CPD庐 HARD-CURE
DESCRIPTION LIMITATIONS
CPD庐 Hard-Cure is a curing and surface hardening 鈥? do not use in concentrate form
compound supplied in a concentrate form. CPD庐 Hard- 鈥? do not apply on glass, brick or aluminum surfaces
Cure must be diluted as directed prior to use. 鈥? not recommended for carbonated concrete (very old floors
should be tested for this condition before treating).
WHERE TO USE
鈥? curing new concrete or hardening and dustproofing COVERAGE
existing concrete floors 鈥? When used in a diluted form as per application
鈥? suitable for concrete floors in warehouses, industrial instructions
plants, commercial and residential buildings 鈥? Curing New Concrete - 2.50-4 m虏/L (100-165 ft虏/U.S.
鈥? water based with no fumes or flammability hazard gallon)
鈥? Cured Concrete - 5 m虏/L (200 ft虏/U.S. gallon) for the first
BENEFITS coat. Higher coverage for the following coats depending
鈥? water based - no fumes or fire hazard on density of concrete floor.
鈥? economical solution to dustproofing and hardening
concrete floors STANDARDS
鈥? imparts a semi-gloss finish to concrete floors Approved for use on surfaces in contact with potable water
by the Ministry of Environment, Ontario.
APPLICATION
New Concrete (Curing): PACKAGING
For use in curing new concrete cover once set with wet 208L (55 U.S. gal) drum - 299 kg (659 lbs.)
burlap and keep wet for a period of 24 hours. After this 18.9L (5 U.S. gal) pail - 33 kg (73 lbs.)
period, remove the burlap and apply CPD庐 Hard-Cure 3.79L (1 U.S. gal) pail - 26 kg (57 lbs.)/case (4 per case)
diluted as follows: 4 parts by volume of CPD庐 Hard-Cure
with 1 part by volume of potable water. This solution is CLEAN UP
best applied by push broom or brush. This application Clean all tools and equipment immediately after using with
forms a surface seal to assure minimum moisture lose for clean water.
proper curing of the concrete.
STORAGE
Cured Concrete (for surface hardening/dustproofing): Protect from freezing.
Clean floor thoroughly using an alkaline concrete detergent
only. DO NOT ACID WASH. Rinse with water and allow SHELF LIFE
to dry thoroughly. Dilute CPD庐 Hard-Cure with potable Two years stored under normal heated warehouse
water (1pt./4pts. Water by volume). Apply the diluted conditions in original unopened containers.
product by roller, push broom or spray. Avoid leaving
puddles. Allow to dry overnight then thoroughly wash with SAFETY PRECAUTIONS
clean water. Allow to thoroughly dry then re-apply as per Consult Material Safety Data Sheet (M.S.D.S.) for specific
first coat. Once again, wash with clean water once floor instructions. M.S.D.S. # 57.
has dried. A third application may be required for some
floors. NOTE: When using CPD庐 Hard-Cure on concrete, WARRANTY
the concrete must be thoroughly cured (28 days minimum). The recommendations made and the information herein is
based on our own and independent laboratory experience,
and is believed to be accurate under controlled conditions.
However, no warranty or guarantee of accuracy is made
because we cannot cover every possible application of
product nor anticipate every variation encountered in
0339-13-1105
weather conditions, job conditions, methods used and types
of surfaces on which the product is applied. The users shall
make their own tests to determine the suitability of such
products for any particular use.
CPD庐 makes no warranties with respect to this product,
expressed or implied, without limitation, the implied
warranties of merchantability or fitness for a particular
purpose.
CPD庐鈥? liability shall be limited in all events to supplying
s
sufficient product to re-treat and/or repair the specific area
to which CPD庐 product has been applied. CPD庐 reserves
the right to have the true cause of any difficulty determined
by accepted test methods. CPD庐 shall have no other liability
for incidental, consequential or resultant damages, however
caused, whether due to breach of warranty, negligence, or
strict liability.
THIS WARRANTY MAY NOT BE MODIFIED OR
EXTENDED BY REPRESENTATIVES OF CPD庐, ITS
DISTRIBUTORS OR DEALERS.
|