___________________________________________________________________________
____________ SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION _____________
PRODUCT IDENTIFICATION: . . : AIR LUBE 10W/NR-24/1PT
MANUFACTURER IDENTIFICATION
Company Name. . . . . . . : FUCHS LUBRICANTS CO.
Address . . . . . . . . . : 17050 LATHROP AVE.
HARVEY IL 60426
Telephone . . . . . . . . : 708-333-8900
Emergency Contact . . . . : Regulatory Compliance Department
Emergency Telephone . . . : 708-333-8900 (8am - 5pm CST, M-F)
800-255-3924 (24 Hours)
MSDS PRINT DATE . . . . . . : 02/05/2007
____________________
* EMERGENCY OVERVIEW
This product is a liquid that is insoluble in water.
Direct eye contact may cause minor, short term irritation. Short term
skin exposure is not expected to be irritating. Inhalation and ingestion
are not anticipated routes of exposure during normal conditions of use.
* HMIS Rating: Health- 1 Flammability- 1 Reactivity- 0 PPE- X
___________________________________________________________________________
______________________ SECTION 2 - COMPONENT DATA _______________________
Components listed in this section may contribute to the potential
hazards associated with exposure to the concentrate. The product may
contain additional non-hazardous or trade-secret components.
Mineral Oil Cas#: proprietary Percent: > 90
Exposure Limit:
ACGIH TLV: 5 mg/m3 (as mist)
ACGIH STEL: 10 mg/m3 (as mist)
OSHA PEL: 5 mg/m3 (as mist)
- Carcinogenic Components: This product contains no carcinogens.
___________________________________________________________________________
___________________ SECTION 3 - HAZARDS IDENTIFICATION __________________
POTENTIAL HEALTH EFFECTS and SYMPTOMS from SHORT TERM/ACUTE EXPOSURE:
- EYE EXPOSURE -
This product is not expected to cause eye irritation under normal
conditions of use. Symptoms of slight eye irritation may result
when direct contact occurs, or when exposed to high mist levels in
poorly ventilated areas.
- SKIN EXPOSURE -
Short term skin contact is not expected to cause skin irritation.
Prolonged or repeated direct exposure to the skin may result in
PRODUCT NAME: AIR LUBE 10W/NR-24/1PT
---------------------------------------------------------------------------
symptoms of irritation and redness. In severe cases, prolonged or
repeated contact may result in dermatitis accompanied by symptoms of
irritation, itching, dryness, cracking and/or inflammation.
- INHALATION -
This product has low volatility and so is not expected to cause
respiratory tract irritation during normal conditions of use. Exposure
to high mist levels in poorly ventilated areas may cause upper
respiratory tract irritation and difficulty breathing.
- INGESTION -
Ingestion may cause slight stomach irritation and discomfort.
POTENTIAL CHRONIC HEALTH EFFECTS:
No further data known.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE:
No further data known.
CARCINOGENICITY:
This product is not listed as a known or suspected carcinogen by IARC,
OSHA, or the NTP.
___________________________________________________________________________
_____________________ SECTION 4 - FIRST AID MEASURES ____________________
EYE CONTACT:
Upon direct eye contact, hold eyelids open and flush with a steady,
gentle stream of water for at least 15 minutes. If irritation is due to
exposure to mist or vapors, remove the individual to fresh air. If
irritation persists, flush the eyes with clean water until the irritation
subsides. If symptoms persist, contact a physician.
SKIN CONTACT:
Remove product from the skin by washing with a mild soap and water.
Contaminated clothing should be removed to prevent prolonged exposure.
If symptoms of exposure persist, contact a physician.
INHALATION:
Inhalation is not an expected route of exposure. If respiratory
irritation or distress occurs, remove the employee to fresh air. Contact
a physician or other medical professional if irritation or distress
persists.
INGESTION:
If small amounts are ingested, first aid measures are not likely to be
necessary. If larger amounts are ingested or if symptoms of ingestion
occur, dilute stomach contents with two glasses of water or milk. (NOTE:
Do NOT give anything by mouth to an unconscious person.) Do not induce
PRODUCT NAME: AIR LUBE 10W/NR-24/1PT
---------------------------------------------------------------------------
vomiting without medical supervision. If vomiting occurs spontaneously
keep airway clear. If symptoms of ingestion persist, seek medical
attention.
NOTE TO PHYSICIAN:
No further data known.
___________________________________________________________________________
___________________ SECTION 5 - FIRE FIGHTING MEASURES __________________
FIRE AND EXPLOSIVE PROPERTIES:
Flashpoint . . . . . . . . . . . . . : 320.0 艗F COC
Flammability Limits . . . . . . . . . : LEL -N/A
UEL -N/A
EXTINGUISHING MEDIA:
In accordance with NFPA guidance, dry chemical, foam, or CO2 fire
extinguishers are all acceptable. Note that while water fog extinguishers
are also acceptable, do NOT apply a direct stream of water onto burning
product because it may cause spreading and increase fire intensity.
UNUSUAL FIRE & EXPLOSION HAZARDS:
No further data known.
FIRE-FIGHTING PROCEDURES AND EQUIPMENT:
Emergency responders in the danger area should wear bunker gear and self-
contained breathing apparatus for fires beyond the incipient stage. See
Section 8 of the MSDS for other PPE to be worn as conditions warrant.
___________________________________________________________________________
________________ SECTION 6 - ACCIDENTAL RELEASE MEASURES ________________
CLEAN-UP MEASURES:
Important: As with any spill or leak, before responding ensure that you
are familiar with the potential hazards and recommendations of the MSDS.
Appropriate personal protective equipment must be worn. See Section 8
of this MSDS for PPE recommendations.
If possible, safely contain the spill with dikes or other spill response
equipment appropriate for petroleum or organic material releases. Take
measures to prevent spreading of product. Note that while product will
ignite it will not readily burn. However, as a precaution eliminate
ignition sources. Prevent from entering sewers or waterways. Large
volumes may be transferred to an appropriate container for proper
disposal. Small volumes or residues may be soaked up with absorbents.
Spill response materials should be collected for proper disposal.
___________________________________________________________________________
____________________ SECTION 7 - HANDLING AND STORAGE ___________________
HANDLING:
PRODUCT NAME: AIR LUBE 10W/NR-24/1PT
---------------------------------------------------------------------------
As with any industrial chemical, handle the product in a manner that
minimizes exposure to practicable levels. Prior to handling, consult
Section 8 of this MSDS to evaluate personal protective equipment needs.
Open containers slowly to relieve any pressure. Follow all other
standard industrial hygiene practices.
Empty containers may contain product residue. All safety precautions
taken when handling this product should also be taken when handling empty
drums and containers. Keep containers closed when not in use.
Product residue in empty containers is combustible but will not readily
burn. NOTE however, that excessive heating or cutting of empty containers
may create an ignition source sufficient to start a fire and in extreme
cases, cause an explosion.
STORAGE:
Protect product quality by storing indoors and away from extreme
temperatures. Close all containers when not in use.
SPECIAL COMMENTS:
No further data known.
___________________________________________________________________________
___________ SECTION 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION __________
PERSONAL PROTECTIVE EQUIPMENT:
Selection of personal protective equipment should be based upon the
anticipated exposure and made in accordance with OSHA's Personal
Protective Equipment Standard found in 29 CFR 1910 Subpart I. The
following information may be used to assist in PPE selection.
- EYE PROTECTION -
Wear eye protection appropriate to prevent eye exposure. Where
splashing is not likely, chemical safety glasses with side shields are
recommended. Where splashing may occur, chemical goggles or full face
shield is recommended.
- SKIN PROTECTION -
Gloves are not normally needed during normal conditions of use. If
health effects are experienced, oil or chemical resistent gloves such
as butyl or nitrile are recommended.
Where splashing or soaking is likely, wear oil or chemical resistent
clothing to prevent exposure.
- RESPIRATORY PROTECTION -
A respirator may be worn to reduce exposure to vapors, dust, or mist.
Select a NIOSH/MSHA approved respirator appropriate for the type and
physical character of the airborne material. A self-contained breathing
PRODUCT NAME: AIR LUBE 10W/NR-24/1PT
---------------------------------------------------------------------------
apparatus is recommended in all situations where airborne contaminant
concentration has not been confirmed to be below safe levels.
Respirator use should comply with the OSHA Respirator Protection
Standard found in 29 CFR 1910.134.
ENGINEERING CONTROLS:
Normal general ventilation is expected to be adequate. It is recommended
that ventilation be designed in all instances to maintain airborne
concentrations at lowest practicable levels. Ventilation should at a
minimum, prevent airborne concentrations from exceeding any exposure
limits listed in Section 2 of this MSDS.
The user may wish to refer to 29 CFR 1910.1000(d)(2) and the ACGIH
"Threshold Limit Values for Chemical Substances and Physical Agents
Biological Exposure Indicies" (Appendix C) for the determination of
exposure limits of mixtures. An industrial hygienist or similar
professional may be consulted to confirm that the calculated exposure
limits apply.
___________________________________________________________________________
______________ SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES _____________
Physical Appearance . . . . . . . . . : Amber
Odor . . . . . . . . . . . . . . . . : Mild petroleum
Physical State . . . . . . . . . . . : Liquid
Water Solubility . . . . . . . . . . : Insoluble
Specific Gravity . . . . . . . . . . : .950
___________________________________________________________________________
_________________ SECTION 10 - STABILITY AND REACTIVITY _________________
INCOMPATIBILITIES:
This product is incompatible with strong oxidizing agents.
DECOMPOSITION PRODUCTS MAY INCLUDE:
Thermal decomposition products are dependent on combustion conditions.
A complex mixture of airborne solid, liquid, particulates and gasses may
evolve when the material burns. Combustion byproducts may include:
oxides of sulfur,
oxides of carbon,
incompletely burned hydrocarbons as fumes and smoke.
CONDITIONS TO AVOID:
Avoid contact with incompatible materials and exposure to extreme
temperatures.
POLYMERIZATION:
This product is not expected to polymerize.
PRODUCT NAME: AIR LUBE 10W/NR-24/1PT
---------------------------------------------------------------------------
STABILITY:
This product is stable.
___________________________________________________________________________
_________________ SECTION 11 - TOXICOLOGICAL INFORMATION ________________
EYE EFFECTS:
No further toxicological data known.
SKIN EFFECTS:
No further toxicological data known.
ORAL EFFECTS:
No further toxicological data known.
INHALATION EFFECTS:
No further toxicological data known.
OTHER:
No further data known.
___________________________________________________________________________
__________________ SECTION 12 - ECOLOGICAL INFORMATION __________________
ECOTOXICOLOGICAL INFORMATION:
This product has not been evaluated for ecotoxicity. As with any
industrial chemical, exposure to the environment should be prevented and
minimized wherever possible.
ENVIRONMENTAL FATE:
The degree of biodegradability and persistence of this product has not
been determined.
___________________________________________________________________________
__________________ SECTION 13 - DISPOSAL CONSIDERATIONS _________________
WASTE DISPOSAL:
Ensure that collection, transport, treatment, and disposal of waste
product, containers and rinsate complies with all applicable laws and
regulations. Note that use, mixture, processing, or contamination of the
product may cause the material to be classified as a hazardous waste.
It is the responsibility of the product user or owner to determine at the
time of disposal, whether the product is regulated as a hazardous waste.
___________________________________________________________________________
___________________ SECTION 14 - TRANSPORT INFORMATION __________________
DOT HAZARDOUS MATERIAL INFORMATION:
* Not otherwise DOT regulated.
___________________________________________________________________________
__________________ SECTION 15 - REGULATORY INFORMATION __________________
PRODUCT NAME: AIR LUBE 10W/NR-24/1PT
---------------------------------------------------------------------------
FEDERAL REGULATIONS:
SARA 313:
This product contains NONE of the substances subject to the reporting
requirements of Section 313 of Title III of the Superfund Amendments
and Reauthorization Act of 1986 and 40 CFR Part 372.
Clean Water Act / Oil Pollution Act:
This product contains mineral oil and is subject to regulation by
Section 311 of the Clean Water Act and the Oil Pollution Act. Releases
of the product into or leading to surface waters must be reported to
the National Response Center at 1-800-424-8802.
CERCLA Reportable Quantity:
Any components listed below have been assigned a reportable quantity
(RQ) by the Federal EPA. Releases of the product into the environment
that exceed the RQ for a particular component must be reported to the
National Response Center at 1-800-424-8802.
___Component____________________________RQ____________
*-*-*-*-*-*-*-*-*-*-*-*-*-*
Toxic Substances Control Act:
The components of this product are listed on the TSCA Inventory.
Ozone Depleting Substances:
This product contains no ozone depleting substances as defined by the
Clean Air Act.
Hazardous Air Pollutants:
Any components listed below are defined by the Federal EPA as hazardous
air pollutants.
___Component______________________________________
*-*-*-*-*-*-*-*-*-*-*-*-*-*
STATE REGULATIONS:
This product contains mineral oil, and as used, may be regulated by state
used oil regulations. Check with the appropriate state agency to
determine whether such a regulation exists.
No further data known.
___________________________________________________________________________
_____________________ SECTION 16 - OTHER INFORMATION ____________________
Prepared by . . . . . . . . . . . . . : Corporate Regulatory Compliance
Date of issue . . . . . . . . . . . . : 02/05/2007
Last Revision Date . . . . . . . . . : 07/03/2002
C4705007
PRODUCT NAME: AIR LUBE 10W/NR-24/1PT
---------------------------------------------------------------------------
___________________________________________________________________________
NOTICE: This MSDS provides a good faith representation of information
believed to be accurate as of the last revision date. This document does
not create any express or implied product warranties. Since conditions of
use are beyond the control of Fuchs Lubricants Co., all risks associated
with product use are assumed by the user.
___________________________________________________________________________
|