06142002 MATERIAL SAFETY DATA SHEET : 00000049 PAGE:1
HENKEL CONSUMER ADHESIVES
50 WEST DRIVE
BRAMPTON, ONTARIO CANADA L6T 2J4
(905) 459-1140
PRODUCT : LEPAGE OUTDOOR ALL WEATHER CARPET ADHESIVE (1633)
SECTION 01: PRODUCT INFORMATION
MANUFACTURER.....................HENKEL CONSUMER ADHESIVES
50 WEST DRIVE
BRAMPTON, ONTARIO
CANADA ; L6T 2J4
(905) 459-1140
AFTER HOURS - CANUTEC (613) 996-6666
WHMIS CLASSIFICATION.............B2. D2A. D2B. WHEN THIS PRODUCT IS LABELLED AS A CONSUMER PRODUCT IT IS
EXEMPT FROM WHMIS REGULATIONS. (SEE SECTION 12(f) OF THE HAZARDOUS
PRODUCTS ACT).
T.D.G. CLASSIFICATION............ADHESIVES, CLASS 3, UN 1133, PKG GRP II. WHEN THIS PRODUCT IS LABELLED AS
A CONSUMER COMMODITY IT IS EXEMPT FROM T.D.G. REGULATIONS (SEE SECTION
2.7(1) OF TRANSPORTATION OF DANGEROUS GOODS REGULATIONS).
PRODUCT NAME.....................LEPAGE OUTDOOR ALL WEATHER CARPET ADHESIVE (1633)
CHEMICAL FAMILY..................SYNTHETIC POLYMER. ORGANIC SOLVENT BLEND
MATERIAL USE.....................FLOORCOVERING ADHESIVE
SECTION 02: HAZARDOUS INGREDIENTS
HAZARDOUS INGREDIENTS % EXPOSURE LEVELS C.A.S. # LD/50, ROUTE, SPECIES LC/50, ROUTE, SPECIES
Naphtha,hydrotreated (C4-C11) 10-30 TLV: 50 ppm TWA 64742-49-0 28g/kg oral,rat Not available
Hexane 5-10 TLV-TWA: 50ppm 110-54-3 28.7g/kg,oral,rat Not available
Crystalline silica 0.1-1.5 0.1 mg/m3 (dust) 14808-60-7 Not available Not available
Toluene 0.1-1 TLV-TWA:188mg/m3 108-88-3 2.6-7.5g/kg,oral,rat 8800 ppm,4hr,rat
PEL-TWA:375mg/m3 14.1ml/kg,skin,rbt
SECTION 03: PHYSICAL DATA
PHYSICAL STATE...................Paste
APPEARANCE & ODOUR...............Tan paste
ODOUR THRESHOLD (ppm)............Not available
VAPOUR PRESSURE (mm Hg)..........Not available
VAPOUR DENSITY (AIR=1)...........3-4
BY VOLUME
BY WEIGHT
EVAPORATION RATE.................< 1 (Butyl acetate = 1)
BOILING POINT (deg C)............70 deg C
pH...............................Not applicable
SPECIFIC GRAVITY.................1.20
SOLUBILITY IN WATER (% W/W)......Not soluble
COEFFICIENT OF WATER/OIL.........Not available
DISTRIBUTION
SECTION 04: FIRE & EXPLOSION DATA
FLAMMABILITY.....................EXTREMELY FLAMMABLE
IF YES, UNDER WHICH..............Vapours may cause flash fires. Vapours may ignite explosively. Static
CONDITIONS? discharge possible. Avoid ignition sources in the presence of flammable or
combustible liquids.
AUTO IGNITION TEMPERATURE........> 250 deg C
EXTINGUISHING MEDIA..............Foam. Dry chemical. CO2
SPECIAL PROCEDURES...............A solid stream of water directed on hot and/or burning material may cause
violent frothing. Fire fighters should be equipped with self-contained
breathing apparatus to protect against potentially toxic and irritating
fumes.
FLASH POINT (C), METHOD..........< -18 deg C
SENSITIVITY TO IMPACT......Avoid shock and friction
SENSITIVITY TO STATIC............Yes. Avoid sparks or other sources of static electricity.
DISCHARGE
LOWER FLAMMABLE LIMIT (% VOL)....0.9 %
UPPER FLAMMABLE LIMIT (% VOL)....8.0%
HAZARDOUS COMBUSTION PRODUCTS....Hydrocarbons. Oxides of carbon (CO,CO2)
SECTION 05: REACTIVITY DATA
CHEMICAL STABILITY:
YES........................Under normal conditions
NO, WHICH CONDITIONS ?
COMPATIBILITY WITH OTHER
SUBSTANCES:
YES
NO, WHICH ONES?............Strong oxidizing agents
06142002 MATERIAL SAFETY DATA SHEET : 00000049 PAGE:2
PRODUCT : LEPAGE OUTDOOR ALL WEATHER CARPET ADHESIVE (1633)
SECTION 05: REACTIVITY DATA
REACTIVITY CONDITIONS ?..........Excessive heat, sparks and open flame
HAZARDOUS PRODUCTS OF............Oxides of carbon (CO,CO2) at high temperatures.
DECOMPOSITION
SECTION 06: TOXICOLOGICAL PROPERTIES
SKIN CONTACT...............Prolonged or repeated contact may cause dryness. Can cause drying and
defatting of skin leading to irritation and dermatitis.
SKIN ABSORPTION............May be absorbed by the skin.
EYE CONTACT................Irritation upon direct contact. Moderate to severe irritation. Vapours
cause tearing. On contact, will bond eyelids together. Causes corneal
damage.
INHALATION.................High vapour concentrations are irritating to the eyes and the respiratory
tract. May affect central nervous system. May cause irritation of nose and
throat, headache, nausea, dizziness, incoordination, drowsiness. May cause
headaches and dizziness; are anaesthetic. Inhalation of mist or vapour may
cause lung inflammatory condition.
INGESTION..................May cause irritation of the gastrointestinal tract. Aspiration of liquid
into lungs can cause chemical pneumonitis. Causes nausea, vomiting,
diarrhea, central nervous system depression.
EFFECTS OF ACUTE EXPOSURE........Refer to route of entry.
EFFECTS OF CHRONIC EXPOSURE......Dermatitis. This product contains crystalline silica. Prolonged exposure
to respirable crystalline quartz may cause delayed (chronic) lung injury
(silicosis).
LD 50 OF MATERIAL, SPECIES &.....See hazardous ingredients section (2)
ROUTE
LC 50 OF MATERIAL, SPECIES &.....See hazardous ingredients section (2).
ROUTE
EXPOSURE LIMIT OF MATERIAL.......See hazardous ingredients section (2)
IRRITANCY OF MATERIAL............Refer to route of entry
SENSITIZING CAPABILITY OF........None known
MATERIAL
CARCINOGENICITY OF MATERIAL......Crystalline silica is an IARC-listed known lung carcinogen. The
crystalline silica contained in this product will not typically become
airborne during normal conditions of use.
MUTAGENICITY OF MATERIAL.........Not available
REPRODUCTIVE EFFECTS.............Not available
TERATOGENICITY OF MATERIAL.......Not available
SYNERGISTIC MATERIALS............Not available
SECTION 07: PREVENTATIVE MEASURES
GLOVES/ TYPE...............Wear impervious gloves (in neoprene or rubber).
RESPIRATORY/TYPE...........None required under normal use. Use a NIOSH/MSHA approved respirator
whenever mist or spray is generated.
EYE/TYPE...................Safety glasses with side-shields
FOOTWEAR/TYPE..............Standard work shoes.
CLOTHING/TYPE..............Standard work clothes.
VENTILATION REQUIREMENTS.........Use adequate local exhaust ventilation. Avoid breathing mists; if general
ventilation or local exhaust is inadequate, persons exposed to mists
should wear approved breathing devices.
LEAK/SPILL.......................Do not use combustible materials. Eliminate all sources of ignition. Wear
a breathing apparatus. Evacuate all non-essential personnel. Follow all
applicable fire and explosion precautions during the spill response
procedure. Stop leak if safe to do so. Provide adequate ventilation to
spill area. For small spills:. Wipe up or absorb with sand or other
absorbent material. For large spills:. Dike area to prevent spreading.
WASTE DISPOSAL...................In accordance with municipal, provincial and federal regulations.
HANDLING PROCEDURES AND..........Keep away from heat, sparks, and open flame. Use adequate ventilation.
EQUIPMENT Wash thoroughly after handling.
STORAGE NEEDS....................KEEP AWAY FROM CHILDREN. Keep container closed when not in use. Store in a
cool dry place.
SPECIAL SHIPPING INSTRUCTIONS....Ship in accordance with applicable Transportation of Dangerous Goods (TDG)
regulations.
SECTION 08: FIRST AID MEASURES
EYE CONTACT......................Immediately flush with water for a minimum of 15 minutes holding lids
apart to ensure flushing of entire surface. Washing within 1 minute is
essential to achieve maximum effectiveness. Seek medical attention
immediately.
INGESTION........................Dilute with large quantities of water or milk. DO NOT induce vomiting. Get
immediate medical attention. Never give anything by mouth to an
unconscious person.
INHALATION.......................Remove victim to fresh air. If not breathing qualified personnel should
administer artificial respiration. Get medical attention.
SKIN CONTACT.....................Remove contaminated clothing. Wash affected area with water and soap. Seek
medical attention if irritation occurs or persists. Discard footwear that
has been contaminated on the inner surface. Wash clothing before reuse.
06142002 MATERIAL SAFETY DATA SHEET : 00000049 PAGE:3
PRODUCT : LEPAGE OUTDOOR ALL WEATHER CARPET ADHESIVE (1633)
SECTION 09: PREPARATION INFORMATION
PREPARED BY:.....................Regulatory Affairs
TELEPHONE NUMBER:................(905) 459-1140
DISCLAIMER2:.....................All information, recommendations, and suggestions appearing herein
concerning our product are based upon tests and data believed to be
reliable. However, it is the user's responsibility to determine the
safety, toxicity, and suitability for his own use of the product described
herein. Since the actual use by others is beyond our control, no
guarantee, express or implied, is made by Henkel Consumer Adhesives as to
the effects of such use, the results obtained, or the safety and toxicity
of the product nor does Henkel Consumer Adhesives assume any liability
arising out of use, by others, of the product referred to herein. The
information herein is not to be construed as absolutely complete since
additional information may be necessary or desirable when particular or
exceptional conditions or circumstan ces exist or because of applicable
laws or government regulations.
PREPARATION DATE.................JUN 13/2002
CANUTEC EMERGENCY (613) 996-6666
|