06182002 MATERIAL SAFETY DATA SHEET : 00000283 PAGE:1
HENKEL CONSUMER ADHESIVES
50 WEST DRIVE
BRAMPTON, ONTARIO CANADA L6T 2J4
(905) 459-1140
PRODUCT : LEPAGE PARQUET CEMENT
SECTION 01: PRODUCT INFORMATION
MANUFACTURER.....................HENKEL CONSUMER ADHESIVES
50 WEST DRIVE
BRAMPTON, ONTARIO
CANADA ; L6T 2J4
(905) 459-1140
AFTER HOURS - CANUTEC (613) 996-6666
WHMIS CLASSIFICATION.............D2A. WHEN THIS PRODUCT IS LABELLED AS A CONSUMER PRODUCT IT IS EXEMPT FROM
WHMIS REGULATIONS. (SEE SECTION 12(f) OF THE HAZARDOUS PRODUCTS ACT).
T.D.G. CLASSIFICATION............NOT REGULATED
PRODUCT NAME.....................LEPAGE PARQUET CEMENT
CHEMICAL FAMILY..................MIXTURE
MATERIAL USE.....................FLOORING ADHESIVE
SECTION 02: HAZARDOUS INGREDIENTS
HAZARDOUS INGREDIENTS % EXPOSURE LEVELS C.A.S. # LD/50, ROUTE, SPECIES LC/50, ROUTE, SPECIES
Crystalline silica 0.1-1 0.1 mg/m3 (dust) 14808-60-7 Not available Not available
SECTION 03: PHYSICAL DATA
PHYSICAL STATE...................Paste
APPEARANCE & ODOUR...............Tan paste. Low viscosity paste with slight odor
ODOUR THRESHOLD (ppm)............No data available
VAPOUR PRESSURE (mm Hg)..........Not available
VAPOUR DENSITY (AIR=1)...........Lighter than air
VOLATILES %
BY VOLUME..................32 %
BY WEIGHT
EVAPORATION RATE.................Slower than n-butyl acetate
BOILING POINT....................Not available
FREEZING POINT...................Not available
pH...............................6 - 7
SPECIFIC GRAVITY.................1.42
SOLUBILITY IN WATER (% W/W)......Partially soluble
COEFFICIENT OF WATER/OIL.........Not applicable
DISTRIBUTION
SECTION 04: FIRE & EXPLOSION DATA
FLAMMABILITY.....................Not flammable
IF YES, UNDER WHICH
CONDITIONS?
EXTINGUISHING MEDIA..............Water fog; Foam; CO2; Dry chemical
SPECIAL PROCEDURES...............Fire fighters should be equipped with self-contained breathing apparatus
to protect against potentially toxic and irritating fumes. Water spray may
be used to keep containers cool.
FLASH POINT (C), METHOD..........Does not flash
AUTO IGNITION TEMPERATURE........Not available
UPPER FLAMMABLE LIMIT (% VOL)....Not applicable
LOWER FLAMMABLE LIMIT (% VOL)....Not applicable
HAZARDOUS COMBUSTION PRODUCTS....Combustion will result in the usual decomposition products, including
oxides of carbon.
EXPLOSION DATA
SENSITIVITY TO STATIC............Not applicable
DISCHARGE
SENSITIVITY TO IMPACT......Not applicable
RATE OF BURNING............Not applicable
EXPLOSIVE POWER............Not applicable
SECTION 05: REACTIVITY DATA
CHEMICAL STABILITY:
YES........................Stable under normal temperature and pressure.
NO, WHICH CONDITIONS ?
COMPATIBILITY WITH OTHER
SUBSTANCES:
YES
NO, WHICH ONES?............Strong bases or oxidants. Strong Lewis or mineral acids
REACTIVITY CONDITIONS ?..........Product is stable; hazardous polymerization will not occur.
HAZARDOUS PRODUCTS OF............Acrid fumes. Oxides of carbon (CO,CO2) at high temperatures.
DECOMPOSITION
06182002 MATERIAL SAFETY DATA SHEET : 00000283 PAGE:2
PRODUCT : LEPAGE PARQUET CEMENT
SECTION 06: TOXICOLOGICAL PROPERTIES
ROUTE OF ENTRY:
SKIN CONTACT...............May cause irritation, especially on prolonged contact. May cause
dermatitis and allergic responses.
SKIN ABSORPTION............No data
EYE CONTACT................May cause mild transient irritation.
INHALATION.................May cause irritation of nose and throat, headache, nausea, dizziness,
incoordination, drowsiness
INGESTION..................May cause nausea and vomiting. Symptoms include nausea, abdominal pain and
possible collapse.
EFFECTS OF ACUTE EXPOSURE........Possible skin, eye, and respiratory tract irritation.
EFFECTS OF CHRONIC EXPOSURE......This product contains crystalline silica. Prolonged exposure to respirable
crystalline quartz may cause delayed (chronic) lung injury (silicosis).
LD 50 OF MATERIAL, SPECIES &.....Not available
ROUTE
LC 50 OF MATERIAL, SPECIES &.....Not available
ROUTE
EXPOSURE LIMIT OF MATERIAL.......Not established
IRRITANCY OF MATERIAL............Mild
SENSITIZING CAPABILITY OF........None known
MATERIAL
CARCINOGENICITY OF MATERIAL......Crystalline silica is an IARC-listed known lung carcinogen. The
crystalline silica contained in this product will not typically become
airborne during normal conditions of use.
REPRODUCTIVE EFFECTS.............None known
MUTAGENICITY OF MATERIAL.........None known
TERATOGENICITY OF MATERIAL.......None known
SYNERGISTIC MATERIALS............None known
SECTION 07: PREVENTATIVE MEASURES
PROTECTIVE EQUIPMENT
GLOVES/ TYPE...............Wear impervious gloves (in neoprene or rubber).
RESPIRATORY/TYPE...........If the TLV is exceeded, or if used in a poorly ventilated space or area
with limited ventilation, use an approved respirator in accordance with
applicable safety regulations. Use approved respirator for dusts and mists
when sanding, grinding or machining cured compound.
EYE/TYPE...................Wear chemical safety goggles.
FOOTWEAR/TYPE..............Standard work shoes.
CLOTHING/TYPE..............Wear adequate protective clothes.
ENGINEERING CONTROLS.............Local exhaust as needed to control vapor/dust levels to below recommended
limits.
LEAK/SPILL.......................Ventilate area. Shut off source of leak if safe to do so. Wear adequate
protective clothing and equipment. Contain the spill. Scrape or shovel
into containers. Cover loosely and remove to appropriate well ventilated
area until disposal. Absorb residual material with sand, or other
absorbent material.
WASTE DISPOSAL...................In accordance with municipal, provincial and federal regulations. Since
emptied container retains product residues all labelled hazard precautions
must be observed.
HANDLING PROCEDURES AND..........Do not take internally. Avoid smoking, drinking or eating in use. Avoid
EQUIPMENT contact with eyes, skin, and clothing. Avoid breathing vapor/dust/mist.
Wash thoroughly after handling. Tightly reseal all partially used
containers. Use adequate ventilation.
STORAGE NEEDS....................Store in a cool and dry place, for product integrity. Store away from all
sources of heat and ignition. Store empty containers away from heat and
flame. KEEP AWAY FROM CHILDREN.
SPECIAL SHIPPING INSTRUCTIONS....Protect against freezing.
SECTION 08: FIRST AID MEASURES
SKIN CONTACT.....................Remove contaminated clothing. Wash affected area with water and soap. Seek
medical attention if irritation occurs or persists.
EYE CONTACT......................Flush with plenty of water at least 15 minutes. If irritation persists,
get medical attention.
INHALATION.......................Remove to fresh air. If breathing is difficult, give oxygen. Administer
artificial respiration if not breathing. Obtain medical attention.
INGESTION........................Do not induce vomiting. Give water or milk if victim is conscious and not
drowsy. Should vomiting occur, be sure to keep victim's head below hips to
avoid aspiration of vomitus into the lungs. Obtain immediate medical
attention.
SECTION 09: PREPARATION INFORMATION
PREPARED BY:.....................Regulatory Affairs
TELEPHONE NUMBER:................(905) 459-1140
06182002 MATERIAL SAFETY DATA SHEET : 00000283 PAGE:3
PRODUCT : LEPAGE PARQUET CEMENT
SECTION 09: PREPARATION INFORMATION
DISCLAIMER2:.....................All information, recommendations, and suggestions appearing herein
concerning our product are based upon tests and data believed to be
reliable. However, it is the user's responsibility to determine the
safety, toxicity, and suitability for his own use of the product described
herein. Since the actual use by others is beyond our control, no
guarantee, express or implied, is made by Henkel Consumer Adhesives as to
the effects of such use, the results obtained, or the safety and toxicity
of the product nor does Henkel Consumer Adhesives assume any liability
arising out of use, by others, of the product referred to herein. The
information herein is not to be construed as absolutely complete since
additional information may be necessary or desirable when particular or
exceptional conditions or circumstan ces exist or because of applicable
laws or government regulations.
PREPARATION DATE.................JUN 17/2002
CANUTEC EMERGENCY (613) 996-6666
|