Material Safety Data Sheet PJS-50
Complies with OSHA's Hazard Communication
GOODSON
Standard 29 CFR 1910.1200.
Tools and Supplies for Engine Builders
Airport Industrial Park 鈥? P.O. Box 847 鈥? Winona, MN 55987-0847
Toll-Free 1-800-533-8010 鈥? Local 507-452-1830 鈥? www.goodson.com
DATE OF PREPARATION: November 8, 1996
1. IDENTIFICATION
Part No.: PJS-50
Description: Jet Spray Cleaner for Cast / Aluminum
NFPA / HMIS Hazard Codes: (minimal = 0; slight = 1; moderate = 2; serious = 3; severe = 4)
Health = 0/0 Fire = 0/0 Reactivity = 0/0 Special / Personal Protection = None / A
DOT: Not regulated
2. HAZARDOUS COMPONENTS
Hazardous Components CAS # OSHA-PEL ACGIV-TLV % by Wt.
Sodium Metasilicate Pentahydrate 6834-92-0 n/d n/d 10 - 15 max.
Hazard is alkalinity. Product is a complex blend of non-hazardous biodegradable surfactants and detergents. This product is a powdered
detergent that contains no volatile organic compounds (VOC's).
4. FIRE AND EXPLOSION HAZARD DATA
Flash Point: n/a
Flammable Limits: Not applicable
Extinguishing Media: n/a
Special Firefighting Procedures: n/a
Unusual Fire Hazards: n/a
5. REACTIVITY DATA
Stability: Stable
Hazardous Polymerization: Will not occur
Conditions to Avoid: Strong Acids
Incompatibility: Strong Acids
Hazardous Decomposition Products: none
6. HEALTH HAZARD DATA
ROUTES OF ENTRY / SIGNS AND SYMPTOMS OF EXPOSURE:
Acute: As any detergent.
Eyes: Irritation
Inhalation: Inhalation of dust may be irritating.
Skin: Irritation or dermatitis with prolonged or repeated contact.
Ingestion: Swallowing may cause irritation, nausea, diarrhea.
漏 1998 Goodson Shop Supplies
HEALTH HAZARD DATA CONT...
Chronic Effects: None known
Carcinogens: None listed under OSHA, IARC, or NTP.
Medical Conditions Aggravated by Exposure: None known
EMERGENCY AND FIRST AID PROCEDURES:
Eyes: Rinse immediately with plenty of water for 10-15 minutes.
Skin: Wash affected area with mild soap and dry.
Inhalation: Remove to fresh air.
Ingestion: Give one pint of water or milk to dilute. Get medical attention for ingestion, or if irritation persists.
7. PRECAUTIONS FOR SAFE HANDLING AND USE
Spill or Leak Procedures: Pick up as appropriate. Reduce pH to 8 - 9.5. Flush residue to drain with water.
Waste Disposal Method: Dispose of as detergent in accordance with Federal, State and local regulations.
Handling and Storing: Store indoors.
Other Precautions: Keep out of reach of children.
8. CONTROL MEASURES
Respiratory Protection: None normally required
Ventilation: None required
Gloves: Rubber or plastic as needed to avoid prolonged contact.
Eye Protection: Goggles recommended when transferring concentrate.
Other Protective Equipment: None
Work / Hygienic Practices: None
MSDS PJS-50 Page 2
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP