9 SPECIALTY ADHESIVES
MENTAL CO
ULTRA/BOND
ON M
IR
M
V
EN
ITM
OUR
ENT
ECO 840
SOLVENT-FREE QUICK DRYING
庐
CARPET PAD ADHESIVE
CARPET PAD ADHESIVE
SOLVENT-FREE QUICK DRYING
DESCRIPTION 3. APPLICATION
3.1 Gently squeeze the container to apply adhesive in
A solvent-free quick drying latex based adhesive
an even film onto floor using a zigzag pattern.
specifically designed for the permanent fastening of
Caution: Be careful not to allow adhesive to
most types of residential carpet pads over approved
contact walls.
substrates. ECO 840 has high tack to securely fasten
carpet pads to substrate while stretching carpet and to 3.2 Allow adhesive to dry for approximately five
resist movement during installation. minutes.
3.3 Place padding into position desired and apply
pressure to secure bond.
USES
3.4 Complete the installation as per pad and carpet
1. For the installation of most types of carpet pad.
manufacturer鈥檚 instructions.
3.5 Promptly clean adhesive smudges with water while
LIMITATIONS
adhesive is still fresh and with mineral spirits when
dried.
1. For interior installations only.
2. For residential installations only. 4. EXPANSION AND CONTROL JOINTS
4.1 Provide for expansion and control joints where
3. Do not use when the substrate temperature is
specified.
below 50掳F (10掳C) or above 90掳F (32掳C), or
when relative humidity exceeds 65%. 4.2 Do not cover any expansion joints with adhesive.
4. Do not apply directly over gypsum based 4.3 Cut flooring material on both sides along the
substrates or patching compounds. edges of expansion joints.
4.4 Insert the specified compressible bead and sealant
for expansion and control joints, according to
RECOMMENDED SUBSTRATES
plans and specifications.
鈥? Any wood underlayment that is recommended or
5. PROTECTION
guaranteed by either the wood underlayment
5.1 Protect containers from freezing in transit and
manufacturer or the floor covering manufacturer,
storage. This product is freeze/thaw stable at
such as Exterior grade plywood, Group 1, CC type.
temperatures down to 0掳F (-18掳C). However, it is
鈥? Fully cured concrete.
recommended to protect all water-based products
Note: It is recommended that all concrete slabs be
from freezing. If frozen, do not stir until material
tested for moisture. If moisture vapor emission exceeds
has completely thawed.
3 lbs./1000 sq. ft. (1,36 kg/92,9 m2) per 24 hours,
using the anhydrous calcium chloride test, this adhesive 5.2 Provide for heated storage on site and deliver all
materials at least 24 hours before work begins.
must not be used.
5.3 Restrict traffic for 24 hours to allow proper
adhesive set-up.
SETTING INSTRUCTIONS
SURFACE PREPARATION
1.
SEE 鈥淪URFACE PREPARATION鈥? SHEET.
MIXING
2.
Shake container to thoroughly mix product.
MAPEI
TECHNICAL DATA
Open time at 72掳F (22掳C)
Headquarters of the Americas
50% relative humidity 10 - 15 minutes
Drying time at 72掳F (22掳C) 24 hours 1144 East Newport Center Drive
Flash point Non-flammable Deerfield Beach, Florida 33442
Phone: (954) 246-8888
Maximum tolerance of moisture
Fax: (954) 246-8800
vapor emission from the concrete slab
www.mapei.com
(using the anhydrous calcium chloride test) 3 lbs. per 1000 sq. ft. (1,36 kg/92,9 m2) per 24 hours
pH 9,3
Customer Service
Cleanability With water while fresh, with mineral spirits when dry.
1-800-42-MAPEI
Color Light beige
Consistency Semi-liquid Technical Services
PACKAGING 1-800-992-6273 (U.S. and Puerto Rico)
Plastic jug: 1 US gal. (3,7 L) 1-800-361-9309 (Canada)
SHELF LIFE
Additional Information
12 months when stored in original containers at room temperature in a dry heated area.
HEALTH AND SAFETY Website: www.mapei.com
Consult the material safety data sheet for more information. Fax on Demand System
for Technical Data Sheets and MSDS
(954) 246-8590 (English only)
NOTICE
MAPEI 鈥? USA
We shall not be liable for incidental and consequential damages, as defined
under the uniform commercial code, directly or indirectly sustained, nor for
Anaheim, California
any loss caused by application of these goods not in accordance with current
Ft. Lauderdale, Florida
printed instruction or for other than the intended use. Before using, user shall
determine the suitability of the product for its intended use and user alone
Fredericksburg, Virginia
assumes all risks and liability whatsoever in connection therewith. Our liability
Garland, Texas
is expressly limited to replacement of defective goods. Any claim shall be
deemed waived unless made in writing to us within thirty (30) days from date
South River, New Jersey
it was, or reasonably should have been discovered.
Tempe, Arizona
West Chicago, Illinois
MAPEI 鈥? Canada
Laval, Qu茅bec
Brampton, Ontario
Delta, British Columbia
MAPEI 鈥? Puerto Rico
Dorado
PR4084 DS3E V0303
漏 2003 MAPEI Corp. All Rights Reserved.
Printed in the U.S.A.
|