MATERIAL SAFETY DATA SHEET
Page: 1
DATE PREPARED: 10/08/1999
MSDS No: B202
Blasting Media Sodium Bicarbonate
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Identi炉er: Blasting Media Sodium Bicarbonate
Product Code: B202
Product Name: Blasting Media - Sodium Bicarbonate
Molecular Formula: NaHCO3
Generic Name: Sodium Bicarbonate
MANUFACTURER: 24 HR. EMERGENCY TELEPHONE
HydroChem Industrial Services, Inc. NUMBERS:
900 Georgia Ave. Emergency Contact: HydroChem ER
Deer Park, TX 77536 Emergency Phone (800) 569-4889
Customer Service: (800) 934-9376
2. COMPOSITION/INFORMATION ON INGREDIENTS
wt.% CAS Registry #
Sodium Bicarbonate 100 144-55-8
COMMENTS:
Exposure limits for this product are not established. A TLV of 10 mg/m3 is recommended for dust.
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
IMMEDIATE CONCERNS:
No hazard in normal industrial use.
Dust may be slightly irritating to eyes and respiratory tracts.
4. FIRST AID MEASURES
EYES:
Immediately 掳ush eyes with water for 30 minutes while holding eyelids open. Seek medical at-
tention.
SKIN:
Immediately wash with soap and water. Rinse thoroughly. Seek medical attention if e庐ects occur.
Launder contaminated shoes and clothing before reuse.
INGESTION:
If swallowed, give 2 glasses of milk (preferred) or water and consult physician.
Page: 2
DATE PREPARED: 10/08/1999
MSDS No: B202
Blasting Media Sodium Bicarbonate
INHALATION:
Remove to fresh air. See a doctor if e庐ects occur.
5. FIRE FIGHTING MEASURES
Flashpoint and Method: Not Applicable
Flammable Limits: Not Applicable
Autoignition Temperature: None
GENERAL HAZARD:
Not considered a 炉re hazard.
EXTINGUISHING MEDIA:
Use alcohol foam, carbon dioxide, dry chemical or water spray when 炉ghting 炉res involving this
material.
FIRE FIGHTING EQUIPMENT:
As in any 炉re, wear self-contained breathing apparatus pressure-demand, (MSHA/NIOSH ap-
proved or equivalent) and full protective clothing to prevent contact with skin and eyes.
6. ACCIDENTAL RELEASE MEASURES
GENERAL PROCEDURES:
Scoop into appropritate containers.
Flush residual with plenty of water.
7. HANDLING AND STORAGE
GENERAL PROCEDURES:
Refer to Section 8.
STORAGE:
No special precautions required.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS:
Ventilation - General and local ventilation are required.
Page: 3
DATE PREPARED: 10/08/1999
MSDS No: B202
Blasting Media Sodium Bicarbonate
PERSONAL PROTECTION
EYES AND FACE:
Chemical goggles required and an eye wash in work area.
RESPIRATORY:
None normally needed. For protection from dust, use NIOSH approved respirator with dust
protection.
PROTECTIVE CLOTHING:
Clean body covering and chemical resistant gloves.
OTHER USE PRECAUTIONS:
Safety shower and eye wash in the work area.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Powder
Color: White
pH: 8.3
Percent Volatile: None
Vapor Pressure: Not Determined
Vapor Density: Not Determined
Melting Point: 122卤 F 50卤 C
Solubility in Water: 7 at 20卤 C
Speci炉c Gravity: 2.16 (water=1)
COMMENTS:
pH: for a 1% solution
Water Solubility: Solubility listed above is grams per 100 grams.
10. STABILITY AND REACTIVITY
STABLE: Yes
HAZARDOUS POLYMERIZATION: No
HAZARDOUS DECOMPOSITION:
Carbon dioxide and sodium hydroxide.
INCOMPATIBLE MATERIALS:
Strong acids
Page: 4
DATE PREPARED: 10/08/1999
MSDS No: B202
Blasting Media Sodium Bicarbonate
11. TOXICOLOGICAL INFORMATION
ACUTE
Eyes: Irritant. May cause pain, redness, discomfort.
Skin: No e庐ect expected. Prolonged or repeated contact may cause mild irritation.
Ingestion: No e庐ect expected. Swallowing large amounts may cause illness.
Inhalation: No e庐ect expected. Prolonged or repeated exposure may cause mild irritation. Dust
is irritating.
TARGET ORGANS:
Not Determined
GENERAL COMMENTS:
Carcinogens: Not listed by IARC, USA NTP, or USA OSHA.
COMMENTS:
Only selected Registry of Toxic E庐ects of Chemical Substances (RTECS) data is presented in this
document. See the actual entry in RTECS for complete information.
LD50 (rats) = 4220 mg/kg
RTECS Number: VZ0950000
12. ECOLOGICAL INFORMATION
GENERAL COMMENTS:
No environmental data for this material are currently available.
13. DISPOSAL CONSIDERATIONS
PRODUCT DISPOSAL:
Dispose of in accordance with ALL applicable federal, state and local regulations.
EMPTY CONTAINER:
Send empty bags to sanitary land炉ll. Render other types of containers unuseable by puncturing
or crushing and sending to a sanitary land炉ll unless prohibited by local regulations.
RCRA/USEPA WASTE INFORMATION:
This material is not a RCRA regulated material.
COMMENTS:
Always follow ALL applicable federal, state and local regulations.
Page: 5
DATE PREPARED: 10/08/1999
MSDS No: B202
Blasting Media Sodium Bicarbonate
14. TRANSPORT INFORMATION
DOT (DEPARTMENT OF TRANSPORTATION)
Proper Shipping Name: Sodium Bicarbonate { Not Regulated
Reportable Quantity (RQ) Under CERCLA: None
Placards: None
Label: None
15. REGULATORY INFORMATION
UNITED STATES
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT)
Fire: No Pressure Generating: No Reactivity: No Acute: No Chronic: No
Title III Notes: This product contains no substances which are de炉ned as toxic chemicals under
the reporting requirements of Section 313 of Title III of the Superfund Amendments and
Reauthorization Act of 1986 (40 CFR Part 372).
CERCLA (COMPREHENSIVE RESPONSE, COMPENSATION, AND LIABILITY ACT)
Reportable Spill Quantity: Not established
TSCA (TOXIC SUBSTANCE CONTROL ACT)
TSCA Status: All components of this material are on the TSCA inventory.
STATE REGULATIONS
PROPOSITION 65 STATEMENT:
This product does not contain any substance(s) which are de炉ned by the state of California to
cause cancer, birth defects, or other reproductive e庐ects.
16. OTHER INFORMATION
REASON FOR ISSUE:
Biannual review
Approval date: 10/08/1999
REVISION SUMMARY
Revision #: 5
This MSDS replaces the September 02, 1999 MSDS. Any changes in information are as follows:
In Section 1
Date Prepared
Page: 6
DATE PREPARED: 10/08/1999
MSDS No: B202
Blasting Media Sodium Bicarbonate
NFPA CODES
Fire: 0 Health: 1 Reactivity: 0
HMIS CODES
Fire: 0 Health: 1 Reactivity: 0
MANUFACTURER DISCLAIMER:
[TM ] Indicates a trade or service mark of HydroChem Industrial Services, Inc.
The information herein is believed to be accurate and is presented in good faith; however, no
warranties or representations are made by HydroChem Industrial Services, Inc. regarding the
accuracy or completeness of the information.
HydroChem Industrial Services, Inc. shall not be held liable for any damage resulting from the
handling, or from contact with the above product.
|