Material Safety Data Sheet PT-SOL
Complies with OSHA's Hazard Communication
GOODSON
Standard 29 CFR 1910.1200.
Tools and Supplies for Engine Builders
Airport Industrial Park 鈥? P.O. Box 847 鈥? Winona, MN 55987-0847
Toll-Free 1-800-533-8010 鈥? Local 507-452-1830 鈥? www.goodson.com
DATE OF PREPARATION: October 28, 1998
1. IDENTIFICATION
Part No.: PT-SOL Parts Tumbler Solution 1 gallon
Product Description: Clear liquid
Chemical Family: Alkaline detergent
Further Proper Shipping Names may be appropriate, depending on circumstances.
2. COMPOSITION, INFORMATION ON INGREDIENTS
Components / CAS # ACGIH TLV OSHA PEL % WT NOTES
2-Butoxyethanol 111-76-2 25 ppm (skin) 25 ppm (skin) <10 1
Sodium Silicate 1344-09-8 n/e n/e <5 n/a
P.Q. Corp.: 5mg/m3 ceiling
Sodium Nitrite 7632-00-00 n/e n/e <5 1
BASF Corp. recommendation: 2mg/m3
NOTE 1 - Section 313 Supplier Notification: 鈥?1鈥? identifies chemical ingredients subject to reporting requirements of Section 313 of the
Emergency Planning and Community Right-to-Know Act of 1986. This information should be included in all MSDS鈥檚 that are copied
and distributed for this material.
Sodium Nitrite and solutions of Nitrate Compounds are new additions to the Section 313 listing in 1995, and were not included in ear-
lier notifications.
3. HAZARDS IDENTIFICATION
Health: 1 Fire: 0 Instability: 0 Other: X
Hazard Signal (short term contact or inhalation only): 0=insignificant; 1=slight; 2=moderate; 3=high; 4=extreme
Threshold Limit Value: n/e, blended product. See Section 2 for information on listed ingredients.
Primary Routes of Entry: Eye contact, Skin contact, Inhalation of spray
EFFECTS OF ACUTE OVEREXPOSURE
Eyes: Irritation, severe irritation possible with prolonged contact.
Skin: Irritation possible with prolonged contact.
Inhalation of mists of product or solution: Irritation of respiratory tract. Headache.
Swallowing: Irritation of mouth, throat and stomach. Stomach upset. Possible reduced blood pressure, rapid pulse, headache,
nausea, vomiting, visual disturbances, cyanosis, collapse and coma.
Effects of Chronic Overexposure:Unknown; none expected beyond acute effects.
Carcinogenicity: This product or its ingredients have not been identified as a carcinogen or probable carcinogen by NTP, IARC
monographs, or OSHA.
Medical Conditions Aggravated by Exposure: Some people have an allergic sensitivity to nitrites. Otherwise, none known or
expected.
4. FIRST AID MEASURES
Eyes: Immediately flush with cool running water holding eye lids apart. Remove contact lenses if present, and continue flushing for
15 minutes. Get medical assistance if irritation persists or is severe.
Skin: Flush thoroughly with running water. Remove contaminated clothing and wash before reuse. If irritation develops and persists,
get medical advise or assistance.
Inhaled: Remove to fresh air. Immediately call for medical advice or assistance if breathing difficulty or irritation is severe or
continues.
Swallowed: Rinse mouth with large amounts of water. Drink water, milk or other fluids to dilute. Do not induce vomiting. Call for
medical advice or assistance if difficulties and discomfort develop and continue.
漏 1999 Goodson Shop Supplies
5. FIRE FIGHTING MEASURES
Flash Point: None
Flammable limits in air LEL-UEL: n/a
Extinguishing Media: As needed for surrounding fire.
Special Firefighting Procedures: For any chemical fire wear self contained breathing apparatus, and protective clothing to
prevent contact.
Unusual Fire and Explosion Hazards: None
Hazardous Combustion Products: Oxides of carbon and nitrogen
6. ACCIDENTAL RELEASE MEASURES
Small Spills: Flush drain with excess water.
Large Spills: Stop source of discharge if safe to do so. Contain spilled material, and keep from discharging to surface waters.
Recover to drum for later use, treatment or disposal. Flush residual to drain. Notify local, state, or national
authorities if required.
Disposal: Normally sewer disposable in dilute solutions. Check with local authorities about any possible restrictions.
7. HANDLING AND STORAGE
Handling: Avoid unnecessary contact with product. Avoid breathing mists of product or solution. Wash after use. Prevent contact
with incompatible materials See Section 10.
Storage: Keep containers tightly closed. Keep from freezing; may rupture container or degrade product.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Ventilation: General or local to avoid exposure to irritating mists if mists are generated.
Respirator: None normally required. NIOSH / MSHA approved respirator where conditions may cause exposure limits to be
exceeded from mists of product or solution.
Eye Protection: Glasses, goggles, or face shield where conditions may cause eye exposure.
Protective Clothing: Chemical resistant, impermeable gloves as needed to prevent excessive contact. Full body covering and shoes
as needed to prevent excessive contact.
Other Protective Equipment or Measures: Eye wash stations or running water in the work area.
9. PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point: 212掳F Vapor Pressure(mmHg@70掳F): n/e
Specific Gravity: 1.02 Vapor Density(Air=1): n/e
Percent Volatile: >80 Evaporation Rate(Ether=1): <1
Solubility in Water: complete pH: 12
10. STABILITY AND REACTIVITY
Stability: Yes. Hazardous Polymerization will not occur.
Conditions to Avoid: Contact with incompatible materials (see below).
Incompatible Materials: Strong oxidizing agents, strong acids. Do not mix with nitrites. Contains amines which may react with
nitrites or other nitrosating agents in acidic conditions to form nitrosamines. Some nitrosamines have been
found to cause cancer in animal studies.
11. DISCLAIMER
The above information is, to the best of our knowledge, current, accurate and complete based on information reasonably available to
us as of the date of preparation of this form. However, it is the user鈥檚 responsibility to determine the safety, toxicity and suitability for
his or her own use of the product described herein. Since the actual use by others is beyond our control, no guarantee, expressed or
implied, is made by us as to the effects of such use or on the safety or toxicity of this product. Nor do we assume any liability arising
out of use by others of the product. Nor is the information herein to be construed as absolutely complete, since additional information
may be necessary or desirable when exceptional conditions or circumstances exist or because of applicable laws or regulations.
Legend: n/e = not established n/a = not applicable
MSDS PT-SOL Page 2
|