately flush skin with plenty of water. Remove contaminated clothing
and shoes. Get medical attention if irritation develops or persists.
INHALATION FIRST AID:
Although this product is not known to cause respiratory problems, if
breathing is difficult, remove to fresh air and provide oxygen.
INGESTION FIRST AID:
Get medical attention immediately. Do not induce vomiting.
NuGenTec
NuBrite B 17 Page 3 of 6
PRD Number: SCB 103 ___ May 30, 2007
STATEMENT OF PRACTICAL TREATMENT:
Always have plenty of water available for first aid.
NOTES TO PHYSICIAN:
Treat patient symptomatically.
5. FIRE FIGHTING MEASURES
FLAMMABLE PROPERTIES
COC Flash Point: None
TCC Flash Point: None
Autoignition Temperature: None
FLAMMABLE LIMITS IN AIR
LEL: None
UEL: None
EXTINGUISHING MEDIA:
Will not burn.
NFPA Rating - Health: 1
Flammability: 0
Reactivity: 0
Special Hazard: None
FIRE & EXPLOSION HAZARDS:
Material will not burn.
FIRE FIGHTING INSTRUCTIONS:
Contaminated extinguishing water must be disposed of in accordance with
applicable regulations. Avoid breathing smoke, fumes, and decomposition
products.
6. ACCIDENTAL RELEASE MEASURES
SAFEGUARDS (PERSONNEL):
Protect skin and eyes from exposure.
INITIAL CONTAINMENT:
Contain spilled material.
LARGE SPILLS PROCEDURE:
Absorb spill with inert material (e g, dry sand or earth), then place in a
chemical waste container.
SMALL SPILLS PROCEDURE:
Wash with water or absorb spills with inert material.
NuGenTec
NuBrite B 17 Page 4 of 6
PRD Number: SCB 103 ___ May 30, 2007
7. HANDLING AND STORAGE
RECOMMENDED STORAGE TEMPERATURE
Minimum: 4.4 C (39.9 F)
Maximum: 48.9 C (120.0 F)
HANDLING (PERSONNEL):
Avoid contact with eyes, skin, and clothing.
STORAGE PRECAUTIONS:
Keep from freezing. Keep container closed when not in use.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
ENGINEERING CONTROLS:
Good general ventilation should be sufficient to control airborne levels.
EYE / FACE PROTECTION REQUIREMENTS:
When splashing of the material may occur, chemical goggles and a face
shield are recommended.
SKIN PROTECTION REQUIREMENTS:
Wear protective gloves to minimize skin contamination.
RESPIRATORY PROTECTION REQUIREMENTS:
Under normal use conditions, with adequate ventilation, no special
handling equipment is required.
9. PHYSICAL AND CHEMICAL PROPERTIES
FORM .....................: Liquid
COLOR ....................: Pale Yellow
ODOR .....................: Faint Odor
BOILING POINT ............: >212 F
SOLUBILITY IN WATER ......: Complete
SPECIFIC GRAVITY .........: 1.05 (Water = 1)
BULK DENSITY .............: 8.8
MELTING/FREEZING POINT ...: 32 F
PH .......................: 10.8 - 11.0
% VOLATILES ..............: <10 %
PH (5% B.V.) .............: 10.6 - 10.9
10. STABILITY AND REACTIVITY
STABILITY:
Stable.
POLYMERIZATION:
Hazardous polymerization will not occur.
NuGenTec
NuBrite B 17 Page 5 of 6
PRD Number: SCB 103 ___ May 30, 2007
INCOMPATIBILITY WITH OTHER MATERIALS:
None known.
DECOMPOSITION:
Decomposition will not occur if handled and stored properly.
CONDITIONS TO AVOID:
This material is safe under normal storage and handling conditions.
11. TOXICOLOGICAL INFORMATION
EYE EFFECTS:
Contact may cause eye irritation.
SKIN EFFECTS:
Contact may cause slight skin irritation.
ACUTE INHALATION EFFECTS:
No know hazards in normal industrial use.
POTASSIUM PHOSPHONATE
Test Code: Oral LD50
Species: Rats
Results: > 1090 mg/kg
12. ECOLOGICAL INFORMATION
No information available.
13. DISPOSAL CONSIDERATIONS
WASTE DISPOSAL:
Dilute or neutralize with acid and discharge to an industrial sewage
treatment facility. Treat or dispose of waste material in accordance
with all local, state/provincial, and national requirements. Uncleaned
empty containers should be disposed of in the same manner as the
contents. For additional waste disposal information contact your local
NuGenTec representative at (888) 99-NuGen.
CONTAMINATED MATERIALS:
Wash contaminated clothing before reuse.
CONTAINER DISPOSAL:
Clean out containers prior to disposal.
14. TRANSPORT INFORMATION
PRODUCT LABEL .............: NuBrite B 17
D.O.T. SHIPPING NAME ......: Cleaning Compound
TECHNICAL SHIPPING NAME ...: N/A
NuGenTec
NuBrite B 17 Page 6 of 6
PRD Number: SCB 103 ___ May 30, 2007
D.O.T. HAZARD CLASS .......: Non-Hazardous
UN NUMBER .................: N/A
D.O.T. LABEL ..............: NOBIN Non-Hazardous
D.O.T. PLACARD ............: N/A
BULK CLASS ................: N/A
PACKAGE CLASS .............: 55
15. REGULATORY INFORMATION
As defined under Sara 311 and 312, this product contains no known
hazardous materials.
MISCELLANEOUS INFORMATION:
This material or all of its components are listed on the Inventory of
Existing Chemical Substances under the Toxic Substance Control Act (TSCA).
16. OTHER INFORMATION
HMIS Rating - Health: 1
Flammability: 0
Reactivity: 0
Personal Protection Index: D
NFPA Rating - Health: 1
Flammability: 0
Reactivity: 0
Special Hazard: None
Prepared By.......: Donato Polignone
Approval Date.....: May 30, 2007
Supersedes Date...: January 11, 2000
PRD Number........: SCB 103 (Official Copy)
**********************************************************************
This information is furnished without warranty, expressed or implied,
except that it is accurate to the best knowledge of NuGeneration
Technologies, LLC. The data on this sheet are related only to the
specific material designated herein. NuGeneration Technologies, LLC
assumes no legal responsibility for use or reliance upon these data.
**********************************************************************
END OF MSDS
**********************************************************************
|