Natural Citrus Solvent Cleaners
Dissolve
Citrus Floating For Use On:
Degreaser
Septic Tanks Sludge Beds Drains
Septic Pumps Wet Wells Grease Traps
Sewage Lift Station
DESCRIPTION
This environmentally friendly, 100% biodegradable, citrus floating degreaser
is a fast acting natural way to maintain septic tanks, wet wells, sludge,
drying beds, drains, grease traps, sump pumps, and sewage lift
stations. Quickly dissolves grease and sludge build-up on liquid surfaces,
walls and tank bottoms.
DIRECTIONS
Liberally spray, sponge or mop this product on the surface to be cleaned.
Allow to stand 5 to 10 minutes, then rinse off with water under pressure.
TO CLEAN LIFT STATIONS, GREASE TRAPS, LINES, ETC.: Liberally
pour product into sump, trap or line at a time when flow is low to allow
maximum time for dissolving deposits. Amount of product will vary
depending on volume of water, thickness of deposits, and length of
time in contact with grease deposits before becoming diluted. Several
treatments may be necessary.
As a daily maintenance program, allow product to drip directly into wet
wells and pumping stations.
TO ELIMINATE SCUM CAKE AND LIQUIFY GREASE: Through any
opening in tank or well, add 15-20 gallons of product immediately followed
by 500-1000 gallons of water. Daily addition of 1-2 gallons in the sludge
compartment will allow effective and continuous treatment of both top and
bottom of grease cake. Circulation should be continued as usual.
PRODUCT SPECIFICATIONS
Active Ingredients: 100% Petroleum Distillates: None
Color: Clear Solubility: None with water
Odor: Strong citrus Emulsification: Excellent
115oF (TCC)
pH: N/A Flash Point:
Viscosity: Water thin Biodegradability: Complete
Foam: None Storage/Stability: 2 years
Abrasives: None Weight per Gallon: 7.01 lbs./gal.
Phosphate Content: None Freeze / Thaw Stability: Will not freeze
Misco Products Corporation 鈥? Reading, PA 鈥? (800) 548-4568 FAX (610) 926-1194
www.miscoprod.com
DIS MATERIAL SAFETY DATA SHEET N/A=Not Applicable
Prepared by: Regulatory Affairs Dept. Effective Date: 5/99 Revision: n/a
(Prepared According to 29 CFR 1910.1200)
SECTION 1-PRODUCT IDENTIFICATION AND SUPPLIER INFORMATION
Product Name: Dissolve
Manufacturer's Name:
Misco Products Corporation Generic Name: Citrus Floating Degreaser
Manufacturer's Address: Chemical Family: Terpene Solvent
1048 Stinson Drive Reading, PA 19605 Formula: Proprietary
Manufacturer's Phone #: (610) 926-4106
SECTION 2-INGREDIENT INFORMATION
CHEMICAL NAME CAS NO. WT. % PEL TWA-TLV STEL-TLV
Citrus Terpenes 5989-27-5 100
SECTION 3-PHYSICAL DATA SECTION 4-FIRE AND EXPLOSION HAZARD DATA
Flash Point (Method Used): 115 F. (TCC)
Boiling Point (掳F): 310 F. Initial Specific Gravity: 0.84
Upper Explosion Limit: 6.1 Lower Explosion Limit: 0.7
Vapor Pressure: 2mm Hg @ 68 F. Vapor Density (Air=1): 0.012
Extinguishing Media: Foam, CO2, dry chemical.
% Volatile: 100 pH: N/A
Special Firefighting Procedures: Do Not Use Water. Handle as oil fire.
Solubility in Water: Nil Evaporation Rate (Water=1): <1
Unusual Fire and Explosion Hazards: Drums heated by fire can explode.
Physical Description: Thin colorless liquid with citrus odor.
SECTION 5-REACTIVITY DATA
Stability: Stable Hazardous Polymerization: None
Hazards Decomposition Products: Carbon monoxide possible if burned. Incompatibility (Materials to Avoid): Strong oxidizers and acidic agents.
SECTION 6-STORAGE AND HANDLING INFORMATION
Combustible Liquid. Keep away from excessive heat, spark or open flames. Do not smoke while handling. Keep out of reach of children. For use by trained personnel
only. Keep container closed during storage. For institutional and industrial use only. Avoid contact with eyes, skin and clothing. Wear rubber gloves and eye protection
when handling. Avoid breathing of vapors. Use in well-ventilated area. Empty container may contain explosive or flammable vapors.
SECTION 7-HEALTH HAZARDS AND FIRST AID SECTION 8-SPECIAL PROTECTION INFORMATION
Effects of Overexposure: Respiratory Protection: Use with adequate ventilation. Use NIOSH approved
Skin: Prolonged or repeated contact may cause irritation, defatting, or dermatitis. Hydrocarbon (Organic vapor) canister respirator when using in confined areas.
Eyes: Eye irritant. May cause redness, swelling, or blurred vision. Ventilation Requirements: Provide explosion-proof ventilation to keep TLV of
Section 2 ingredients below acceptable limit.
Inhalation: May be irritating to the nose, throat, and lungs. Large amounts can
cause headache, nausea, dizziness, weakness, and fatigue. Protective Gloves: Solvent proof rubber or viton.
Ingestion: Can cause irritation of the gastrointestinal tract, nausea, vomiting, and Eye Protection: Chemical splash goggles or full-face shield.
diarrhea. Aspiration of material into the lungs can cause pneumonitis. Other Protective Equipment: Eyewash station should be nearby. Protective
chemical resistant outerwear when conditions exist where body contact is possible.
First Aid Procedures: SECTION 9-SPILL OR LEAK PROCEDURES
Skin: Remove contaminated clothing. Wash with soap and water. Seek medical Steps to be taken in Case Material is Released or Spilled: Floors will become
attention if irritation persists. slippery. Avoid walking in product. Keep unessential personnel away. Mop up or
otherwise absorb and hold disposal. Avoid discharge to sewer or open waterways.
Eyes: Flush with large quantities of water, holding eyelids open. Seek medical
attention. Waste Disposal Method: Any method in accordance with local, state and federal
laws. Best method is to recycle or reuse for intended purpose. If discarded, this
Inhalation: Get to fresh air. If breathing is difficult, give oxygen. Seek medical
material and containers should be treated as hazardous waste based on the
attention is symptoms persist.
characteristic of ignitability as defined under federal RCRA regulations (40 CFR
Ingestion: Do not induce vomiting. Seek medical attention immediately.
261) Consult local authorities for disposal in public sewer. Do not dispose of into
storm drain, stream, river or to ground. Rinse container thoroughly before
discarding in trash.
SECTION 10-REGULATORY INFORMATION
HMIS Hazardous Materials
SARA Title III - Section 311/312 -Hazard Categories: Shipping Information:
Yes - Fire Hazard FOR CONTAINERS > 1 Gallon : Cleaning Compound Identification System
No - Sudden Release of Pressure Hazard Health 2
No - Reactivity Hazard FOR 1 GALLON CONTAINERS : Cleaning Compound Flammability 2
Yes - Immediate (acute) Health Hazard Reactivity 0
No - Delayed (chronic) Health Hazard FOR CONTAINERS < 1 GALLON : Cleaning Compound Personal Protection B
FOR EMERGENCY MEDICAL OR TRANSPORT INFORMATION: CHEM-TEL, Inc. @ 800-255-3924 (24 hours, 7 days per week)
This product contains the following toxic chemical(s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-To-Know Act
of 1986 and of 40 CFR 372.
CAS# Chemical Name Percent by Weight
None
This product contains the following chemical(s) which have been established to be either a carcinogen or suspected carcinogen.
CAS# Chemical Name Percent by Weight
None
SECTION 11-OTHER INFORMATION
This company cannot anticipate all conditions of handling and use of this product. Therefore, this company accepts no responsibility for results obtained by the
application of this information, or the safety and suitability of our products either alone or in combination with other products. It is the responsibility of the user to
provide a safe workplace, using the health and safety information contained herein as a guide. This company will accept no liability for damages or loss incurred from
the improper handling and use of this product
|