Clean-Up
Wood Floor Care
Waterless For Use On:
Cleaner
Quarry Tile Flagstone
Wood
Brick Terrazzo
Concrete
DESCRIPTION
A blend of refined solvents formulated for use in cleaning and preparing
wood, concrete, terrazzo, quarry tile, and other hard surfaces prior to
sealing and/or finishing. Easily removes most soil, dirt, oil, black heel
marks, rubber burns, chewing gum and tar. Excellent for tack ragging
wood, and as a clean-up solvent for application tools. Designed to
evaporate quickly, leaving no greasy or oily residue to damage gloss
and/or prevent bonding. Not for use on resilient tile.
DIRECTIONS
FOR USE ON WOOD FLOORS PRIOR TO COATING: Apply with a
mop and bucket to areas of approximately 100 square feet. Immediately
scrub with a scrubbing pad or steel wool. Pick up with a wet vacuum
or mop. Rinse floor thoroughly with fresh product and allow one hour dry
time prior to coating.
FOR TACKING OF FLOORS: Apply to clean cotton towels, making sure
not to over-wet. Tack in usual manner.
FOR REMOVING TAR, RUBBER BURNS, CHEWING GUM ETC.:
Apply to clean cotton cloth. Rub soiled area until clean. Apply directly
to larger areas of soils or rubber burns and allow to soak for several
minutes before wiping clean.
FOR PARTS AND MACHINERY CLEANING: Spray product directly
from container and wipe dry. Immerse parts to be cleaned in solution.
Wipe or air dry.
In federally inspected meat and poultry plants, equipment must be washed
with an effective cleaner and rinsed with potable water.
PRODUCT SPECIFICATIONS
Active Ingredients: 100% Water Miscibility: None
Color: Clear Drying Time: Rapid
Odor: Solvent Sediment: None
Solvent Systems: High K.B. mineral spirits Storage/Stability: 2 years
o
Flash Point: Greater than 100 F Freeze/Thaw Stability: Keep from freezing
Viscosity: Water thin Weight per Gallon: 6.87 lbs./gal.
300-400 ft2 per gal.
Foam: Low Coverage:
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
CLE MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 5/99 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: Clean-Up
Manufacturer鈥檚 Name: Supplier鈥檚 Name:
Misco Products Corporation Generic Name: Waterless Cleaner
Manufacturer鈥檚 Address: Supplier鈥檚 Address:
Chemical Family: Hydrocarbon Solvent Blend
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer鈥檚 Phone #: (610) 926-4106 Supplier鈥檚 Phone #:
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Petroleum Distillates 64742-48-9 45 to 55 500 ppm 100 ppm N/A
Aromatic Hydrocarbons 64742-95-6 45 to 55 500 ppm 50 ppm N/A
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 106 F. (TCC)
Boiling Point (掳F): 310 F. Initial Specific Gravity: .83
Upper Explosion Limit: 6.0 Lower Explosion Limit: .7
Vapor Pressure: <10mm Hg @ 68 F. Vapor Density (Air=1): >1
Extinguishing Media: Foam, CO2, Dry Chemical
% Volatile: 100 pH: N/A
Special Firefighting Procedures: Do Not Use Water.
Solubility in Water: Nil Evaporation Rate (Water=1): >1
Unusual Fire and Explosion Hazards: Drums heated by fire can explode.
Physical Description: Thin colorless liquid with characteristic odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Carbon monoxide possible if burned. Incompatibility (Materials to Avoid): Strong oxidizers.
SECTION 6-STORAGE AND HANDLING INFORMATION
Keep out of reach of children. Combustible liquid. Avoid contact with excessive heat, spark or open flame. For use by trained personnel only. Keep unauthorized
personnel away when applying to floor. Keep container closed during storage. For institutional and industrial use only. Avoi d contact with eyes, skin and clothing.
Avoid breathing of vapors. Use in well-ventilated area. Empty container may contain explosive or flammable vapors.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Respiratory Protection: Use with adequate ventilation. Use NIOSH approved
Effects of Overexposure:
Hydrocarbon (Organic vapor) canister respirator when using in confined areas.
Skin: Prolonged or repeated contact may cause irritation, defatting of skin leading
to dermatitis. Ventilation Requirements: Provide explosion-proof ventilation to keep TLV of
Section 2 ingredients below acceptable limit.
Eyes: Eye irritant. May cause redness, swelling, or blurred vision.
Protective Gloves: Solvent proof neoprene or viton.
Inhalation: High concentration and/or long term exposure may irritate mucous
membranes of the respiratory tract. Headaches, dizziness and nausea, as well as Eye Protection: Chemical splash goggles or full-face shield.
unconsciousness may result from overexposure to high concentrations over Other Protective Equipment: Spark resistant tools are recommended. Eyewash
extended periods. and fire extinguisher provided nearby when using. Full protective outerwear and
Ingestion: Liquid ingestion may result in vomiting. Aspiration of material into the chemical resistant footwear when using.
lungs can cause pneumonitis and pulmonary edema/hemorrhage.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Steps to be taken in Case Material is Released or Spilled: Immediately shut off
Skin: Remove contaminated clothing. Wash with soap and water. Seek medical
all ignition sources. Dike or contain liquid. Avoid walking in product. Evacuate
attention if irritation persists.
unessential personnel. Mop up or otherwise absorb and hold disposal. Avoid
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
discharge to sewer or open waterways.
attention.
Waste Disposal Method: Any method in accordance with local, state and federal
Inhalation: Get to fresh air. If breathing is difficult, give oxygen. Seek medical
laws. Best method is to recycle or reuse for intended purpose. If discarded, this
attention if symptoms persist.
material and containers should be treated as hazardous waste based on the
Ingestion: Do not induce vomiting. DO NOT GIVE LIQUIDS. Seek medical
characteristic of ignitability as defined under federal RCRA regulations (40 CFR
attention immediately.
261). Do not dispose of into storm drain, stream, river or to ground. Rinse
container thoroughly before discarding in trash. Consult local or state
environmental officials for further information.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
Yes - Fire Hazard FOR CONTAINERS > 1 Gallon :, Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound Flammability 2
Yes - Immediate (acute) Health Hazard Reactivity 0
Yes - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from
the improper handling and use of this product
|