Material Safety Data Sheet SGB-10 / SGB-50
GOODSON
Complies with OSHA's Hazard Communication
Tools and Supplies for Engine Builders
Standard 29 CFR 1910.1200. Airport Industrial Park 鈥? P.O. Box 847 鈥? Winona, MN 55987-0847
Toll-Free 1-800-533-8010 鈥? Local 507-452-1830 鈥? www.goodson.com
DATE OF PREPARATION: DECEMBER 19, 1989
1. IDENTIFICATION:
Part No.: SGB-10, SGB-50
Description: Belt Resurfacer Coolant
NFPA (Rating): Health 3, Flammability 1, Reactivity 0
Chemical Family: Napthenic oil
2. HAZARDOUS INGREDIENTS
Ingredients Wt. pct. CAS # TLV-TWA1,2 Notes
Diethanolamine 1-5 111422 3 ppm TC
Triethanolamine 1-5 102716 n/e
1. "TLV" means the Threshold Limit Value exposure (8 hour time-weighted average, unless otherwise noted) established by ACGIH. "OSHA PEL"
refers to the Permissible Exposure Limits for airborne contaminants as specified in 29 CFR 1900.1000.
2. "n/e" indicates that neither TLV nor OSHA Permissible Exposure Limit has been established.
Notes: A1- human carcinogen; A2 - suspect carcinogen; C - ceiling limit (not a TWA); S - absorption through skin may be a significant route of expo-
sure; "TC" indicates a "Toxic Chemical" subject to the reporting requirements of SARA Section 313 (40 CFR Sec. 372).
3. HEALTH HAZARDS
Ingestion: Low oral toxicity for small amounts associated with industrial handling.
Inhalation: Inhalation of mist generated during working conditions may cause irritation.
Eyes: May cause moderate to severe eye irritation.
Skin: Moderate skin irritant
Effects of Chronic Overexposure: Chronic feeding studies with concentrated TEA and DEA have shown liver, kidney, and CNS
damage in rats and guinea pigs. Some liver and kidney effects have been seen in one study of rats subjected to prolonged, dermal
dosing.
Medical conditions that may be aggravated by exposure: None reported.
4. FIRST AID
Ingestion: Induce vomiting if large amounts are ingested. Give 2 glasses of water to dilute.
Inhalation: Remove patient to fresh air.
Eyes: Flush with water for 15 minutes. Consult a physician.
Skin: Wash affected area with soap and water. Remove contaminate clothing.
5. FIRE HAZARD
Flash Point: 325掳F; Method: TOC
Flammable limits in air: Lower - n/d Upper - n/d
Extinguishing Media: Water, CO2, Dry chemical
Special Firefighting Procedures: Use of chlorinated solvent fire extinguishers should be avoided.
Unusual Fire Hazards: Oxides of nitrogen may be generated in a raging fire. Full self-contained fire protection suits are
recommended.
漏 1997 Goodson Shop Supplies
6. ACCIDENTAL SPILL PROCEDURES
Mop up or use dry absorbents.
7. HANDLING AND STORAGE
None
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Eyes: Safety glasses or goggles.
Skin: Chemical resistant rubber gloves.
Respiratory: None required for normal use. If working conditions generate mists in a confined area, a NIOSH approved organic
vapor respirator should be worn.
Ventilation: Material does not give off hazardous vapors. If work conditions generate mist, ventilation (100 linear feet/minute) is
recommended.
9. PHYSICAL PROPERTIES
Initial Boiling Point: 212掳F Vapor Pressure: 22 at 68掳F
Melting Point: 30掳F Vapor Density: 0.63
Density/sp. gravity: 1.0 Percent Solids:
Evaporation Rate: <1 pH: 8.5-9.0
Appearance & Odor: Amber liquid with a mild odor. Water Solubility: 100%
10. STABILITY & REACTIVITY
Stability: Chemically stable
Conditions to Avoid: None
Materials to Avoid: Substances that react with water.
Hazardous Decomposition Products: In raging fire, oxides of nitrogen may be evolved.
Hazardous Polymerization: Will not occur.
11. TOXICOLOGICAL INFORMATION:
Oral LD50 (rat): 710 mg/kg (Diethanolamine); 8000 (Triethanolamine)
Dermal LD50 (rabbit): In mg/kg 12200 (Diethanolamine); >2000 (Triethanolamine)
Inhalation LC50 (rat): No data; exposure time: hours
Carcinogenicity: OSHA regulated?: NO ACGIH?: NO National Toxicology Program?: NO
International Agency for Research on Cancer?: NO Ingredients Listed: NONE
12. ECOLOGICAL INFORMATION:
13. DISPOSAL
May be disposed of according to federal, state, and local regulations.
14. TRANSPORTATION
US DOT: None
Proper Shipping Name: Not regulated
15. REGULATORY INFORMATION
CERCLA: None
MSDS SGB-10/SGB-50 Page 2
|