WD-40
MATERIAL SAFETY DATA SHEET
SECTION 1 PRODUCT AND COMPANY IDENTIFICATION
MANUFACTURER/SUPPLIER: Canadian Office:
US Office: WD-40 Products [Canada] Ltd.
WD-40 Company P.O. Box 220
1061 Cudahy Place Toronto, Ontario M9C 4V3
San Diego, CA 92110
Information Phone #: (416) 622-9881
Information Phone #: (619) 275-1400 Emergency Phone # 24 hr:
Canutec: (613) 996-6666 鈥?
Emergency Phone # 24 hr:
Chemtrec: (800) 424-9300 鈥? Designated for use only in the event of chemical
Designated for use only in the event of chemical emergencies involving a spill, leak, fire exposure or
emergencies involving a spill, leak, fire exposure or accident involving chemicals
accident involving chemicals.
PRODUCT NAME: 3-IN-ONE Multi-Purpose Oil
PRODUCT USE: Lubricant
MSDS DATE OF PREPARATION: March 1, 2008
SECTION 2 HAZARDS IDENTIFICATION
CAUTION! May cause eye irritation. Prolonged or repeated skin contact may cause mild irritation and defatting
dermatitis. Avoid eye contact. Avoid prolonged or repeated contact with skin and clothing.
POTENTIAL HEALTH EFFECTS:
PRIMARY ROUTES OF ENTRY: Skin and eye contact.
ACUTE EFFECTS:
INGESTION: This product has low oral toxicity. Swallowing may cause gastrointestinal irritation, nausea, vomiting
and diarrhea. Aspiration into the lungs during swallowing or vomiting may cause chemical pneumonitis.
EYES: Contact may be irritating to eyes. May cause redness and tearing.
SKIN: Prolonged and/or repeated contact may produce mild irritation and defatting with possible dermatitis.
INHALATION: High concentrations of oil mists may cause nasal and respiratory irritation.
CHRONIC EFFECTS: None expected.
SECTION 3 COMPOSITION INFORMATION ON INGREDIENTS
Ingredient CAS Number Percent
Severely Hydrotreated Heavy 64742-52-5 >97%
Naphthenic Oil
Non-Hazardous Ingredients Proprietary <3%
SECTION 4 FIRST AID MEASURES
For Medical Emergencies Call 1-888-324-7596 (24 hours/day)
INGESTION: Aspiration Hazard. DO NOT induce vomiting. Call physician, poison control center or the WD-40
Safety Hotline at 1-888-324-7596 immediately.
EYE CONTACT: Flush thoroughly with water. Get medical attention if irritation persists.
SKIN CONTACT: Wash with soap and water. If irritation develops and persists, get medical attention.
Page 1 of 4
3-IN-ONE Multi-Purpose Oil
03/01/08
INHALATION: If irritation is experienced, move to fresh air. Get medical attention if irritation or other symptoms
develop and persist.
SECTION 5. FIRE FIGHTING MEASURES
EXTINGUISHING MEDIA: Use water fog, dry chemical, carbon dioxide or foam. Do not use water jet or flooding
amounts of water. Burning product will float on the surface and spread fire.
SPECIAL FIRE FIGHTING PROCEDURES: Firefighters should always wear positive pressure self-contained
breathing apparatus and full protective clothing. Cool fire-exposed containers with water.
UNUSUAL FIRE/EXPLOSION HAZARDS: Slightly combustible liquid. If heated above the flashpoint, will
release flammable vapors that can present a fire or explosion hazard.
SECTION 6. ACCIDENTAL RELEASE MEASURES
SPILL RESPONSE: Wear appropriate protective clothing (see Section 8). Eliminate all sources of ignition and
ventilate area. Contain and collect liquid with an inert absorbent and place in a container for disposal. Clean spill
area thoroughly. Report spills to authorities as required.
SECTION 7. HANDLING AND STORAGE
HANDLING: Avoid contact with eyes. Avoid prolonged contact with skin. Avoid breathing oil mists. Use with
adequate ventilation. Keep away from heat, hot surfaces and open flames. Wash thoroughly with soap and water
after handling. Keep containers closed when not in use. Keep out of the reach of children.
STORAGE: Store away from heat, flames and incompatible materials.
SECTION 8. EXPOSURE CONTROLE/PERSONAL PROTECTION
OCCUPATIONAL EXPOSURE LIMITS:
Severely Hydrotreated Heavy 5 mg/m3 TWA ACGIH TLV
Naphthenic Oil 10 mg/m3 STEL ACGIH TLV
Non-Hazardous Ingredients None Established
The Following Controls are Recommended for Normal Consumer Use of this Product
Engineering Controls: Use in a well-ventilated area.
Personal Protection:
Eye Protection: Avoid eye contact.
Skin Protection: Avoid prolonged skin contact. Wash hands with soap and water after use.
Respiratory Protection: None needed for normal use with adequate ventilation.
For Bulk Processing or Workplace Use the Following Controls are Recommended
Engineering Controls: Use adequate general and local exhaust ventilation to maintain exposure levels below that
occupational exposure limits.
Personal Protection:
Eye Protection: Safety goggles recommended where eye contact is possible.
Skin Protection: Wear chemical resistant gloves.
Respiratory Protection: None required if ventilation is adequate. If the occupational exposure limits are exceeded,
wear a NIOSH approved respirator. Respirator selection and use should be based on contaminant type, form and
concentration. Follow applicable regulations and good Industrial Hygiene practice.
Work/Hygiene Practices: Wash with soap and water after handling.
SECTION 9. PHYSICAL DATA
APPEARANCE AND ODOR: Clear amber liquid with a faint citronella odor.
Page 2 of 4
3-IN-ONE Multi-Purpose Oil
03/01/08
Boiling Point: Specific Gravity:
>550掳F 0.866-0.923 @ 20掳C
Solubility in Water: Insoluble pH: Not Applicable
Vapor Pressure: Not determined Vapor Density: Not determined
Percent Volatile: Nil VOC: Nil
Coefficient of Water/Oil Not Determined Flash Point: >305掳F (TOC)
Distribution: Flammable Limits: Not determined
SECTION 10 STABILITY AND REACTIVITY
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizing agents. Avoid heat and open flames.
HAZARDOUS DECOMPOSITION PRODUCTS: Carbon monoxide, carbon dioxide.
SECTION11 TOXICOLOGICAL INFORMATION
The oral toxicity of this product is estimated to be greater than 5,000 mg/kg based on an assessment of the
ingredients. This product is not classified as toxic by established criteria.
None of the components of this product is listed as a carcinogen or suspected carcinogen or is considered a
reproductive hazard.
SECTION12 ECOLOGICAL INFORMATION
No data is currently available.
SECTION13 DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD: If this product becomes a waste, it would not be expected to meet the criteria of a
hazardous waste. However, it is the responsibility of the generator to determine at the time of disposal the proper
classification and method of disposal. Dispose in accordance with federal, state, and local regulations.
SECTION14 TRANSPORT INFORMATION
U.S. DOT Hazard Classification: Not regulated
Canadian TDG Classification: Not regulated
IMDG Code Hazard Classification: Not regulated
SECTION15 REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS:
CERCLA 103 Reportable Quantity: This product is not subject to CERCLA reporting requirements, however, oil spills
are reportable to the National Response Center under the Clean Water Act and many states have more stringent release
reporting requirements. Report spills as required under federal, state and local regulations.
SARA TITLE III:
Hazard Category For Section 311/312: Acute health
Section 313 Toxic Chemicals: This product contains the following chemicals subject to SARA Title III Section 313
Reporting requirements: None
Section 302 Extremely Hazardous Substances (TPQ): None
EPA Toxic Substances Control Act (TSCA) Status: All of the components of this product are listed on the TSCA
inventory.
Page 3 of 4
3-IN-ONE Multi-Purpose Oil
03/01/08
CANADIAN REGULATIONS:
Canadian Environmental Protection Act: All of the ingredients are listed on the Canadian Domestic Substances List
or exempt from notification
Canadian WHMIS Classification: Not a controlled product
This MSDS has been prepared according to the criteria of the Controlled Products Regulation (CPR) and the MSDS
contains all of the information required by the CPR.
Section 16 鈥? Other Information__
HMIS Hazard Rating: Health 鈥? 1 (slight hazard), Fire Hazard 鈥? 1 (slight hazard), Physical Hazard 鈥? 0
(minimal hazard)
Revision Date: 03/01/08 Supersedes: 04/12/05
Prepared By: Industrial Health & Safety Consultants, Inc.
This MSDS complies with OSHA guidelines set by 29 CFR 1910.1200 and the Canadian WHMIS regulations. The
foregoing information has been compiled from sources believed to be accurate but is not warranted to be. Recipients
are advised to confirm in advance of need that data is correct. Standards change without notice. It is the
responsibility of the recipient to insure that their personnel have been notified of any changes which may affect
them. The data provided on this MSDS are not meant to be used as specifications, only as guideline information as
to the safe use of this product. User should refer to applicable laws before use.
N/D = Not Determined N/E = Not Established N/A = Not Applicable
Page 4 of 4
|