Material Safety Data Sheet MM-030
Complies with OSHA's Hazard Communication
GOODSON
Standard 29 CFR 1910.1200.
Tools and Supplies for Engine Builders
Airport Industrial Park 鈥? P.O. Box 847 鈥? Winona, MN 55987-0847
Toll-Free 1-800-533-8010 鈥? Local 507-452-1830 鈥? www.goodson.com
DATE OF PREPARATION: August 1, 1997
1. PRODUCT IDENTIFICATION
Part No.: MM-030
Description: Metal Marker-Yellow
HMIS: Health - 2 Flammability - 2 Reactivity - 0 Pers Prot - B
Chemical Family: Solvent base ink
DOT Hazard Class: UN1993 NOS
WHMIS (Canada Only): B3
DOT Shipping Name: Combustible Liquid NOS
2. HAZARDOUS INGREDIENT
Information on this Material Safety Data Sheets refers to inks used in pens and markers, however, it applies to these inks in bulk. The
inks are contained in capillary or valve reservoirs and will not spill or leak under normal conditions.
Ingredients CAS Reg Num# % (wt) Threshold Limit Value
Aromatic Hydrocarbon 64742-95-6 34 100 ppm / 8hr PEL/TWA
Clay, Silica 1332-58-7 27 15 mg/M3*
Titanium Dioxide 13463-67-7 10 15 mg/M3*
Hydrocarbon Resin 68240-01-7 20 10 mg/M3
CI Pig. Yel. 34 1344-37-2 9 .05 mg/M3*
This product is in compliance with EPA TSCA Inventory.
3. PHYSICAL DATA
Boiling Point: Low = 350掳F (177掳C) High = 410掳F (210掳C) Specific Gravity: 0.8
Viscosity: 3000-4000 CPS BROOKFIELD Vapor Pressure: 3mm Hg @ 25掳C
% Volatile by Volume: ca. 40 Vapor Density: 4.8
Solubility in Water: NIL VOC: 3.02 +/- .2 lbs/gal
Evaporation: Slower than ether
Appearance: Thick yellow liquid with aromatic odor
4. FIRE AND EXPLOSION DATA
Flash Point: 112掳F TCC LEL: 1.00% UEL: 7.00%
Extinguishing Media: Foam, CO2, Dry Chemical, Water Spray
Unusual Fire Hazards: n/a
Special Procedures: NNR
5. HEALTH HAZARD DATA
Listed as possible carcinogen: NTP: YES IARC: YES OSHA: YES
If YES: Long term exposure to lead chromate may cause cancer. See 29 CFR 1910.1025 Sections G through J.
Symptoms of Overexposure: Headache, dizziness, nausea, anesthesia, coughing, eye, throat, irritation
Effects of Overexposure: Slight to severe irritation to eyes and mucous membranes of nose & throat. Dermatitis. Affects central
nervous system.
Primary Routes of Entry: Ingestion, Dermal or Inhalation
漏 1998 Goodson Shop Supplies
EMERGENCY FIRST AID
Inhalation: Seek fresh air. Give artificial respiration if not breathing.
Skin Contact: Wash with copious water.
Ingestion: Call a physician.
6. REACTIVITY DATA
Stability: Stable
Conditions to Avoid: Heat, open flame and sparks
Hazardous Polymerization: Will not occur.
Incompatibility: Do not mix with strong oxidants
Hazardous Decomposition Products: Carbon monoxide, Carbon dioxide, & unidentified organic combustion products
7. ENVIRONMENTAL PROTECTION PROCEDURES
Spill Response: Remove all ignition sources, ventilate area, use absorbent material to clean spill.
Disposal Methods: Dispose of waste in accordance with local and federal regulations.
Protective Gear: NNR
Additional Measures: Keep away from heat, fire and strong oxidants. Store in cool place (room temp.) Use adequate ventilation.
Special Precautions: n/a
8. OTHER INFORMATION
LEGEND:
* = 'Free Dust' not bound in paint/ink matrix
n/a = Not applicable
NL = Not listed
NNR = Not normally required
NE = Not established
MSDS MM-030 Page 2
|