Food Service Products
Big Break CL
Chlorinated For Use On:
Meatroom
Food Processing
Floors Tables
Stainless Steel
Walls Vinyl
Concrete Porcelain
Degreaser DESCRIPTION
This product is a specially formulated concentrated high foaming
chlorinated degreaser for removing stubborn stains and greasy soils from
cutting boards, tile and grout, sinks, walls, equipment, etc. May also be
used on rubber or vinyl surfaces, but must be rinsed immediately
after using.
DIRECTIONS
NOTE: This product MUST be diluted before use. Failure to do so may
result in damage to equipment or certain surfaces. Wear rubber gloves,
eye protection and protective clothing before using.
Before using, remove all food products and packaging materials from the
area, or carefully protect from contact.
FOR GENERAL CLEANING AND BLEACHING: Dilute 1 part product per
20 parts water. (approx. 6.4 oz. per gal.)
FOR HEAVY DUTY CLEANING AND BLEACHING: Dilute 1 part product
per 10 parts water. (approx. 12 oz. per gal.)
Spray or sponge diluted product onto area to be cleaned and allow stains
to disappear before rinsing. Scrubbing or brushing may be necessary for
heavily soiled or stained cutting surfaces. After using this product, all
surfaces in the area must be thoroughly rinsed with potable water.
PRODUCT SPECIFICATIONS
Active Ingredients: 20% min. Emulsification: Excellent
Color: Slight yellow Detergency: Excellent
Odor: Chlorine Rinsability: Complete with water
pH: 13.0 - 13.5 Flash Point: None (water-based)
Viscosity: Water thin Storage/Stability: 1 year
Foam: Moderate Weight Per Gallon: 10.6 lbs. per gallon
Abrasives: None Freeze Thaw Stability: Keep from freezing
Solubility: Complete with water
Misco Products Corporation Reading, PA (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
CHL MATERIAL SAFETY DATA SHEET N/A= Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 2/02 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Manufacturer鈥檚 Name: Product Name: Big Break CL Supplier鈥檚 Name:
Misco Products Corporation Generic Name: Chlorinated Meatroom Degreaser
Manufacturer鈥檚 Address: Chemical Family: Alkaline Detergent Blend Supplier鈥檚 Address:
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer鈥檚 Phone #: (610) 926-4106 Supplier鈥檚 Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Water 7732-18-5 to 100
3
Sodium Hypochlorite 7681-52-9 0 to 5 N/A C2mg/M N/A
C2mg/M3
Potassium Hydroxide 1310-58-3 15 to 20 N/A N/A
Amine Oxide 2605-78-9 0 to 5 N/A
Sodium Xylene Sulfonate 1300-72-7 0 to 5
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Boiling Point (掳F): 210 F. Specific Gravity: 1.042 Flash Point (Method Used): N/A
Vapor Pressure: 20mm Hg @ 68 F. Vapor Density (Air=1): >1 Upper Explosion Limit: N/A Lower Explosion Limit: N/A
% Volatile: 85+ pH: 13.0-13.5 Extinguishing Media: N/A
Solubility in Water: Complete Evaporation Rate (Water=1): <1 Special Firefighting Procedures: Non Flammable
Physical Description: Thin clear liquid with chlorine bleach odor. Unusual Fire and Explosion Hazards: N/A
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Alkaline vapors in a fire. Chlorine gas when in Incompatibility (Materials to Avoid: Acids, reducing agents, ammonia, organics, heavy
contact with acids. Heat and hydrogen gas generated when in contact with certain organic metals.
materials
SECTION 6-STORAGE AND HANDLING INFORMATION
DANGER: Corrosive to eyes and skin. May react with organic materials, causing generation of heat and hydrogen gas. Keep out of reach of children. For use by trained personnel
only. Keep container tightly closed during storage. For institutional and industrial use only. Avoid contact with eyes, skin and clothing. Wear rubber gloves and eye protection
when using. Avoid breathing of vapors or mists. Use in well-ventilated area.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: NIOSH/MSHA approved chlorine canister when used in confined
areas.
Skin: Severe skin irritant. May cause moderate reddening, swelling, and possible skin
Ventilation Requirements: Provide local exhaust to keep TLV of Section 2 in-gredients
damage.
below acceptable limit.
Eyes: Severe eye irritant. Liquid and mists may damage eyes, causing corneal damage.
Protective Gloves: Chemical resistant rubber or neoprene.
Inhalation: Vapors and mists may be irritating to mucous membranes in the nose, throat,
Eye Protection: Chemical splash goggles or full face shield.
and lungs.
Other Protective Equipment: Eyewash station nearby. Wear protective rubber footwear
Ingestion: Irritating and corrosive to the mouth and throat. May cause headache, nausea,
when using on floor. Wear protective outerwear when spraying or danger of mist contact
abdominal pain, vomiting, and diarrhea. Excessive amounts may cause collapse.
may occur.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Flush with water. Seek medical attention if irritation persists. Steps to be taken in Case Material is Released or Spilled: Floors will become slippery.
Eyes: Object is to immediately Flush with large quantities of water, holding eyelids open. Avoid walking in product. Keep unessential personnel away. Ventilate area by opening
Seek medical attention if irritation persists. doors, windows, etc. Mop up or otherwise absorb and hold disposal. Avoid discharge to
Inhalation: Get to fresh air. Seek medical attention if irritation persists. sewer or open waterways. Do not use combustible materials e.g. sawdust to absorb.
Ingestion: Do not induce vomiting. Drink large quantities of water. Seek medical attention Waste Disposal Method: Any method in accordance with local, state and federal laws.
immediately. Best method is to recycle or reuse for intended purpose. If discarded, this material and
containers should be treated as hazardous waste based on the characteristic of corrosivity
as defined under federal RCRA regulations (40 CFR 261). Consult local authorities for
disposal in public sewer. Do not disposal of into storm drain, stream, river or to ground.
Rinse container thoroughly before discarding in trash.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
No - Fire Hazard FOR CONTAINERS > 1 Gallon: Compounds, cleaning liquid, Identification System
No - Sudden Release of Pressure Hazard (Potassium Hydroxide), 8, NA-1760, PG III Health 3
Yes - Reactivity Hazard FOR 1 GALLON CONTAINERS: Compounds, cleaning liquid, Flammability 0
Yes - Immediate (acute) Health Hazard (Potassium Hydroxide), 8, NA-1760, PG III (Limited Quantity) Reactivity 1
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON: ORM-D Personal Protection D
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 and of
40 CFR 372.
CAS# Chemical Name Percent by Weight
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the application of this
information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to provide a safe workplace, using the
health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from the improper handling and use of this product
|