Material Safety Data Sheet SCF-2/SCF-10
Complies with OSHA's Hazard Communication
Standard 29 CFR 1910.1200.
DATE OF PREPARATION: August 6, 2008
1. IDENTIFICATION
Part No.: SCF-2 and SCF-10
Description: Valve Seat Cutting Fluid 1 pint and 1 gallon
Emergency Phone: 800-688-4005 (24 hours)
2. REPORTABLE COMPONENTS
Component /CAS # < Wt. % Exposure Limits
Light naphthenic, severely 10-20% ACGIH: 5 mg/m3 TWA
hydrotreated oil (reportable as mist only)
64742-52-5
*Indicates chemical subject to the reporting requirements of OSHA鈥檚 Hazard Communication Standard 1910.1200.
California Proposition 65: This product does not contain any ingredients known by the State of California to cause cancer, birth
defects, or other reproductive harm.
All components in this product are listed on TSCA.
3. PHYSICAL / CHEMICAL CHARACTERISTICS
Boiling Point: Specific Gravity:(H20=1)
100掳C 1.0
Vapor Density: (Air =1): Evaporation Rate (BuAc=1): <1
>1
Coating V.O.C.: Material V.O.C.:
0.00 lb/gl 0.00 lb/gl
Solubility in water: Appreciable
Appearance and odor: Amber liquid with mild odor
4. FIRE AND EXPLOSION HAZARD DATA
Flash Point: Method Used: TCC
>200掳F
Flammable Limits in Air by Volume Lower: NA Upper: NA
Extinguishing Media: Water Yes, CO2 Yes, Dry chemical Yes, Foam Yes, Alcohol foam yes
Special Firefighting procedures: Fire fighters should wear self-contained breathing apparatus in confined areas.
Unusual Fire and Explosion Hazards: None
5. REACTIVITY DATA
Stability: Chemically stable
Conditions to Avoid: None
Incompatibility (Materials to Avoid): Strong oxidizing agents.
Hazardous Decomposition or Byproducts:Oxides of carbon.
Hazardous Polymerization: Will not occur.
漏 2008 Goodson Shop Supplies
6. HEALTH HAZARD DATA
Inhalation Health Risks and Symptoms of Exposure: Unlikely at normal room temperatures. At elevated temperatures, eye, nose
and throat irritation may occur.
Skin and Eye Contact health risks and symptoms of exposure: Slight irritation
Skin Absorption health risks and symptoms of exposure: Slight irritant
Ingestion health risks and symptoms of exposure - Symptoms: Nausea and vomiting. Do not induce vomiting. If vomiting
occurs keep head below hips to prevent aspiration of liquid into lungs. Call a physician immediately.
HEALTH HAZARD DATA CONT...
HEALTH HAZARDS (ACUTE AND CHRONIC)
Acute: Slight irritation
Chronic: Effects are not known
CARCINOGENICITY
NTP Carcinogen: No.
IARC Monographs: No.
OSHA Regulated: No.
ACGIH Carcinogenicity:No
Medical conditions generally aggravated by exposure: Skin disorders
EMERGENCY AND FIRST AID PROCEDURES
Eyes: Flush well with water. Contact a physician if irritation persists.
Skin: Wash with soap and water.
Inhalation: No emergency care anticipated under normal conditions.
Ingestion: Do not induce vomiting. Contact a physician. If vomiting occurs, keep head below hips to prevent aspiration of liquid
into lungs.
7. PRECAUTIONS FOR SAFE HANDLING AND USE
Steps to be taken in case material is released or spilled: Prevent skin and eye contact. mop up or use absorbent material, wash
area, discard in suitable containers.
Waste Disposal Method: Remove to a waste disposal facility operating in compliance with federal, state, and local regulations.
Waste rags soaked with product should be disposed of into oily waste cans.
Precautions to be taken in handling and storing: If mists are generated in the use of this product; then the following values for
petroleum oils apply:
ACHIG-TLV/TWA = 5 mg/m3/8hr
OSHA-PEL/TWA = 5 mg/m3/8hr
ACGIH-TLV/STEL = 10 mg/m3
**If actual mists exceed these values, then appropriate respirators should be worn.
Shipping Classification: Non-Hazardous according to IATA, 49CFR, and IMDG Regulations.
8. CONTROL MEASURES
Respiratory Protection: None is required at normal handling temperatures.
Ventilation: Local exhaust is recommended for confined areas. General mechanical ventilation is adequate for normal use.
Protective Gloves: Chemical resistant rubber gloves, such as polyvinyl chloride-coated, and other protective gear as required to
minimize skin contact.
MSDS SCF-2 SCF-10 Page 2
Eye Protection: Safety glasses. Splash proof goggles.
Other protection clothing or equipment: Eye bath and safety shower.
Work/Hygienic Practices: Follow current HMIS regulations.
9. REGULATORY INFORMATION
U.S. Federal Regulatory Information:
SARA EXTREMELY HAZARDOUS SUBSTANCE: No chemicals in this product exceed the DE Minimus reporting level estab-
lished on the SARA EXTREMELY HAZARDOUS SUBSTANCE LIST.
SARA TITLE III, Section 313: No chemicals in this product exceed the DE Minimus reporting level established by SARA TITLE III,
Section 313.
TSCA: All ingredients are listed in TSCA inventory.
CERCLA: Not reportable
10. DISCLAIMER
Goodson bases the information and recommendations in this document on data believed to be correct. No warranty of any kind, how-
ever, is made as to the information in this document.
MSDS SCF-2 SCF-10 Page 3
|