GOODSON
Material Safety Data Sheet RS-16
GOODSON
Complies with OSHA's Hazard Communication
Standard 29 CFR 1910.1200.
Tools and Supplies for Engine Builders
156 Galewski Drive 鈥? P.O. Box 847 鈥? Winona, MN 55987-0847
Toll-Free 1-800-533-8010 鈥? Local 507-452-1830 鈥? www.goodson.com
DATE OF PREPARATION: REVIEWED ON:
April 5, 1993 November 27, 2002
GOODSON
1. IDENTIFICATION
Part No.: RS-16
Description: Rust Shield - Short Term 12oz.
Hazard Rating: Health = 1 Flammability = 4 Reactivity = 0 Protective Equipment = B
GOODSON
2. INGREDIENTS
Ingredient Cas No. OSHA PEL ACGIH TVL %WT
n-Heptane 142-82-5 400ppm 400ppm 40-45
Liquefied 68476-85-7 1000ppm 1000ppm 20-30
Petroleum Gas (LPG)
Medium Aliphatic 64742-88-7 N/E N/E 10-20
GOODSON
Petroleum Naphthenic
Distillate
Proprietary Rust Preventive Trade Secret N/E N/E
SARA: Superfund Amendments Reauthorization Act, Title III - 鈥淵ES鈥? = reportable under this act.
CERCLA: Comprehensive Environmental Response, Compensation & Liability Act - 鈥淵ES鈥? = reportable under this act.
WHMIS: Workplace Hazardous Materials Information System (Canadian) - 鈥淵ES鈥? = reportable under this system.
Prop 65: California鈥檚 Proposition 65 - 鈥淩鈥? = Reproductive Toxicant. 鈥淐鈥? = Carcinogen.
Clean Air: Clean Air Act Amendments, Section 301 - 鈥淵ES鈥? = listed on Hazardous Air Pollutants List.
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW: Contents extremely flammable and under pressure. Store below 120掳F, out of sunlight and away from
heat sources. Do not puncture or incinerate. Avoid contact with skin and eyes. Vapor harmful. Intentional misuse by deliberately
concentrating and inhaling the contents may be harmful or fatal.
HMIS Ratings: Health:1 Fire:4 Reactivity:0 Protective Equipment:B
POTENTIAL HEALTH EFFECTS:
EYE: Liquid or vapors may cause redness, burning, tearing, swelling and/or pain.
SKIN: Frequent or prolonged contact can result in defatting and drying of the skin which may result in skin irritation and dermatitis
(rash).
INGESTION: Due to being an aerosol, product does not lend itself to ingestion. Should ingestion occur, it may cause irritation to
membranes of the mouth, throat and gastrointestinal tract, resulting in vomiting and/or cramps.
INHALATION: Prolonged or repeated overexposure is anesthetic. May cause irritation of the respiratory tract, or acute nervous
system depression characterized by headache, dizziness, staggering gait, or confusion.
MEDICAL CONDIDIONS AGGRAVATED: Skin contact may aggravate an existing dermatitis. Others unknown.
CARCINOGEN DATA: None of the ingredients in this product are listed with OSHA, IARC or NTP as being carcinogenic.
4. FIRST AID MEASURES
INGESTION: Unlikely due to being an aerosol form. Should actual ingestion occur, do not induce vomiting! Drink a glass of water
or milk to dilute. Call a physician or poison control center immediately. Never give anything by mouth to an inconscious person.
EYE: Immediately flush with plenty of clear water for at least 15 minutes. Make sure to flush under the eyelids. Consult a physician
for definitive treatment.
SKIN: Remove with soap and water. Continue flushing with water for several minutes. Use skin cream to counter resulting dryness.
Consult a physician if irritation continues or if large skin area is affected.
INHALATION: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Seek medical
attention if symptoms persist or if unconscius.
5. FIRE FIGHTING MEASURES
FLASH POINT: Propellant < 0掳F FLAMMABLE LIMITS: LEL: 1.8% UEL: 9.5%
EXTINGUISHING MEDIA: For warehouse and storage conditions, use NFPA Class B extinguishers (CO2, dry chemical or
universal squeous film forming foam).
漏 2000 Goodson Shop Supplies
SPECIAL FIRE FIGHTING PROCEDURES: Use water spray to cool fire exposed aerosol containers for containers can rupture
violently from heat developed pressure.
UNSUSAL FIRE AND EXPLOSION HAZARDS: contents extremely flammable and under pressure. In addition, when liquid or
vapor comes into contact with flames or red hot metal, products of combustion will be created. Firemen should wear self-contained
breathing apparatus.
6. ACCIDENTAL RELEASE MEASURES
CONTAINMENT PROCEDURES: Product is an aersol, therefore spills and leaks are unlikely. In case of rupture, released content
should be contained as any other solvent spill.
SPILL CLEAN UP: Spills from aerosol cans are unlikely and are generally of small volume. Large spills are therefore not normally
considered a probelm. In case fo actual rupture, avoid breathing vapors and ventilate area well. Remove all sources of ignition and use
non-sparking equipment. Soak up material with inert absorbent and place in safety containers for proper disposal.
SPECIAL INSTRUCTIONS: Aerosol products represent a limited hazard and will not spill or leak unless ruptured. In case of
rupture contents are generally evacuated from the can rapidly. Area should be ventilated immediately and continuous ventilation
provided until all fumes and vapors have been removed. Aerosol cans should never be incinerated or burned. See Section 13 for
disposal considerations.
REPORTING REQUIREMENTS: Spills due to the rupture of a single aerosol can are generally below any regulatory reporting
reuirements. However, if larger spills somehow result, the reporting requirements of the EPA and other local, state and federal
agencies should be observed.
7. HANDLING AND STORAGE
Avoid prolonged or repeated skin contact. Avoid breathing vapors. Store in area below 120掳F. Do not incinerate (burn) containers.
Assure can is in a secure place to prevent knocking over and accidental rupture. Always replace overcap when not in use. For storage
of pallet quantities, compliance with ANSI/NFPA 30B is recommended.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
EXPOSURE GUIDLINE: Since this product is a mixture, an OSHA or ACGIH exposure value is not available. In determination of
any exposure procedures, protection or testing, use the lowest rated ingredient in Section 2.
SKIN PROTECTION: For brief contact, no precautions other than clean body-covering clothing should be needed. When prolonged
or repeated contact occur, use protective clothing such as Sol-Vex庐 gloves or ther clothingimprevious to the ingredients listed in
section 2.
EYE PROTECTION: Safety glasses with side shields are recommended as a minimum for any type of industrial chemical handling.
Where eye contact could occur, chemical splash proof goggles are recommended.
RESPIRATORY PROTECTION: Atmospheric levels should be maintained below the exposure guideline. When respiratory
protection is required an appropriate NIOSH approved respirator for organic vapor should be worn. If respirators are needed, assure
compliance with OSHA standard 29 CFR 1910.134.
ENGINEERING CONTROLS: General ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be
matched to condidtions. Local exhaust ventilation or an enclosed handling system may be needed to control air contamination below
that of the lowest TVL/PEL rated ingredient from Section 2.
9. PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point: Propellant <0掳F
Vapor Pressure: No data
Vapor Density (AIR=1) Above 1.0
Water Solubility: Negligible
Specific Gravity (H2O=1) Below 1.0
Percent Volatile: 80.0% Wt Max
Appearance and Odor: Straw colored liquid with a mineral spirits-like odor
10. STABILITY AND REACTIVITY
Stability: Stable
Hazard Polymerization: Will not occur
Conditions to avoid: Heat, sparks, flame, red hot metal
Incompatibilities: Strong oxidizing materials
Decomposition Products: Oxides of carbon
11. TOXICOLOGICAL INFORMATION
Acute Oral LD50: No data
Acute dermal LD50: No Data
Acute Inhalation LC50: LPG 57.42% v/v (mice)
12. ECOLOGICAL INFORMATION
This product has not been teted for environmental effcts.
MSDS RS-16 Page 2
13. Disposal considerations
An aerosol container that does not contain a significant amount of liquid would meet the definition of scrap metal (40 VFR
261.1(c)(6), and would be exempt from RCRA regulation under 40 CFR 261.6(a)(3)(iv) if it is to be recycled. If containers are not
recycled them must be managed uner all applicable RCRA and state regulations.
14. TRANSPORTATION INFORMATION
DOT INFORMATION
Proper Shipping Name: consumer commodity
Hazard Class or Division: ORM-D
Identification Number: None
Packaging Group: -
Label(s) Required: none
INTERNATIONAL TRANSPORTATION REGULATIONS
Proper shipping Name: consumer commodity
Class or Division: 9
Subsidiary Risk: -
Hazard Label(s) Miscellaneous
Packaging Group: -
UN or ID Number: ID8000
NATIONAL MOTOR FREIGHT CLASSIFICATION
Item: 50303
Article: Compounds, lubricating
Class: 55
15. REGULATORY INFORMATION
Toxic Substances Control Act: All of the ingredients in this product are on the TSCA inventory.
SARA title III, Section 313: The following ingredients are subject to the reporting requirements of section 313 of Title III of the
Superfund Amendments and Reauthrization Act of 1986 and 40 VFR Part 372: None
Clean air act (CAA): The following ingredients apppear on the List of Hazardous Air Pollutants (HAP-42 USC 7412, Title I, Part
A, p112):None
Clean Water Act:The following ingredients appear on the CWA List of Hazardous Substances (40 VFR 116.4):None
California Proposition 65: The following ingredients appear on the Proposition 65 list(s): None
Canadian Workplace Hazardous Materials Information System (WHMIS): The following ingredients are listed: LPG,
Petroleum Distillates, Heptane
16. OTHER INFORMATION
No other data available.
|