*** MATERIAL SAFETY DATA SHEET *** Page 1
Date of preparation: 07/01/04 4701010
SECTION I
Manufacturer : W. R. MEADOWS, INC. -HMIS-
Address : 2300 West Valley Boulevard |Health :1|
: Pomona, CA 91768 |Flammability :1|
|Reactivity :0|
Telephone # : (909) 469-2608 |Personal Protection :|
Emergency # : 1-800-424-9300 Chemtrec
(Hazard Rating: 0=Least,1=Slight,2=Moderate,3=High,4=Extreme,*=Chronic)
Mfg. code I.D. : 4701010
Trade Name : DECK-O-SEAL PG BASE
SECTION II-A HAZARDOUS COMPONENTS
% by SARA VAPOR PRESSURE LEL
No. Component CAS# Weight 313 (mm Hg @ 20 C) (@ 25 C)
1. Diethylene Glycol Dibenzoate 120-55-8 5-10 NO N/A N/A
2. Dipropylene Glycol Dibenzoate 27138-31-4 5-10 NO N/A N/A
3. Titanium Dioxide 13463-67-7 1-5 NO N/A N/A
4. Limestone 1304-29-6 20-25 NO N/A N/A
None of the components of this product are recognized as carcinogenic. N/A = Not Applicable
Under the reporting requirements of Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA) and 40 CFR Part
372, chemicals listed on the 313 List (40 CFR Part 373.65) are identified under the heading "SARA 313".
SECTION II-B OCCUPATIONAL EXPOSURE LIMITS
OSHA ACGIH
No. PEL/TWA PEL/CEILING PEL/STEL SKIN TLV/TWA TLV/CEILING TLV/STEL SKIN
1. N/E N/E N/E N/E N/E N/E N/E N/E
2. N/E N/E N/E N/E N/E N/E N/E N/E
3. 15 mg/m鲁**+ N/E N/E N/E 10 mg/m鲁** N/E N/E N/E
4. 15 mg/m鲁** 5 mg/m鲁 N/E N/E 10 mg/m鲁** N/E N/E N/E
N/E = Not established ** = Total dust + = 5 mg/m鲁 Respirable fraction
SECTION III PHYSICAL DATA
Boiling Point : 320 degrees F % Volatile by volume : Not applicable
Evaporation Rate : < 1 (N-Butyl Acetate = 1) % Volatile by weight : Not applicable
Vapor Density : > 1 (air = 1) Weight per gallon : 11.31 (Theoretical)
pH Level : Not applicable
SECTION IV HEALTH INFORMATION
EYE CONTACT: Based on the presence of components 1 and 2 this product may cause slight eye irritation. Corneal injury is unlikely.
SKIN CONTACT: Based on the presence of components 1 and 2 this product is non-irritating to the skin, but may cause mechanical irritation of the
skin. Prolonged contact may result in drying/defatting of the skin.
INHALATION: Inhalation of concentrated vapors may irritate the nose and throat.
INGESTION: Based on the presence of component 1 single dose oral toxicity is low. Ingestion may cause irritation of the gastrointestinal tract and/or
ulceration/burns in the throat and mouth.
SIGNS AND SYMPTOMS: Symptoms of eye irritation include pain, tearing, reddening, and swelling. Symptoms of skin irritation include reddening,
swelling, rash, and redness. Symptoms of respiratory irritation include runny nose, sore throat, coughing, chest discomfort, shortness of breath, and
reduced lung function. Symptoms of gastrointestinal irritation include sore throat, abdominal pain, nausea, vomiting, and diarrhea.
AGGRAVATED MEDICAL CONDITIONS: Pre-existing skin, eye, and respiratory disorders may be aggravated by exposure to this product. Impaired
asthmatic conditions may be aggravated from prolonged and continuous exposure to dust. Functions from pre-existing disorders may be aggravated
by exposure to this product.
OTHER HEALTH EFFECTS: None known.
Date of preparation: 07/01/04 4701010
DECK-O-SEAL PG BASE Page 1
*** MATERIAL SAFETY DATA SHEET *** Page 2
Date of preparation: 07/01/04 4701010
SECTION V EMERGENCY AND FIRST AID PROCEDURES
EYE CONTACT: If irritation or redness develops, move victim away from exposure source and into fresh air. Flush eyes with water for fifteen (15)
minutes. If symptoms persist, seek medical attention.
SKIN CONTACT: Remove contaminated shoes and clothing. Cleanse affected area(s) thoroughly by washing with mild soap and water. If irritation or
redness develops and persists, seek medical attention.
INHALATION: If respiratory symptoms develop, move victim away from exposure source and into fresh air. If symptoms persist, seek medical
attention. If victim is not breathing, immediately begin artificial respiration. If breathing difficulties develop, oxygen should be administered by qualified
personnel. Seek immediate medical attention.
INGESTION: Dilute with liquid unless the victim is unconscious or very drowsy. If vomiting spontaneously occurs, keep the victim鈥檚 head below the
hips to prevent aspiration into the lungs. Consult a physician, hospital, or poison control center and/or transport to an emergency facility immediately.
SECTION VI FIRE AND EXPLOSION HAZARDS
FLAMMABILITY CLASSIFICATION - NFPA: Not regulated
- DOT: Not regulated
FLASH POINT: Greater than 210 degrees F
EXTINGUISHING MEDIA: Use water fog, foam, dry chemical, or Carbon Dioxide.
SPECIAL FIRE FIGHTING PROCEDURES AND PRECAUTIONS: Clear area of unprotected personnel. Do not enter confined fire space without helmet,
face shield, bunker coat, gloves, rubber boots, and a positive pressure NIOSH approved self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Containers exposed to intense heat from fires should be cooled with water to prevent vapor pressure
buildup which may result in container rupture. Container areas exposed to direct flame contact should be cooled with large quantities of water as
needed to prevent weakening of container structure.
SECTION VII REACTIVITY
STABILITY: Stable HAZARDOUS POLYMERIZATION: Will not occur
CONDITIONS AND MATERIALS TO AVOID: Avoid oxidizing materials and strong acids.
HAZARDOUS DECOMPOSITION PRODUCTS: Combustion may yield Carbon Dioxide, Carbon Monoxide, and/or incomplete combustion products. Do
not breathe smoke or fumes. Wear appropriate protective equipment.
SECTION VIII EMPLOYEE PROTECTION
RESPIRATORY PROTECTION: Use ventilation as required to control vapor concentrations - at least 10 air changes per hour are recommended for
good general room ventilation. If exposure exceeds the PEL/TLV, use the appropriate NIOSH approved respirator.
PROTECTIVE CLOTHING: Wear safety glasses, goggles, or a splash shield to prevent eye contact. Contact lenses should not be worn. Wear
appropriate gloves and protective clothing to prevent contact with skin and clothing.
ADDITIONAL PROTECTIVE MEASURES: Eye wash fountains and safety showers should be available for use in an emergency.
SECTION IX ENVIRONMENTAL PROTECTION
SPILL OR LEAK PROCEDURES: LARGE SPILLS>> Evacuate the hazard area of unprotected personnel. Wear appropriate respirator and protective
clothing. Shut off source of leak only if safe to do so. Dike and contain. If vapor cloud forms, water fog may be used to suppress; contain run-off.
Remove with vacuum trucks or pump to storage/salvage vessels. Soak up residue with an absorbent such as clay, sand, or other suitable material;
place in non-leaking containers for proper disposal. Flush area with water to remove trace residue; dispose of flush solutions as above. SMALL
SPILLS>> Take up with an absorbent material and place in non-leaking containers; seal tightly for proper disposal.
WASTE DISPOSAL: Observe all Federal, State and local regulations regarding proper disposal.
SECTION X ADDITIONAL PRECAUTIONS
Containers can contain hazardous product residues even when empty. Wash with soap and water before eating, drinking, smoking or using toilet
facilities.
The information contained herein is based on the data available to us and is believed to be correct. However,
we make no warranty, expressed or implied regarding the accuracy of this data or the results to be obtained
from the use thereof. We assume no responsibility for injury from the use of the product described herein.
Date of preparation: 07/01/04 4701010
DECK-O-SEAL PG BASE Page 2
|