MATERIAL SAFETY DATA SHEET Flammability
0
2 1
Health Reactivity
Manufactured by:
ANDERSON Chemical Company
* See Bottom
Litchfield, Minnesota 55355-1041
of Page
Special Hazard
(320) 693-2477
NFPA HAZARD RATING
Eclipse
Product Name:
Revised: 3/10/2005 lmt
24-HOUR EMERGENCY PHONE #: 1-800-424-9300 (CHEMTREC) Supersedes: 2/28/2003
I. IDENTIFICATION
Chemical Name And Synonyms: DOT Shipping Name
Not applicable Compounds, Cleaning Liquid
(Sodium Hydroxide)
Chemical Family: DOT Hazard Class & I.D. Number # PG
Alkaline Corrosive Material NA1760 8 II
II. HAZARDOUS INGREDIENTS
Component CAS NO. % TLV PEL Toxic Hazard
Sodium hydroxide 1310-73-2 13 2 mg/M3 NE NA Corrosive
Tetrasodium EDTA 64-02-8 <17 NE NE NA May cause eye, skin, respiratory tract irritation.
**Toxic chemical subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 搂372). NA: Not applicable
III. PHYSICAL DATA
Form: Liquid
Boiling Point: Not established
Solubility In Water: Complete
Specific Gravity: 1.268
Odor: None
Appearance: Clear, red liquid
IV. FIRE AND EXPLOSION HAZARD DATA
Flashpoint: Not applicable
Extinguishing Media: Use media appropriate to surrounding fire.
Special Fire
Fighting Procedures: Although this product is not combustible, if a fire occurs in the near vicinity, good fire-fighting practice dictates the use of self-contained
breathing apparatus and other protective gear. Keep fire exposed containers cool with water.
Unusual Fire And
Explosion Hazards: If the container breaks, the product should be handled with care as it is corrosive.
V. HEALTH HAZARD DATA
Carcinogenic: The raw materials used in this product are not considered to be a carcinogen by ACGIH and OSHA.
Effects Of Over-exposure: Corrosive. May cause severe burns or irritation. May cause irreversible damage to eyes in some cases. Harmful if swallowed.
Emergency And First
Aid Procedures: EYES: Flush immediately with water for 15 minutes, raise eyelids for complete rinsing. Get immediate medical attention.
SKIN: Flush with water for 15 minutes. If irritation persists, get medical attention. Remove contaminated clothing and wash before
reuse.
INGESTION: DO NOT induce vomiting. Give large quantities of water or milk. Get immediate medical attention. Never give anything
by mouth to an unconscious person.
* NFPA Degree or Hazard: 4 = Extreme; 3 = High; 2 = Moderate; 1 = Slight; 0 = Insignificant. Continued On Back
Eclipse
Page 2; Product Name:
VI. REACTIVITY DATA
Stable: X
Stability - Unstable:
Conditions To Avoid: None known.
Incompatibility: Reacts vigorously with strong acids. Avoid prolonged contact with aluminum, brass, bronze, copper, nickel, tin, lead, zinc and
other alkali sensitive metals or alloys. Halogenated compounds.
(Materials To Avoid)
Hazardous
Decomposition Products: Oxides of carbon and nitrogen are produced by the decomposition of this product
VII. SPILL OR LEAK PROCEDURES
Steps To Be Taken In Case Material Is Released Or Spilled:
Small spills: Dilute with a large amount of water and flush to drain.
Large spills: Remove nonessential personnel. Wear appropriate personal protection equipment. Maintain adequate ventilation.
Completely contain spilled material and prevent run-off into ground or surface waters or sewers. Recover as much material as
possible into containers for disposal. Rinse area with water, if appropriate, and recover into containers for disposal.
Waste Disposal Method: Dispose of according to Federal, State, and Local regulations.
VIII. SPECIAL PROTECTION INFORMATION
Respiratory Protection: Respiratory protection is not required for normal use. If mist level is high, wear NIOSH approved respirator.
Ventilation: Should be adequate to keep mist level below the TLV.
Protective Gloves: Chemical resistant gloves.
Eye Protection: Chemical safety glasses. If contact with large amounts is anticipated, goggles and a faceshield.
Protective Clothing: Where the possibility of contact exists, wear protective clothing.
IX. SPECIAL PRECAUTIONS
Precautions To Be Taken In Handling And Storing:
Do no get in eyes, on skin, or on clothing. Wash thoroughly after handling. Keep containers closed when not in use. Keep separate
from incompatible materials. Do not allow contact with aluminum.
Other Precautions: Safety showers and eyewash stations should be provided in the areas where this product is handled.
X. REVISED INFORMATION
MSDS Status: Product reformulation.
The opinions expressed herein are those of qualified experts within ANDERSON Chemical Company. We believe that the information contained herein is current as of the date of this Material Safety Data Sheet. Since
the use of this information and these opinions and the conditions of use of the product are not within the control of ANDERSON Chemical Company, it is the user's obligation to determine the conditions of safe use of the
product.
|